BMW Z3 Complaints

253 consumer complaints on file.

#10404652May 30, 2011
AIR BAGS
UPON STARTING THE CAR THE AIR BAG LIGHT CAME ON AND STAYED ON. THIS IS THE THIRD TIME THIS HAS HAPPENED. THE FIRST TWO TIME IT COST APPROXIMATELY $350 TO REPAIR. FOR THIS TO HAPPEN A THIRD TIME IS INDICATIVE OF A DESIGN FAULT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397393April 25, 2011
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 1998 BMW Z3M ROADSTER. THE CONTACT WAS TRAVELING 25 MPH WHEN THE REAR FRAME OF THE VEHICLE FRACTURED COMPLETELY. THE CONTACT TOWED THE VEHICLE TO THE DEALER WHERE THEY ADVISED THAT THE FRAME METAL WAS EXTREMELY WEAK AND CAUSED THE FRAME TO DROP AND THE REAR AXLE TO FRACTURE FROM THE VEHICLE. THE CONTACT WAS CONCERNED BECAUSE HE COULD HAVE BEEN INVOLVED IN A CRASH IF HE WERE TRAVELING FASTER IN THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10389650March 9, 2011
STRUCTURE:FRAME AND MEMBERS
REAR SUBFRAME ON VEHICLE HAS TORN FROM THE REAR UNDER PANEL ON VEHICLE. THE TRUNK FLOOR ON VEHICLE IS FALLING OUT FROM UNDERNEATH, THIS POSES A MASSIVE SAFETY ISSUE. WAS TOLD BY TECHNICIAN VEHICLE IS NO LONGER SAFE TO OPERATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378668January 25, 2011
POWER TRAIN
TL* THE CONTACT OWNS A 1999 BMW Z3. THE CONTACT STATED THAT THE VEHICLE WAS INCREASINGLY HARD TO CONTROL AND THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR AN ALIGNMENT. THE MECHANIC ADVISED THE CONTACT THAT THE REAR DIFFERENTIAL HAD FAILED AND WAS CAUSING THE WHEELS TO FRACTURE FROM THE SUB FRAME. THE MECHANIC ALSO ADVISED THE CONTACT OF THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 99V272000 (POWER TRAIN: DRIVELINE: DIFFERENTIAL UNIT). THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS ADVISED TO HAVE THE VEHICLE TOWED TO THE DEALER. THE VEHICLE WAS TOWED AND THE CONTACT WAS AWAITING DIAGNOSIS AND REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378233January 22, 2011
STRUCTURE:FRAME AND MEMBERS
MY 1999 BMW Z3 ROADSTER BEGAN DRIVING FUNNY AND MAKING SQUEAKING NOISES, IN THE REAR. THEN I NOTICED THE BACK TIRES, WERE STARTING TO KICK OUT AND LOOK STRANGE. THEN MY CAR BEGAN MAKING A BAD VIBRATING SOUND, COMING FROM THE BACK TIRES, WHEN I WAS IN FIRST GEAR. I TOOK IT TO SHOP. THEY JACKED IT UP, AND FOUND, THAT THE DIFFERENTIAL UNIT, HAS SEPARATED FROM THE SUB-FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10372319December 24, 2010
STRUCTURE:FRAME AND MEMBERS
1998 Z3 SUBFRAME FAILURE. I'M WORRIED MY DIFFERENTIAL OR REAR END WILL FAIL DURING DRIVING AND BMW REFUSES TO FIX IT. THIS IS A SAFETY CONCERN FOR EVERYONE ON THE ROAD. BMW HAS INSPECTED MY CAR, ACKNOWLEDGED THE PROBLEM, AND BLAMED THE FAILURE ON THE MODIFICATIONS I MADE TO THE CAR, HOWEVER, THE PROBLEM IS OCCURRING IN A VERY HIGH NUMBER OF UN-MODIFIED Z3 VEHICLES AS WELL. THERE IS ALSO A CLASS ACTION LAWSUIT FOR THE SAME EXACT PROBLEM ON E46 MODELS (Z3 IS NOT AN E46) AND BMW IS FIXING THE E46 BUT NOT THE Z3. THIS IS A VERY DANGEROUS SITUATION AND SOMEONE IS GOING TO BE KILLED EVENTUALLY B/C OF THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10371628December 18, 2010
UNKNOWN OR OTHER
I TURNED THE KEY TO START THE VEHICLE. IT STARTED NORMALLY. I PUT THE CAR IN NEUTRAL (5 SPEED TRANS.) TO ALLOW IT TO WARM-UP FOR ABOUT 2 MINUTES WHILE I CHECKED MY VOICE MAIL ON MY PHONE. AS I PUT THE CAR IN GEAR AND LOOKED OUT THE WINDSHIELD TO PULL OUT OF MY PARKING SPACE, I SAW DENSE WHITE SMOKE ROLLING OUT FROM UNDER THE HOOD ON THE DRIVER'S SIDE. I LOOKED AT THE DASH FOR ANY WARNING OR INDICATOR LIGHTS; THERE WERE NONE. I IMMEDIATELY TURNED THE CAR OFF, POPPED THE HOOD, AND GOT OUT OF THE CAR. I WANTED TO WAIT UNTIL THE SMOKE WAS NO LONGER ROLLING OUT BEFORE ACTUALLY OPENING THE HOOD, AS I WAS AFRAID OF INTRODUCING A RUSH OF AIR IF SOMETHING WAS ON FIRE. AS THE SMOKE RAPIDLY INCREASED AND PROGRESSED TO BLACK SMOKE, I CALLED MY FACILITY SECURITY FROM AN EMERGENCY CALL BOX WHILE ALSO CALLING 911 FROM MY CELL PHONE. DURING THE 911 CALL, FLAMES BECAME VISIBLE FROM UNDER THE HOOD. FOUR FIRE ENGINES ARRIVED TO PUT OUT THE FIRE. ALL FOUR LEVELS OF MY FACILITIES PARKING DECK WERE FILLED WITH TOXIC SMOKE WHICH WAS EVACUATED BY THE FIRE DEPARTMENT. THE CAR WAS A TOTAL LOSS. THE FIRE DEPT. TOLD ME THAT NIGHT THAT THE CAR WAS TOO BADLY BURNED TO DETERMINE THE CAUSE. THEY SUPPOSED IT WAS ELECTRICAL. AFTER INSPECTING THE CAR, THE INSURANCE INVESTIGATOR DID NOT BELIEVE THE FIRE TO BE FROM ELECTRICAL ORIGIN, BUT INSTEAD FUEL / ENGINE RELATED. THE CAR HAD BEEN MAINTAINED ON A REGULAR BASIS. NO SERVICE HAD BEEN RECENTLY PERFORMED. I HAD NOT BEEN EXPERIENCING ANY ISSUES WITH THE CAR'S PERFORMANCE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10369086December 3, 2010
SEAT BELTS
MY 1997 BMW Z3 HAD THE AIRBAG LIGHT COME ON 2 YEARS AGO. THE TECHNICIAN SAID IT WAS CAUSED BY THE SEATBELT TENSIONER. HE REPLACED IT AND ALL WAS FINE. IT'S BACK ON AGAIN. IF THIS IS AS COMMON TO THESE MODELS AS I'VE HEARD WHY HASN'T BMW HAD A RECALL TO FIX THE PROBLEM. THIS IS GETTING EXPENSIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360272October 13, 2010
AIR BAGS:SIDE/WINDOW
TL*THE CONTACT OWNS A 2000 BMW Z3. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH INTO AN INTERSECTION, UNEXPECTEDLY AN OPPOSING VEHICLE CRASHED INTO THE FRONT DRIVER SIDE DOOR. THE AIR BAGS FAILED TO DEPLOY UPON IMPACT. THE CONTACT SUSTAINED SEVERE INJURIES CONSISTING OF A BROKEN COLLAR BONE, EIGHT BROKEN RIBS AND PUNCTURED LUNGS. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL BY AMBULANCE. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO A COLLISION FACILITY. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000. THE VIN WAS UNAVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10360392October 13, 2010
STRUCTURE:FRAME AND MEMBERS, SUSPENSION:REAR
NORMAL DRIVING RESULTED IN FRAME FAILURE AT THE DIFFERENTIAL MOUNTING POINT. THE ENTIRE DIFFERENTIAL MOUNT BROKE LOOSE FROM THE FRAME AND THE CROSS FRAME IS BROKEN IN TWO PLACES.. THE VEHICLE ALSO HAS TRUNK FLOOR PAN SPOT WELDS BREAKING LOOSE. THE PROBLEMS RESULT IN A REAR AXLE ASSEMBLY THAT IS LOOSE AND STEERS THE CAR ERRATICALLY. THE CAR IS UNSAFE TO DRIVE AT THIS TIME DUE TO ERRATIC HANDLING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358612October 1, 2010
SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL (ESC)
2001 BMW Z3 3.0L. THE ABS/DSC SYSTEM MALFUNCTIONS. WHILE DRIVING AT VARYING SPEEDS THE BRAKES ENGAGE ON THEIR OWN, CAUSING THE RIGHT FRONT BRAKE TO APPLY AND PULL THE CAR TO THE RIGHT. THIS HAS HAPPENED AT VARIOUS SPEEDS ON SEVERAL OCCASIONS. IT IS INCREDIBLY DANGEROUS SINCE IT COULD CAUSE A DRIVER TO LOOSE CONTROL. THE ACTIVATION OF THE BRAKES HAPPENS WHILE DRIVER'S FOOT IS ON ACCELERATOR, NO WHERE NEAR THE BRAKE PEDAL. AFTER THIS OCCURS THE BRAKE AND ABS LIGHTS DISPLAY ON THE INSTRUMENT PANEL. THIS DISAPPEARS WHEN THE CAR IS TURNED OFF AND THEN BACK ON, HOWEVER, THE CONDITION HAPPENS AGAIN. THERE IS NO ROAD ISSUES THAT WOULD CAUSE THIS. IT HAPPENS WHILE DRIVING STRAIGHT OR ON A CURVE. THERE IS NO REASON FOR IT TO HAPPEN. IT IS DANGEROUS! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10341018July 1, 2010
POWER TRAIN
Z3 SUBFRAME PROBLEM. POSSIBLE DETACHMENT OF DIFFERENTIAL FROM CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340816June 30, 2010
SUSPENSION:REAR
1999 BMW Z M ROADSTER REAR GEARBOX(DIFF) TEARING FROM CAR. ALL WELDS ARE BROKEN AND SUPPORT IS TORN IN HALF IN PLACES AND CRACKED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336091June 13, 2010
AIR BAGS
THE AIRBAG FAULT LIGHT CAME ON IN OUR 1998 BMW Z3 (WITH LESS THAN 16,000 MILES ON THE ODOMETER), INDICATING THE AIRBAG (OR AIRBAGS) AND SEAT BELT TENSIONERS WERE NO LONGER FUNCTIONING. THE DEALER SERVICE REPRESENTATIVE SAID THIS WAS "A COMMON PROBLEM" WITH THIS MODEL AND TOLD US EXACTLY WHAT MOST LIKELY CAUSE OF THE PROBLEM PRIOR TO ANY DIAGNOSTICS'THAT THERE WAS A FAULT IN THE SEATBELT LATCH AND WIRING THAT CAUSED 'HIGH RESISTANCE'. THE COST OF REPAIRS WAS $825. A GOOGLE SEARCH SHOWS THIS SAME PROBLEM IS ESSENTIALLY UBIQUITOUS. I SEARCHED FOR 'BMW Z3 AIRBAG LIGHT ON', AND I GOT NEARLY 40,000 HITS. LOOKING RANDOMLY AT SOME OF THESE HITS, I FIND EACH CONTAINS MULTIPLE ACTUAL INSTANCES OF THIS PROBLEM OCCURRING. FOR EXAMPLE, THE FIRST RESULT RETURNED (HTTP://WWW.AUTOMOTIVEFORUMS.COM/T145936-Z3_AIRBAG_SENSORS.HTML) INDICATED AT LEAST 6 VEHICLES WITH THIS EXACT SAME PROBLEM. THUS, I WOULD ESTIMATE FROM THE GOOGLE SEARCH THAT THIS PROBLEM HAS AFFECTED 100,000+ VEHICLES JUST COUNTING THOSE POSTED ON THE INTERNET'PLUS ALL OF THOSE THAT ARE NOT POSTED ON THE INTERNET. THE BMW Z3 WAS A LOW VOLUME VEHICLE, SO IT WOULD APPEAR THIS SIGNIFICANT SAFETY DEFECT AFFECTS A VERY LARGE PERCENTAGE OF THESE VEHICLES. ASIDE FROM THE FINANCIAL BURDEN OF OWNERS REPAIRING THIS VERY DANGEROUS DEFECT, I SUSPECT MANY OWNERS SIMPLY CHOOSE NOT TO HAVE THE POTENTIALLY DEADLY SAFETY DEFECT REPAIRED DUE TO THE COST OF THE REPAIRS. BMW SHOULD BE REQUIRED TO CORRECT THEIR DESIGN DEFECT AND REIMBURSE OWNERS WHO HAVE INCURRED PERHAPS $100,000,000 IN REPAIRS FOR THIS SEVERE AND DEADLY DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10334640June 4, 2010
EQUIPMENT:MECHANICAL, ENGINE AND ENGINE COOLING
I HAVE A Z3 2001. THE CAR KEEPS STALLS WHILE DRIVING. THE BMW SERVICE DEPARTMENT IN COLUMBUS OHIO HAS BEEN UNABLE DETERMINE THE PROBLEM AND ARE UNABLE TO REPAIR IT. THEY SAID IT WAS A FUEL PUMP, THEN SAID IT WAS THE IDLE CONTROL VALVE THEN SAID THEY STILL DO NOT KNOW WHAT IS WRONG WITH IT.. THEY'VE HAD IT ON AND OFF SINCE MAY 6. (ABOUT ONE MONTH). THE CAR IS UNSAFE TO DRIVE WHILE STALLING WITHOUT WARNING. THE ENGINE LIGHT DOES NOT COME ON AFTER THE CAR STALLS. I DO NOT FEEL SAFE DRIVING A CAR THAT STALLS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310014February 12, 2010
AIR BAGS
AIR BAG LIGHT ON. SHOP MECHANIC STATED "RETRIEVED DTC CODE FOR DRIVERS SEAT BELT SWITCH OPEN OR SHORT CIRCUIT. CLEANED CONNECTORS, CLEARED DTC INFO OPERATIONAL CHECK OK. IF FAULT RECURS, RECOMMEND REPLACEMENT OF DRIVERS SEAT BELT LATCH ASSEMBLY." PROBLEM FIXED JUNE 18, 2008. NOW PROBLEM WITH AIR BAG LIGHT ON IS BACK. THERE SEEM TO BE A LOT OF PROBLEMS WITH AIR BAG SENSORS AND SEAT BELT LATCHES ON VARIOUS BSM VEHICLES ACCORDING TO INTERNET SEARCHES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10285850September 30, 2009
SEATS
TL*THE CONTACT OWNS A 1998 BMW Z3. DURING ACCELERATION AND DECELERATION THE FRONT PASSENGER AND DRIVER SEAT ADJUSTOR RAIL FAILED. AS A CONSEQUENCE, THE SEAT MOVED BACK AND FORTH WHILE THE CONTACT WAS DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, BUT NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 50,000. THE CURRENT MILEAGE WAS 65,000. UPDATED 11/09/09 *BF THE CONSUMER STATED BMW KNEW THERE WAS A PROBLEM AND THERFORE, THEY CHANGED MATERIAL USED IN THE ISOLATER PADS. UPDATED 11/09/09
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10270028May 27, 2009
TIRES:VALVE, EQUIPMENT
TL*THE CONTACT OWNS A 2001 BMW Z3. THE CONTACT STATED THAT ALL FOUR VALVE STEMS HAD TO BE REPLACED ON HIS VEHICLE BECAUSE THEY WERE CRACKED AND CAUSED AIR TO LEAK FROM THE TIRES. THE VALVE STEMS WERE TECH INTERNATIONAL, MODEL TR413. THE TIRES WERE MANUFACTURED BY TOYO. THE PART NUMBER AND SERIAL NUMBER FOR THE VALVE STEMS WERE UNKNOWN. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 29,861.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246665October 24, 2008
AIR BAGS:FRONTAL
TL*THE CONTACT OWNS A 2000 BMW Z3. WHILE DRIVING 75 MPH, THE CONTACT HEARD A LOUD BANG. HE NOTICED THAT THE PASSENGER SIDE AIR BAG DEPLOYED, BUT NO ONE WAS STRUCK. HE FILED A REPORT WITH BMW AND WAS INFORMED THAT SOMEONE FROM THE CORPORATE OFFICE WOULD CALL HIM REGARDING THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244619October 7, 2008
AIR BAGS
PASSENGER AIR BAG FAILURE. PRESSURE SWITCH IN PASSENGER SEAT FAILED. HAS NOT BEEN REPAIRED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW Z3