BMW · Model Report
Showing safety data for the 2011 model year only.
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
1. Vanos Bolts recall. NHTSA Recall 23V-707. Cause the car the have a rough idle, check engine light, car to stall, and cut off in traffic all with seconds. Dealership says it was not the Vanos Bolts that cause the shutdown, but it is the DME and ICM. 2. The safety of myself and my 15 year old daughter was at risk, along with the drivers on the highway. The car stopped in traffic, and would not release out of park to go in neutral. 3. State Trooper came to call a tow truck, the car was inspected by BMW of Irondale. 4. No warning lamps, messages or other symptoms prior to the failure. The car was driving as normal, a sudden rough idle, light came on, and the car cut off in ongoing traffic, with not warning before.
No injuries · No fire · No crash
I am filing a complaint regarding the recall work performed on my 2011 BMW 528i for the VANOS bolt safety recall. The recall notice stated the vehicle was unsafe to drive until repaired. I arranged towing to Jackie Cooper BMW in Edmond, Oklahoma because of this safety warning. The dealership performed the recall repair and released the vehicle back to me. Immediately after picking it up, the vehicle experienced a failure and became inoperable. The vehicle had to be towed again. This time, the dealership covered the towing cost and had the vehicle returned to my residence. Staff present at the time included a technician named Luke and the Service Drive Manager, Tayler Hawkins. Staff statements indicated that diagnostic charges would have applied if issues outside the recall were found, but no diagnostics were ultimately billed. There were also inconsistencies regarding the availability of the service manager. I am filing this complaint because the vehicle failed immediately after recall service and required towing. I am concerned that the recall work may not have been performed correctly or that the vehicle was released in a condition that was not suitable for operation. I am requesting that this incident be documented as part of the recall and safety record for this vehicle.
No injuries · No fire · No crash
The contact owns a 2011 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
No injuries · No fire · No crash
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle stalled. The contact pulled over, and after several attempts, the vehicle restarted. The contact was able to restart the vehicle, and the message "Drivetrain Malfunction" was displayed. The contact stated that the failure started recently and had occurred several times. Additionally, the vehicle was vibrating intermittently and lost motive power. The contact stated that occasionally the vehicle failed to accelerate above 15 MPH. The contact smelled the odor of gasoline inside the vehicle. The contact stated that the check engine warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
No injuries · No fire · No crash
The contact owns a 2011 BMW 528I. The contact received notification of NHTSA Recall Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING), and the vehicle was taken to a local dealer for the recall repair. The contact stated that while driving 40 MPH, the message "Drive Train Malfunction - Drive Moderately" was displayed. The vehicle was towed to the same dealer to be diagnosed. The contact was informed that faulty spark plugs had caused damage to a cylinder, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 123,568.
No injuries · No fire · No crash