BMW of North America, LLC (BMW) is recalling certain 2020 750i xDrive, 2019 M850i xDrive Coupe, M850i xDrive Convertible, X5 xDrive50i, X7 xDrive50i, and M5 vehicles. The high pressure fuel pump may not have been properly attached to the engine, which may cause the fuel pump flange to crack, resulting in a fuel leak.
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
BMW of North America, LLC (BMW) is recalling certain 2013-2015 740i, 740Li, 740Lxi, 750i, 750xi, 750Li and 750Lxi and 2014 ActiveHybrid 7 vehicles. The affected vehicles may have received incorrect replacement left rear taillight assemblies. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
BMW of North America, LLC (BMW) is recalling certain 2005-2008 745i, 745Li, 750i, 750Li, 760i, 760Li, and B7 Alpina vehicles equipped with both the Comfort Access and Soft Close Automatic options. In these vehicles, the doors may appear to be closed and latched, but, in fact, may inadvertently open.
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
The contact owns a 2021 BMW 750i. The contact stated that while driving at an undisclosed speed, the engine independently shut off. The engine overheating warning light illuminated, and the message "Engine Cooldown" was displayed. After several attempts, the vehicle restarted. The vehicle was taken to the dealer, where it was diagnosed with a failed engine starter that needed replacement. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with any recalls related to the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 84,000.
No injuries · No fire · No crash
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The suspected failed component is the front differential carrier bearing on my 2021 BMW 750i xDrive. [XXX] BMW of Westmont, Illinois diagnosed carrier bearing damage and oil leaks and recommended replacement of the front differential. The vehicle has approximately 53,791 miles. The failed differential/carrier-bearing assembly is currently available for inspection, subject to the vehicle remaining at the dealership and before the component is replaced or discarded. I have specifically requested that BMW and the dealership retain the failed component if inspection or engineering analysis is necessary. The dealership's repair order is XXX, dated XXX. 2. How was your safety or the safety of others put at risk? The vehicle developed a significant grinding noise during acceleration from a stop. The grinding continues for approximately 5–15 seconds, depending on how long the vehicle is under acceleration, and goes away after the vehicle reaches approximately 30–40 MPH. I am concerned that failure of a major front drivetrain component could result in an unexpected loss or interruption of proper power transfer, particularly during acceleration from a stop or at low speeds. The vehicle also has a documented differential oil leak progressing to a drip. I am concerned that continued loss of differential lubricant could contribute to further mechanical damage or failure. I have therefore limited use of the vehicle while seeking diagnosis and determining the appropriate repair. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The vehicle was inspected by Laurel BMW of Westmont, Illinois, an authorized BMW service center. The dealer documented the customer's complaint as a grinding noise when accelerating from a stop and documented the diagnosis: “Front differential replacement due to carrier bearing ,oil leaks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),
No injuries · No fire · No crash
Took my 2020 BMW 7 Series into BMW San Diego because there was fluid leaking. Upon diagnosis at the dealership, I was notified I needed to replace the front differential as it was coming apart. The leaking fluid was identified as differential fluid. The vehicle has 54,308 miles on it. My research indicates front differentials should not need replacement until nearly 150,000 miles. A broken front differential is considered to be very bad and makes a car unsafe to drive as it causes severe handling issues, loss of control and potential damage to the transmission. A broken differential can cause the vehicle to lock up or lose steering control. Me and my family have been at risk as it is unclear how long this issue has been happening. The problem has been confirmed by BMW San Diego. The cost to replace was quoted as about $10,251. There are no warning lamps, and there are no messages indicating there is a problem with the vehicle. Not sure when the issue started. Apparently, due to my research I’ve learning many 2020 BMW’s seem to need to have the front differential replaced with mileage between 38,000 and 55,000.
No injuries · No fire · No crash
The contact owns a 2006 BMW 750I. The contact received notification of NHTSA Campaign Number: 17V328000 (Latches/Locks/Linkages). The contact stated that the passenger's side rear door had failed to function as intended and failed to open. Additionally, the handle on the driver's side rear door intermittently failed to function as intended and required to be hit to function as intended. The vehicle was taken to the dealer; however, the dealer was unable to perform the recall repair because the door latch system on the vehicle was old. The manufacturer was not made aware of the failure. The failure mileage was unknown.
No injuries · No fire · No crash
On [XXX], while driving on a busy boulevard in Wilmington, Delaware, my 2020 BMW 750i suddenly lost all power (engine and electrical) without any warning. The vehicle completely shut down in traffic, creating an extremely dangerous situation. There were no warning lights or messages before the failure. I called BMW Roadside Assistance for help but was informed that because my warranty had just expired, they canceled the tow truck that was already en route and turned it away. This left me stranded in a live traffic lane until I could arrange my own tow service from Geico. I called Wilmington Police for assistance and eventually had to run a couple of blocks to flag down a police vehicle that arrived and dropped several flares behind my vehicle. The vehicle was later inspected at Union Park BMW (Wilmington, DE), where the technician stated that the failure was due to a defective cell in the main battery. This experience has made me very nervous to drive the car again, as a total loss of power without warning could lead to a collision or injury. I believe this represents a serious safety defect in the vehicle’s electrical or battery system and should be investigated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash