BMW i8 Service Bulletins
245 manufacturer communications on file.
- August 1, 2016•Document ID: 10147015Service Bulletin/Repair InstructionsSERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING
- Mfr Comm. #:
- B340616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"DSC ""WHEEL SPEED SENSOR"" FAULT CODES AND MALFUNCTION INDICATOR LAMP- DIAGNOSTIC. 1. DSC's fault codes stored from two different wheel speed sensors (both front or both rear): 4809B0 - wheel speed sensor - front left - drive off recognition faulty and 4809CD - wheel speed sensor - front right - drive off recognition faultyor 4809B9 - wheel speed sensor - rear left - drive off recognition faulty and 480686 - wheel speed sensor - rear right - drive off recognition faulty. 2. Next ignition ON (after above codes stored). a) DME fault can occur:1F054D - drive, safety function: Drive power output reduced, DSC signals implausible and b) Malfunction Indicator Lamp (MIL) may light up. Faulty drive off recognition due to: a towing operation with a raised axle operation of the vehicle on the vehicle hoist operation of the vehicle on the roller test stand DSC diagnosis recognizes implausible wheel speeds, so no control is possible. DME fault is entered on safety grounds since the DSC fault still exists after a terminal change and may only be removed while driving."
Associated Products (51)Associated Documents - July 1, 2016•Document ID: 10147551Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B620516
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummaryHead-up Display is no Longer Visible. HUD (Head-up Display) adjusted to the lowest position is no longer visible. Software in the instrument cluster
Associated Products (11)Associated Documents - July 1, 2016•Document ID: 10147545Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- B512316
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummarySNOW IN ENTRANCE AREA. CAUSE Excessive clearance in door sill area. CORRECTION Replace entrance cover and entrance molding on both sides.
Associated Products (3)Associated Documents - July 1, 2016•Document ID: 10147544Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- B512016
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummaryDoor Will Not Go Up All The Way. The driver's side or passenger's side door may not open to the highest position. Insufficient lifting force from gas pressurized damper spring.
Associated Products (4)Associated Documents - June 1, 2016•Document ID: 10151375Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B621016
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryHeadUp Display does not Show Full Street Names. INFORMATION Design of the HUD has limited display area. (It can only show a certain number of text characters). NOTE: Parts replacement or programming the vehicle will not recitify the situation!
Associated Products (168)Associated Documents - June 1, 2016•Document ID: 10151371Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610816
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"DC/DC Converter does not supply sufficient 12V power. Customer probably has a CCM stating ""Battery is not charged"" (CCM-ID: 213) is displayed. Customer may report a variety of other issues: Erratic KOMBI behavior Malfunction of any device powered by 12V electrical Vehicle not starting, or reduced 12V power while driving Vehicles from production date 10/1/2015 with the following software levels: I01: 15-11-501 up to and including 16-07-500 I12: 15-11-501 up to and including 16-03-503 CAUSE EME Software"
Associated Products (10)Associated Documents - June 1, 2016•Document ID: 10151370Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610416
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"SI B61 04 16 General Electrical June 2016 Technical Service EME Fault Code 222C02 Following Replacement or Programming- Diagnosis. Programming, (e.g. following replacement), can cause EME fault code ""222C02 - Electronic immobilizer protection against tampering: expected response implausible"" to be stored. After clearing, the fault comes back during a test drive. Improper EME software"
Associated Products (10)Associated Documents - June 1, 2016•Document ID: 10151367Service Bulletin/Repair InstructionsSTEERING:COLUMN; STEERING
- Mfr Comm. #:
- B511916
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"STEERING COLUMN STALK SWITCH STICKING. The steering column stalk switch for the turn signal sticks when actuating ""headlight flasher"" mode. Interference fit between stalk switch and upper steering column shroud."
Associated Products (5)Associated Documents - June 1, 2016•Document ID: 10151361Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING
- Mfr Comm. #:
- B340316
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryErroneous Wheel Speed Sensors Plausibility Faults - Diagnosis. INFORMATION These faults do NOT indicate brake system malfunction, or cause Check Control message display. Do not replace any parts! Perform a 12V battery reset and clear the fault memory. In case one of the plausibility faults returns after a short test drive, diagnose it using the corresponding ISTA test plan for the wheel speed sensor faults.
Associated Products (5)Associated Documents - May 1, 2016•Document ID: 10151335Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B840314
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryBluetooth Connection Failures. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle. Contact List incomplete General connection failures Apple iOS software (issue started with iOS 8.3 continues with iOS 9.x and its variants) Samsung S6 and S6 Edge device firmware.
Associated Products (264)Associated Documents - May 1, 2016•Document ID: 10151316Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES:DOORS:LATCH; STRUCTURE:BODY:DOOR
- Mfr Comm. #:
- B511316
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryDifficult to Unlock Vehicle with Mechanical Key. Lock cylinder difficult to turn when unlocking with mechanical key. CAUSE Door lock actuator
Associated Products (5)Associated Documents - April 14, 2016•Document ID: 10216791Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- TEC24
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryTech24 Snap-in Adapter Return
Associated Products (59)Associated Documents - April 1, 2016•Document ID: 10216793Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TEC26
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryTEC26 Turbo Charger Return
Associated Products (59)Associated Documents - April 1, 2016•Document ID: 10151271Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:AIR CONDITIONER
- Mfr Comm. #:
- B640816
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryReduced or No HVAC Heat Output. I12 & F30 PHEV - The heat is not functioning during electric driving and/or the heat output is reduced or fluctuating when driving with the combustion engine. I01 - The heat is not functioning at all. The issue can occur sporadically for all vehicles and will not have any associated fault codes. IHKA software with I-Level: I01, I12I001-15-11-504 F30 PHEV F020-15-11-505
Associated Products (10)Associated Documents - April 1, 2016•Document ID: 10151256Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; ELECTRICAL SYSTEM; EQUIPMENT:APPLIANCE:AIR CONDITIONER
- Mfr Comm. #:
- B122715
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryThis Service Information bulletin supersedes SI B12 27 15 dated November 2015 SUBJECT Service Engine Soon (MIL) - IHKA FC 801375 & 8013A3. The Service Engine Soon light (MIL) is currently or intermittently illuminated in the instrument cluster and one or both of the fault codes below are stored in the Automatic Climate Control (IHKA). 801375 - Electric auxiliary heater (high voltage) is stored: Temporary fault detected after software reset CAUSE: IHKA software or Electric Heater (EH).
Associated Products (10)Associated Documents - March 21, 2016•Document ID: 10216792Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TEC25
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryTec25 Wishbone Return
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10216758Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SIM110115
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryMINI engine oil part number transition and model year 2016 engine oils
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10216757Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SIM010603
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryMINI "Enhanced" dealer self authorized (DSA)K goodwill program
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10151203Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- B660416
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"""Comfort Access Restricted"" Check Control Message is Displayed. ""Comfort Access Restricted"" CCM (Check Control Message) is permanently displayed.. The CCM ID: D0h. The comfort access is functioning correctly. No comfort access aerial fault codes stored in the BDC (Body Domain Controller). Software error in the BDC"
Associated Products (17)Associated Documents - March 1, 2016•Document ID: 10151201Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B652615
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryHissing Noise from Speakers when Radio Volume is Turned Down. There is an audible hissing noise from the speakers when there is no active audio source. This noise is most apparent with the engine and climate system fan turned off. Software in the HK HiFi amplifier.
Associated Products (18)Associated Documents