Chevrolet · Model Report
Showing safety data for the 2007 model year only.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.
No injuries · No fire · No crash
The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy in a crash. The vehicle has also experienced ongoing electrical problems, including lighting failures, blown fuses, and shift-interlock malfunctions, which suggests an electrical system fault affecting multiple safety-related systems. These issues create concern that the airbag control system may be impacted by the same electrical malfunction. The vehicle has not been repaired or diagnosed by a dealer for the airbag issue. The condition is still present and the warning light remains illuminated. This failure creates a serious safety risk because the airbags may not function in the event of a collision.
No injuries · No fire · No crash
The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.
No injuries · No fire · No crash
The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver’s side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.
No injuries · No fire · No crash
Out of no where it cought on fire