BMW 545i Complaints

122 consumer complaints on file.

#11760532August 29, 2026
UNKNOWN OR OTHER
Vehicle suffered a catastrophic engine fire while parked due to fuel line separation under open recall 04V303000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11576234March 8, 2024
ENGINE
The contact owns a 2005 BMW 545I. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the contact became aware of a ball of white smoke coming from the exhaust. The contact stated that whenever the accelerator pedal was depressed, there was white smoke coming from the exhaust pipe. The vehicle was taken to an independent mechanic where it was diagnosed with a failed crank casting and the protective crank casting valve. The contact was informed that the failure was similar to an undisclosed manufacturer's recall, however the contact's VIN was not associated with the recall. The independent mechanic informed the contact that the smoke was excessive. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 122,195.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442056November 30, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The wiring inside of the headlights has dried up and fallen off, leaving bare electrical wire. The resulting was both of the headlights became non operational at night. To replace the headlights in the car with all the factory features is about 3200.00 for parts alone. I know of others who have had this happen, and everyone i know who owns one, has the same exact problem. The vehicle in question barely has 125,000 miles on it. I feel the manufacturer should repair these vehicles at no cost to the owners.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424889July 15, 2021
ELECTRICAL SYSTEM
At approxamitately 1:20pm on July 13, after being parked for a little over an hour I was told that my car was burning. 911 was called immediately and the owner of the establishment went outside and called to the firemen at the station on the other side of the street. Their response was immediate. Response was so quick that damage was limited to the right rear. Which seems that the fire started in the area directly foreward and above the battery
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11354824September 14, 2020
ELECTRICAL SYSTEM
WHILE DRIVING TO WORK DURING MORNING RUSH HOUR IN A BUSY HIGHWAY THE CAR JUST STOPPED RUNNING. NO ODD SOUNDS NO SHUTTING NO CLUNKING. IT WAS LIKE SOME JUST TURNED THE KEY OFF. I MADE IT TO THE SIDE OF THE HIGHWAY AND HAD TO WAIT TWO HOURS FOR A TOW TRUCK TO SHOW UP. MOST OF THE WEEK PREVIOUS TO THIS MY CAR WOULD NOT START AT RANDOM TIMES EVEN THOUGH MY BATTERY WAS GOOD AND I HAD GAS. THE PROBLEM WAS THE DME HAD WATER INGRESS FROM A POOR LOCATION WHERE THE DME AND METRONIC COMPUTER AND THE INTERGRADED POWER MODULE ARE LOCATED AND STORED. THEY ARE IN A SEALED PLASTIC BOX UNDER THE CABIN FRESH AIR INLETS AND CABIN FILTERS AND THE FRONT HOOD COWL. I'M THE BOX THERE IS A FAN AT THE BOTTOM TO EXPELL MOISTER. IF THE INTERGTATED POWER MODULE STARTS TO GO THEN THE FAN STOPS WORKING OR THE FAN IT SELF GOES BAD. AT THAT POINT THERE IS ALMOST ALWAYS WATER INGRESS INTO THE DME AND OR THE METRONIC COMPUTER CAUSING THE CAR TO NOT TO RUN OR EVEN CRANK AND WITH WATER CORROSION ON THE THE DME IT CAUSES PHANTOM PROBLEMS IN OTHER AREAS OF THE CAR. THE DME IS ALSO NOT EASILY REPLACED. THE CAR HAD TO BE TAKEN TO THE DEALERSHIP AND THEY HAVE TO ORDER A NEW DME AND ALIGN IT WITH THE BE CAS MODULE FOR THE IMMOBILIZER TO WORK CORRECTLY AND FOR YOUR CAR TO START. THIS USALLY COST IN EXCESS OF $2,000 JUST FOR THE NEW DME. THE WORST PART OF THIS WHOLE THING IS I LOST MY JOB BECAUSE I WAS 4 HOURS LATE TO WORK AFTER WAITING FOR THE TOW AND GETTING A RIDE TO WORK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11325833May 25, 2020
AIR BAGS, STRUCTURE:BODY
DRIVING APPROXIMATELY 50 MPH AN ACCIDENT OCCURRED WHERE THERE WAS OIL IN ROAD. MY CAR LOST CONTROL AND VEERED INTO A GUARD RAIL ON THE HIGHWAY. MY CAR WAS SUBSEQUENTLY TOTALED AND NONE OF MY AIR BAGS DEPLOYED IN THE CRASH.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11306903February 4, 2020
AIR BAGS, SEAT BELTS
MY CAR HAS THE PASSENGER RESTRAINT SYSTEM WARNING EVERYTIME I START MY CAR. THE AIR BAG RECALL IS BY TAKATA IS FOR THE 2003 545I MODEL. MY CAR WAS MANUFACTURED IN SEP OF 2003 WITH THOSE TAKADA AIRBAGS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11300372January 19, 2020
ELECTRONIC STABILITY CONTROL (ESC), STEERING
DYNAMIC STEERING MALFUNCTION CAUSING HAZARDOUS DRIVING CONDITIONS AT HIGHWAY SPEEDS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11282786November 28, 2019
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
ELECTRICAL WIRING IN HEADLIGHTS ARE DISINTEGRATING. THE SHIELDING IS DRY ROTTING AND FLAKING OFF NEARLY EVERY WIRE IN BOTH HEADLIGHTS CAUSING THEM TO MALFUNCTION DURING DRIVING. LIGHTS WILL CUT OFF RANDOMLY. I'D IMAGINE THE WIRES ARE SHORTING OUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253982September 8, 2019
ENGINE
VALVE COVER GASKET LEAK, TIMING CHAIN COVER GASKET LEAK, VALVE STEM LEAK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11174913February 7, 2019
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
BARE WIRES INSIDE THE HEADLIGHT HOUSING, THESE ARE HID LIGHTS MADE BY HELLA FOR BMW THEY ARE OEM. WHEN CONTACTING BMWNA THEY SAY THAT'S NOT HOW THEY MAKE THERE LIGHTS AND BLAME HEAT AND THE CAR NOT BEING MAINTAINED AT A BMW DEALERSHIP, WELL THE REST OF THE WIRING ON THE CAR IS JUST FINE EVEN THE WIRES THAT COME IN CONTACT WITH A HIGH HEAT PRODUCING ENGINE... IT'S THE SAME EXACT ISSUE MERCEDES BENZ HAD ON THE W202 CHASSIS, WIRES THAT WOULD DEGRADE AT AN EXTREMELY FAST RATE. BUT FOR HEADLIGHTS THAT COST WELL OVER $1000 EACH. BUT MY QUESTION IS WHAT HAPPENS WHEN A FAMILY IS OUT AT NIGHT AND THERE HEADLIGHTS MALFUNCTION BECAUSE OF SOMETHING BMW KNOWS ABOUT BUT REFUSE TO TAKE RESPONSIBILITY AND SAID FAMILY HAS A WRECK AND KILLS MULTIPLE PEOPLE BECAUSE OF A KNOWN PROBLEM. THIS IS MY SECOND ATTEMPT AT GETTING SOMETHING DONE THE FIRST WAS CONTACTING BMWNA WHICH EQUALED TO INSULTING SOMEONE'S KNOWLEDGE OF ELECTRICAL COMPONENTS. ALSO THE HEADLIGHTS NO LONGER ADJUST, THE ANGEL EYES NO LONGER WORK BULBS BLOW AS SOON AS THEY ARE REPLACED AND CONSTANT WARNINGS THAT PARKING LIGHTS HAVE A MALFUNCTION. TELLING SOMEONE HEAT IS THE CAUSE MAKES AN AUTOMOTIVE COMPANY KINDA LOOK IGNORANT ESPECIALLY WHEN WIRES TOUCHING AN ENGINE ARE NOT EFFECTED BY HEAT AT ALL AND ARE STILL 100% FLEXIBLE AND HAVE NOT LOST ANY OF THE INSULATION. YOU CAN SEE SOME OF THE WIRES HAVE LIQUID ELECTRICAL TAPE USED, SHOULD ANY VEHICLE WITH 119XXX MILES HAVE SUCH AN ISSUE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11139108October 8, 2018
AIR BAGS, SEAT BELTS
AS I UNDERSTAND A VEHICLE FOR PASSENGER SIDE AIRBAG IN PASSENGER SIDE FREE STREAM HAS BEEN DEALT WITH ALREADY I JUST RECEIVED THIS VEHICLE SEVERAL MONTHS AGO SO IT IS NEW TO ME AND I HAVE THE SAME ERRORS AS WHICH A RECALL HAS BEEN ISSUED FOR MY CAR 2005 545 I BMW. AS I HAVE READ AFTER X AMOUNT OF YEARS A RECALL IS FINALIZED I JUST RECEIVED THIS VEHICLE SEVERAL MONTHS AGO SO I FEEL I AM STILL ABLE TO SUCCEED FROM THIS SAFETY RECALL FROM THE MANUFACTURE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11115784August 5, 2018
ELECTRICAL SYSTEM
GOOD EVENING ALL, SINCE 2011 I HAVE HAD ISSUES WITH THE I DRIVE SYSTEM. JUST RECENTLY, THE SYSTEM STOPPED WORKING. AFTER ATTEMPTING TO RESOLVE THE ISSUE WITH BMW OF ONTARIO, THEY DECLINED TO COVER THE VEHICLE'S I DRIVE COMPUTER MODULE. FINALLY, THE COMPUTER STOPPED WORKING AND I COULD NOT SEE MY COMPUTER DISPLAY OR LISTEN TO MUSIC. I COULD NOT RE-SET THE AIR PRESSURE ON THE TIRES. I DROVE THE VEHICLE THAT WAY FOR MONTHS. FINALLY, I WENT TO THE JUNK YARD AND FOUND A VEHICLE SIMILAR TO MINE AND REPLACED IT. EVEN THOUGH I REPLACED THE COMPUTER, I WAS NOT ABLE TO GAIN CERTAIN FUNCTIONS ON MY VEHICLE THAT CAME STANDARD WITH THAT PARTICULAR VEHICLE SUCH AS THE SATELLITE RADIO OR SPEAK TO CALL FUNCTION. I'M PRETTY SURE MANY VEHICLE OWNERS CAN RELATE TO THIS ISSUE AND THE DIFFICULTY IT HAS CREATED TO TRY AND MITIGATE WITH THE DEALER. TAKE CARE,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11115782August 5, 2018
ELECTRICAL SYSTEM
GOOD EVENING SIR, I AM WRITING TO YOU BECAUSE MY VEHICLE HAD BARE WIRES ON THE HEADLIGHT. THE HOT WIRE AND GROUND WIRES WERE TOUCHING. I DID NOT HAVE THE HEADLIGHT WORKING. THERE IS A PROBLEM WITH THE WIRES OF THE VEHICLE PEELING OFF AFTER A CERTAIN AMOUNT OF TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11115783August 5, 2018
FUEL/PROPULSION SYSTEM
GOOD EVENING ALL, EVERY TIME I FILL UP THE GAS IN THE VEHICLE, THERE IS A STRONG SMELL INSIDE THE CAB. THIS BEGAN OCCURRING ABOUT 4 YEARS AGO BUT HAS CONTINUED THOUGHT MY TIME WITH THE VEHICLE. CURRENTLY, I CANNOT FILL THE TANK AT MORE THAN . IF I DO FILL UP THE VEHICLE TO MORE THAN I FACE HAVING TO SMELL THE FUMES OF THE FUEL INSIDE THE CAB OF THE VEHICLE. THIS IS A SAFETY ISSUE AND SHOULD BE RECALLED. MANY PEOPLE HAVE A SIMILAR COMPLAINT WITH THESE VEHICLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11100379June 7, 2018
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION, AIR BAGS, SEAT BELTS
IN 10/17 I BOUGHT THE ABOVE VEHICLE FROM PRIVATE OWNER. FROM THE TIME I STARTED DRIVING IT TO CURRENTLY, THE CONTROL DISPLAY HAS BEEN SHOWING A PASSENGER AIRBAG AND/ORSEATBEIT WARNING. THE CURRENT WARNING READS: "PASS. RESTRAINT SYSTEM. FAULT IN PASSENGER-RESTRIANT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT FORCE LIMITER." THE DISPLAY BETWEEN THE SPEEDOMETER AND TACHOMETER SHOWS A RED AIRBAG SYMBOL AND A RED FASTEN SEATBELT SYMBOL, WHICH DO NOT GO OFF WITH OPERATION OF VEHICLE. THESE 2004/2005 BMW 545I HAD A NHTSA SAFETY RECALL (08V384000) BUT CERTAIN VINS, INCLUDING MINE WERE NOT INCLUDED. I CANNOT UNDERSTAND WHY, BECAUSE CLEARLY NOT KNOWING WHETHER YOUR AIRBAG & BELT TENSIONER & BELT FORCE LIMITER ARE WORKING PROPERLY IS A SAFETY ISSUE. I AM NOT THE ONLY ONE WITH THIS CONCERN, PLEASE SEE AT LEAST 10 OTHER PEOPLE LISTING THIS PROBLEM WITH "WWW.CARPROBLEMZOO.COM" UNDER BMW 545 I SEATBELT PROBLEMS. MY MECHANIC HAS TRIED SEVERAL TIMES TO RESET THESE WARNINGS, BUT THEY ALWAYS COME BACK. NHTSA'S JOB IS TO PROTECT CAR OWNERS RE REAL SAFETY CONCERNS; I ASK THAT YOU PLEASE DO THIS. HOW WOULD YOU LIKE TO HAVE A PASSENGER IN THE FRONT SEAT AND NOT KNOW IF AIRBAGS AND SEATBELTS WILL OPERATE PROPERLY IN THE EVENT OF A CRASH?20 THANK YOU. *JS *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11096844May 19, 2018
AIR BAGS
SAME PROBLEM EVERYONE ELSE HAS WITH PASSENGER SIDE AIR BAG MALFUNCTION. $1500+ REPAIR, BUT WILL DO IT AGAIN, AS IT IS FAULTY PARTS. SOMEONE SITS DOWN IN THE PASSENGER SEAT TOO HARD, AND IT SETS OFF THE WARNING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11019448August 24, 2017
AIR BAGS, ELECTRONIC STABILITY CONTROL (ESC), STEERING
TAKADA RECALL. MY CAR'S MAKE CRACKING NOISE OR GROANED NOISES AS SOME OTHER E60 OWNERS DESCRIBED. THE NOISES SOUNDED AS THE CAR START ROLLING AT LOW SPEED WHETHER GO STRAIGHT OR TURN A LITTLE TO LEFT OR RIGHT. IT'S HAPPENED EVERY TIME. THE AIRBAG LIGHT COME ON DURING DRIVE AND IT IS OFF WHEN I SHUT OFF THE ENGINE. THE NEXT TIME I START THE CAR IS STILL REMAIN STAYED ON, AND IT'S GOES OFF DURING DRIVE. THE STEERING WHEEL SEEMS NOT FIRM UNLIKE E39 IS MORE FIRM. I FOUND A FORUM WHERE THE E60 OWNERS HAD SIMILAR PROBLEM AND THE DEALER SOLVED THE PROBLEMS I MENTIONED ABOVE BY JUST REPLACE THE TAKATA AIRBAG AND MAYBE AN UPDATE OF SOFTWARE INVOLVED. IN CONCLUSION TO MY COMPLAINT REGARDING TAKADA AIRBAG THE BMW SHOULD OPEN A RECALL FOR MY CAR OR ADD MY CAR TO THE RECALL LIST AS IT'S NOT SAFE FOR ME AND MY FAMILY. PLEASE HELP, THANK YOU.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11018755August 21, 2017
ELECTRICAL SYSTEM
MY I DRIVE OR CCC HAS MALFUNCTIONED. AT FIRST THE SCREEN WOULD TURN ON AND OFF OR FREEZE UP. FINALLY THE SCREEN WENT BLANK. THIS UNIT PROVIDE THE SAFETY INFORMATION OF THE VEHICLE. THIS UNIT ALSO PROVIDES THE COMMUNICATIONS SUCH AS BLUETOOTH AND HANDS FREE FUNCTIONS. THIS UNIT ALSO PROVIDES ALL THE SERVICE INFORMATION/ BASICALLY IT LIKE DRIVING A VEHICLE WITH OUT A BRAIN. THIS SEEMS TO BE A RECURRING PROBLEM WITH OTHER BMW OWNER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11014948August 13, 2017
ENGINE
CERTAIN BMW MODELS INCLUDING E60 2005 545I ALMOST ALL REQUIRE VALVE SEAL REPLACEMENT DUE TO FAULTY MANUFACTURING DEFECTS. THIS RESULTS IN OIL LEAKING INTO THE ENGINE AND SECONDARY AIR INJECTOR CAUSING SMOKE TO EMIT OUT OF THE TAILPIPES. ALTHOUGH MY CAR PASSED AL COMPUTERIZED SMOG CHECKS, IT DID NOT PASS THE NEW VISUAL TEST BECAUSE OF THESE FAULTY VALVE STEM SEALS. THIS OCCURS AFTE IDLING THE ENGINE FOR 10 MINUTES. THE REPAIR COSTS FOR THIS ARE ABOUT EQUAL TO THE RETAIL VALUE OF THE CAR. EVERY MECHANIC I'VE SPOKEN TO BELIEVES THIS SHOULD BE RECALLED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 545i