BMW 428i Service Bulletins
457 manufacturer communications on file.
- April 1, 2017•Document ID: 10146632Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- B130315
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?N20, N26, N55, N63TU, S63TU and S55 Engines: Bosch Injector ETK Part Number Error What's New: ? Identifying the injector type using the ISTA test plan ? Determining the injector part number using the new the parts table. The current version of the ETK incorporates multiple part number errors for the Bosch type injectors. Ordering the injectors by VIN number or manual identification in ETK may result in an incorrect part number.
Associated Products (214)Associated Documents - April 1, 2017•Document ID: 10146628Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B112216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?"ENGINE OIL PRESSURE" ON LOW MILEAGE CARS. Check Control Message (CCM-212) states: "Engine Oil Pressure. Stop Carefully" The following codes may be stored in the DME fault memory" 1C2002 - Engine oil pump, pressure too low 1FB801 - CCM (ID212) - Oil pressure Also, the vehicle's mileage is very low (below 60 miles), the fault frequency shows only "one" occurrence; faults are not currently present and cannot be reproduced. CAUSE Unfavorable DME software application."
Associated Products (45)Associated Documents - March 1, 2017•Document ID: 10146610Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B840916
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"?SERVICE ACTION: SUPPLEMENTARY PAGE NEEDED IN OWNER'S MANUAL . Operator's manual of affected vehicles does not contain required information on wireless smartphone charging accessory. AFFECTED VEHICLE Vehicles which require this Service Action to be completed will show it as ""Open"" when checked either in the ""Service Menu"" of DCSnet (Dealer Communication System) or with the Key Reader."
Associated Products (53)Associated Documents - March 1, 2017•Document ID: 10146605Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B651715
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"?ACTIVE SOUND DESIGN (ASD) INOPERATIVE AFTER PROGRAMMING What's New: ? ISTA/P and ISTA 4 software level that contains the fix added to Correction and Procedure ? F31, F32, F33, F34, F36 vehicles added to Models ? Warranty information updated to include programming fix . After programming with ISTA/P V3.56.1 or ISTA/P V3.60: Active Sound Design (ASD) no longer provides simulated engine sounds. A fault is stored in the Active Sound Design (ASD) module. Fault Code 8053A5 ""ASD; invalid coding data for equalizing"". Invalid ASD coding data in two different versions of ISTA/P."
Associated Products (37)Associated Documents - March 1, 2017•Document ID: 10146604Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B650617
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?SATELLITE RADIO DETERIORATION IN RECEPTION QUALITY DUE TO NEW CELLULAR FREQUENCIES . INFORMATION Inform the customer that the introduction of these expanded frequencies by the wireless mobile providers may be influencing reception quality. BMW is currently working with the wireless mobile providers in order to improve the quality of reception and help alleviate the issues that are caused by the wireless mobile expanded frequencies. Once we have more information about this situation this service information bulletin will be updated. Currently Satellite Radio is provided by SiriusXM for BMW customers via geosynchronous (GEO) satellites located roughly above the equator. This means that the satellite signal to some parts of the United States can come in at an angle as low as 32 degrees to the horizon. Due to this angle, buildings, hills, trees, highway sound blocking walls or other obstacles might block the satellite signal coming from reaching the vehicle receiver antenna and might cause audio cut outs, unless the wireless provider has installed terrestrial repeaters. Reception quality decreases the further north you travel, as the angle of the incoming signal gets smaller. Also adverse weather conditions might affect reception. At this time, in the event of a customer complaint or inquiry on interference noise: Do not replace any parts Do not program or carry out other work on the vehicle Explain to customer about the new Wireless Communications Service (WCS) signals When investigating Satellite Radio cutouts or a temporary loss of reception: Please compare to a similarly equipped vehicle. Keep in mind the roofline of the vehicle, size of the antenna (sharkfin) and location of the antenna on the vehicle will all affect the strength of the reception. Do not compare a Sport Activity Vehicle (SAV) with a high roofline mounted antenna to a different vehicle such as a coupe or convertible with a much lower mounting point of the antenna. Replace no parts Do not prog
Associated Products (99)Associated Documents - March 1, 2017•Document ID: 10146603Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B650616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?NBT HEAD UNIT ABORTS IMPORT OF CD Whats New: ? G12 (7 Series) removed ? I01 (i3) removed ? Warranty Section updated for removal of G12 and I01 . While importing a CD to the internal music collection of an NBT head unit the process aborts. You will see 'import error' on the radio display when this occurs. NBT Head Unit software
Associated Products (160)Associated Documents - March 1, 2017•Document ID: 10146597Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B620217
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?Instrument Cluster Failure at Low Ambient Temperature. Sporadically, at low temperatures, the instrument cluster (KOMBI) is not operating (display remains black). KOMBI software.
Associated Products (31)Associated Documents - March 1, 2017•Document ID: 10146585Service Bulletin/Repair InstructionsVISIBILITY:REARVIEW MIRRORS/DEVICES
- Mfr Comm. #:
- B514416
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryEXTERIOR MIRROR: CREAKING NOISES Whats new: Video link added This Service Information bulletin supersedes SI B51 44 16 dated January 2017. . Creaking noise coming from either or both exterior rearview mirrors when folding in. Video Link: tinyurl.com/z46agg9 Accumulation of dust in the joint gap seal.
Associated Products (47)Associated Documents - March 1, 2017•Document ID: 10146573Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B130315
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryN20, N26, N55, N63TU, S63TU and S55 Engines: Bosch Injector ETK Part Number Error What's New: ? Procedure change: indentifying injector type using an ISTA test plan. . The current version of the ETK incorporates multiple part number errors for the Bosch type injectors. Ordering the injectors by VIN number or manual identification in ETK may result in an incorrect part number.
Associated Products (220)Associated Documents - March 1, 2017•Document ID: 10146572Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B120417
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySERVICE ENGINE SOON LIGHT IS ON WITH PT-CAN FAULTS STORED . The Service engine soon light (MIL) is on and the transmission may go into failsafe. The problem may be intermittent along with any of the following check control messages displayed or stored. Transmission temperature Drivetrain fault Chassis stabilization Note: Any combination of the following faults can be stored. DME faults: CDBB04: No message (request, torque, crankshaft, transmission 2), receiver DME, transmitter EGS CDBE04: No message (display, engine speed, dynamic), receiver DME, transmitter EGS CDBF04: No message (status, transmission control unit), receiver DME, transmitter EGS CDC004: No message (diagnosis, OBD gearbox), receiver DME, transmitter EGS CDC104: No message (data, transmission train), receiver DME, transmitter EGS CDC201: No message (request, torque, crankshaft, EGS), receiver DME, transmitter EGS EGS faults: 4209A4: Temperature sensor system: Hotmode 3 - excess temperature CF1501: No message (diagnosis OBD engine), receiver EGS, transmitter DME/DDE CF1521: Message (group fault 1 - effect during driving: considerable): Receiver EGS, transmitter DME/DDE CF1531: Message (group fault 2 - effect on driving: possible): Receiver EGS, transmitter DME/DDE CF1541: Message (group fault 3 - effect on driving: none): Receiver EGS, transmitter DME/DDE CF2C21: Signal (actual engine speed, crankshaft - signals a poor quality useful signal, 0xA5) undefined, transmitter DME/DDE The EGS harness wiring from connector X13*2B becomes damaged due to abrasive movement inside the corrugated housing.
Associated Products (15)Associated Documents - March 1, 2017•Document ID: 10146567Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B111015
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?Service Action: Replace the Thermostat What's New: ? Part number and quantity of coolant has been updated. Refer to the Warranty section for details. . The Service Engine Soon light is on with corresponding fault codes in the DME for the engine thermostat.
Associated Products (37)Associated Documents - March 1, 2017•Document ID: 10136361Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- B651312
- Date Added:
- May 7, 2018
- Manufacturer:
- BMW
SummaryHEADUNIT NAVIGATION MAPS (HU-H HU-H2 HU-B): The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (7/2012+).
Associated Products (146)Associated Documents - February 1, 2017•Document ID: 10146560Service Bulletin/Repair InstructionsSEAT BELTS
- Mfr Comm. #:
- B720115
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryFRONT SEAT BELT: EXTENDER MALFUNCTION This Service Information bulletin supersedes SI B72 01 15 dated April 2015. . Upper seat belt extender system is failing to deliver the belt and may exhibit one of the following symptoms: A. Seat belt is slipping off/ not being captured by the extender hand B. The seat belt extender hand is broken C. The seat belt extender hand is making noises D. The seat belt extender housing is broken E. The seat belt extender motions are erratic or illogical. The belt extender has mechanically and/or electrically failed. Excessive resistance from the safety-belt reel (twisted safety belt) does not allow the belt to extend properly, causing a failure to deliver the safety belt. The safety belt slips off the hand due to the geometry of the safety-belt extender, which fails to catch the safety belt for delivery.
Associated Products (9)Associated Documents - February 1, 2017•Document ID: 10146554Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B620217
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?SeriesOptionDescription F22, F23, F30, F31, F32, F33, F34, F36, F25, F26, F48, 05AR Traffic Jam AssistantX. Sporadically, at low temperatures, the instrument cluster (KOMBI) is not operating (display remains black). KOMBI software.
Associated Products (35)Associated Documents - February 1, 2017•Document ID: 10146550Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610315
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?Various Check Control Messages Caused by Shorted K- CAN This Service Information bulletin supersedes SI B61 03 15 dated June 2016. . The customer states that one or more of the following CC messages are displayed: 627 - Steering behavior: Drive moderately 070 - Steering: Drive moderately 765 - Rear-end collision restricted 850 - Pedestrian warning restricted 236 - Driving stabilization: Drive moderately 299 - SOS call system failure 042 - Brake system: Drive moderately After performing a vehicle test, one or more of the following fault codes are stored: ACSM - C9549A Message faulty (seat memory), ACSM receiver, driver's seat module transmitter FEM - D91DE0 No message, receiver FEM, transmitter TMSL FEM - D91EE5 No message, receiver FEM, passenger seat module transmitter ACSM - C9540C Message missing, receiver ACSM, transmitter FEM TMSL - D95402 Message missing, receiver TMSL, transmitter FEM KOMBI - E11454 No message, receiver KOMBI, transmitter REM FEM - D91DE6 No message, receiver FEM, transmitter TMSL TMSR - D99401 Message missing, receiver TMSR, transmitter FEM TMSR - D99402 Message missing, receiver TMSR, transmitter FEM FEM - 8041BA AHL system faulty FEM - D916C3 No message, receiver FEM, transmitter TCB ZBE - E2D403 No message, receiver CON, transmitter FEM-ZGM TRSVC - CA9428 Message incorrect, receiver TRSVC, transmitter PDC-REM TMSL- D95401 Message missing, receiver TMSR, transmitter FEM HU-H - S0397 MOST configuration was not stored TCB - E1445F KCAN2 or KCAN4: Line fault/electrical fault FEM - 8041B6 LWR faulty REM - E58468 Body CAN2; communication fault TRSVC - CA9427 Message incorrect, receiver all around vision camera, transmitter PDC/REM FEM - D91CEC Message missing, receiver FEM, transmitter REM Shorted K-CAN wiring under driver or passenger seat Shorted K-CAN2 wires were shorted between the left side trunk trim panel and the body of the vehicle Shorted K-CAN in left rear wheel well area Shorted K-CAN under center console trim Shorted K-CAN und
Associated Products (44)Associated Documents - February 1, 2017•Document ID: 10146547Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; SEATS
- Mfr Comm. #:
- B520317
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?MISSING AUDIO NOTIFICATION WHEN STORING SEAT MEMORY . When saving seat memory settings (Memory 1 or Memory 2) with a vehicle without navigation, there is no audio tone confirmation. Software error in control unit of Seat Module 2.
Associated Products (45)Associated Documents - February 1, 2017•Document ID: 10146546Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- B520117
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?RATTLING/CREAKING NOISE FROM REAR BENCH SEAT BACKREST . Rear seat bench backrest makes creaking or rattling noise when driving on uneven surface. Torsional stresses on vehicle body cause movement between seat back and latching mechanism. Friction among backrest locking mechanism components generates noise.
Associated Products (20)Associated Documents - February 1, 2017•Document ID: 10146543Service Bulletin/Repair InstructionsSTRUCTURE:BODY:TAILGATE
- Mfr Comm. #:
- B510417
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?CREAKING NOISE FROM TAILGATE DURING TRAVEL . While the vehicle is in motion, a creaking noise is heard from the vicinity of the tailgate. Friction between trim panel and the tailgate where they make contact.
Associated Products (6)Associated Documents - February 1, 2017•Document ID: 10146537Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- B310514
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?FRONT SUSPENSION RIDE HEIGHT HAS DROPPED . INFORMATION Please refer to the Electronic Parts Catalog (EPC), using the VIN to locate the part numbers. WARRANTY INFORMATION Damages due to outside influences are not covered under the terms of the BMW limited warranties.
Associated Products (45)Associated Documents - January 1, 2017•Document ID: 10150973Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- B514716
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary?CREAKING NOISES FROM C-PILLAR. Flexing of body panels near weld point in the interior side wall.
Associated Products (8)Associated Documents