Chevrolet Aveo Recalls

4 recalls on file.

• Recall14V460000July 29, 2014
  SERVICE BRAKES, HYDRAULIC:FLUID

  General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Aveo and 2009 Pontiac G3 vehicles. The vehicles may contain brake fluid which does not protect against corrosion of the valves inside the anti-lock brake system (ABS) module, affecting the closing motion of the valves.

  Remedy

  GM will notify owners, and dealers will replace the ABS module, free of charge, in any vehicle that did not have its module replaced under a previous customer satisfaction campaign. The recall began in late September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), and 1-800-762-2737 (Pontiac). GM's number for this recall is 14505.

• Recall14V261000May 19, 2014
  EXTERIOR LIGHTING:HEADLIGHTS

  General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

  Remedy

  GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

• Recall06V398000October 17, 2006
  FUEL SYSTEM, GASOLINE

  ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.

  Remedy

  DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

• Recall04V407000August 17, 2004
  SEAT BELTS:REAR/OTHER

  ON CERTAIN PASSENGER VEHICLES, THE REAR SAFETY BELT CAN BECOME TWISTED.

  Remedy

  DEALERS WILL INSTALL A SAFETY BELT WEBBING GUIDE TO PREVENT THE BELT FROM TWISTING. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438. VEHICLE OWNERS LOCATED IN GUAM SHOULD CONTACT GM CUSTOMER ASSISTANCE AT 1-671-648-8453.