BMW 230i Service Bulletins
377 manufacturer communications on file.
- January 1, 2017•Document ID: 10150966Service Bulletin/Repair InstructionsFUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B160616
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary?SERVICE ACTION: REPLACE LOW-PRESSURE ELECTRIC IN-TANK FUEL Please perform the procedure outlined in this Service Information on all affected vehicles before customer delivery or the next time the vehicle is in the shop.
Associated Products (41)Associated Documents - December 1, 2016•Document ID: 10146794Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B650915
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySI B65 09 15 November 2016 Audio, Navigation, Monitors, Alarms,SRS Technical Service NBT Head Unit High (HU-H) Resets Intermittently or Permanently. The Head Unit-High (HU-H) resets intermittently or permanently. 1. The display is inoperative and there is no audio output 2. Automatic system start-up after a couple of seconds Fault Code E1C440 set No Fault Codes set Software error in the Head Unit High (HU-H)
Associated Products (170)Associated Documents - December 1, 2016•Document ID: 10146747Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B540416
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySERVICE ACTION: CONVERTIBLE ROOF: TENSIONING STRAP REPLACEMENT. The tensioning strap that is fastened to the headliner could fail during convertible top operation. Convertible top could be damaged by tensioning strap failure (approx. 10% of vehicles). Tensioning strap can become jammed or trapped in convertible top mechanism leading to failure.
Associated Products (6)Associated Documents - November 1, 2016•Document ID: 10146964Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT
- Mfr Comm. #:
- B651316
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"NBT-EVO Head Unit Cannot Be Swapped Between Vehicles for Testing This Service Information bulletin supersedes SI B65 13 16 dated July 2016.. If an NBT-EVO head unit is swapped into a different vehicle it will enter a locked mode once it recognizes a different VIN. This will set a fault in the Head Unit (NBT-EVO), Fault Code ""B7F87A: Burgler Actively Registered / Component Protection Active"" This will require REPLACEMENT of the head unit to restore operation. To prevent easy re-use of stolen Head units additional features are introduced with 11/15 ISTA/P software to bring NBT-EVO to a higher security level. In NBT-EVO the mechanism is called ""Trusted VIN"""
Associated Products (78)Associated Documents - November 1, 2016•Document ID: 10146962Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES
- Mfr Comm. #:
- B630516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"HEADLIGHT ASSEMBLIES HAVE VISIBLE INTERNAL MOISTURE/CONDENSATION. Water on the inside (A) or misting (B) of both headlight lenses that is visible from outside. Water inside the headlights can be caused by two situations: Water/moisture ingress into the headlight housing. Thermal conditions that result in the formation of condensation. Note: An important indication that the moisture issue is caused by ""condensation"" rather than a ""water leak"" into the headlight housing, there will be misting/condensation in ""both headlights."""
Associated Products (156)Associated Documents - November 1, 2016•Document ID: 10146784Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B122816
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"DME Electrical Wastegate Valve Faults - Adaptation Limit Positions Not Detected. Engine runs with reduced power. Emissions warning lamp lights up. One or more of the following faults are entered in the DME fault memory. 123411 ""Electrical wastegate valve, limit position teach in: End stop (wastegate valve open) not found 123412 - Electrical wastegate valve, limit position teach in: End stop (wastegate valve open) not found Other consequential faults that also may be stored: 123401 - Electrical wastegate valve, adaptation: Cold start not learned 123437 - Electrical wastegate valve: Jammed closed Problems with electromagnetic compatibility (EMC). The PWM actuation (PWM = pulse-width-modulated) of the heat management module causes a fault condition on the 5V supply line of the electrical wastegate valve controller. This leads to a fault on the position sensor signal of the electrical wastegate valve controller."
Associated Products (9)Associated Documents - November 1, 2016•Document ID: 10146779Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B070314
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryDiagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits This Service Information bulletin supersedes SI B07 03 14 dated October 2015.. Fault codes stored in vehicles being serviced are not being diagnosed, leading to repeat repair visits (source- Analysis of FASTA data and repeat repair visit reports). INFORMATION Where diagnosis (vehicle or short test) with ISTA has already started, it is important to diagnose the fault code(s) listed below (when they are stored in the vehicle) to find their root cause during the current workshop visit. This will help lead to a reduction in workshop repeat repair visits and higher customer satisfaction.
Associated Products (256)Associated Documents - October 1, 2016•Document ID: 10146903Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- B652416
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"NBT NAVIGATION DOES NOT ROUTE ON TOLL ROADS. NBT Navigation does not provide routes that include certain toll roads. CAUSE Roads that have toll lanes ""without a cash option"" where not utilized for routing in NBT map data versions: NEXT 2015-1 NEXT 2015-2 NEXT 2016-1 As an enhancement, the NEXT 2017-1 map release now provides information about toll lanes ""without cash option"". UPDATE Install new map data."
Associated Products (148)Associated Documents - October 1, 2016•Document ID: 10146902Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B652316
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?AUDIO VOLUME NOT RESTORED AFTER MSA STOP, ENTRY HEAD UNIT. Volume of audio system (when set to near maximum) is reduced when Auto Start-Stop (MSA) stop occurs and is not restored upon automatic engine restart. This is normal system behavior - serves to protect the head unit, battery drain and avoidance of incremental leaps in the loudness. The loudness is reduced to 2/3 of maximum and is not restored. Note: Air conditioning output is also reduced upon MSA stop and is not restored for similar reasons.
Associated Products (154)Associated Documents - October 1, 2016•Document ID: 10146900Service Bulletin/Repair InstructionsEXTERIOR LIGHTING
- Mfr Comm. #:
- B630716
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?WATER INSIDE REAR LIGHT ASSEMBLY. Water is inside rear light assembly. Water is drawn into the rear light assembly through ventilation openings.
Associated Products (9)Associated Documents - October 1, 2016•Document ID: 10146892Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- B340516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCBS BRAKE PAD CALCULATION AND CORRECTION. When a vehicle comes into the workshop for any repair or maintenance job, the bundling calculator recommends a brake maintenance checkup. No brake warning light is illuminated. CBS shows 3,107 miles or slightly higher for the next brake service displayed via Key Reader, or vehicle's Control Display (in Vehicle Info/Status/Service required/Brake pads) CAUSE CBS calculates the remaining brake pad wear based on brake pressure, speed, vehicle specific parameters (i.e. NAO pads), brake temperature as well as cumulative brake application time. Due to variation of these parameters and outside environmental influences, this calculation can deviate from the real brake pad wear. Starting from the above-mentioned production dates of the vehicles indicated, the CBS brake pad wear calculation has been changed, and is now based only on the brake pad wear sensor. Important Note: To avoid a too-slow wear prediction, the CBS brake model will estimate the need for repairs, in some cases, rather early. Calculation will level at 3,107 miles and stay at this value until the CBS brake pad wear sensor is triggered. https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/36...11/8/2016 Page 2 of 2 After the sensor is triggered, the CBS mileage will count down indicating to the customer that the brake repairs will be due.
Associated Products (148)Associated Documents - September 1, 2016•Document ID: 10146849Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B840916
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"SERVICE ACTION: SUPPLEMENTARY PAGE NEEDED IN OWNER'S MANUAL. Operator's manual of affected vehicles does not contain required information on wireless smartphone charging accessory. AFFECTED VEHICLE Vehicles which require this Service Action to be completed will show it as ""Open"" when checked either in the ""Service Menu"" of DCSnet (Dealer Communication System) or with the Key Reader."
Associated Products (53)Associated Documents - September 1, 2016•Document ID: 10146848Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840416
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySOS MALFUNCTION DISPLAYED. An SOS malfunction is seen in the Kombi. When pressing the E-Call/SOS button in the overhead console, nothing happens. Fault code B7F33C (internal ECU error) is stored in the Telematics control unit (ATM/TCB2). There are 2 known causes for this failure. They are as follows: Software file missing from the ATM/TCB2 control module Water leak at shark-fin leading to corrosion in the ATM/TCB2 control module
Associated Products (52)Associated Documents - September 1, 2016•Document ID: 10146844Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B641216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"HVAC BLOWER NOT WORKING This Service Information bulletin supersedes SI B64 12 16 dated August 2016. HVAC blower is not working. Condensation occurs even though blower is working. CC message ""Increased battery discharge"" - standby current violation may be displayed. Climate control unit (IHKA) software"
Associated Products (56)Associated Documents - September 1, 2016•Document ID: 10146832Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- B513516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryPAINT ON THE B-PILLAR IS SCRATCHED/DAMAGED. Paint on B-pillar is scratched. Especially noticeable on dark colored paint. Door seal is rubbing against entry opening surfaces.
Associated Products (23)Associated Documents - September 1, 2016•Document ID: 10146830Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- B513216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCREAKING NOISES FROM DOOR TRIM PANEL. Creaking noise is heard from door trim panel while driving on rough roads. Door trim panel is contacting the inner door panel.
Associated Products (53)Associated Documents - September 1, 2016•Document ID: 10146813Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B122016
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"MIL LIGHT WITH DME FAULTS 1B2002 AND 1F1A51 STORED. Service Engine Soon (MIL) light is on. Both of the following fault codes are stored in Digital Motor Electronics (DME) memory: 1B2002: ""EWS protection against tampering: no starting value programmed"" 1F1A51: ""DME, internal fault: Read EEPROM faulty"" Note: Only vehicles with DME MEVD17.2.3 produced or programmed to Integration levels: F02x-16-03-50x - F02x-16-07-50x - F02x-16-11-50x are affected. Ineffective DME software."
Associated Products (6)Associated Documents - August 1, 2016•Document ID: 10147042Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT
- Mfr Comm. #:
- B840616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryBMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional. Vehicle and service cockpit have different ICC-ID's.
Associated Products (158)Associated Documents - August 1, 2016•Document ID: 10147041Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B840516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryBMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. The ConnectedDrive Services are non-functional after a hardware exchange of the telematics control unit. This is not indicated by CC-message. ConnectedDrive Services not synchronized by Telematics Control Unit.
Associated Products (160)Associated Documents - August 1, 2016•Document ID: 10147039Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B661816
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryINFORMATION ON THE OPERATION OF THE SMART OPENER. INFORMATION ON THE OPERATION OF THE SMART OPENER MODEL F07 (5 Series Gran Turismo) F10 (5 Series) F12 (6 Series Convertible) F13 (6 Series Coupe) F15 (X5) F16 (X6) F22 (2 Series Coupe) F23 ( 2 Series Convertible) F25 (X3) F26 (X4) F30 (3 Series Sedan) F31 (3 Series Wagon) F32 (4 Series Coupe) F33 (4 Series Convertible) F34 (3 Series Gran Turismo) F36 (4 Series Gran Coupe) F48 (X1) F80 (M3 Sedan) F82 (M4 Coupe) F83 (M4 Convertible) F85 (X5 M) F86 (X6 M) G12 (7 Series) I01 (i3 Series) Vehicles with option code SA-0322 (Comfort Access) without M-Sport trim INFORMATION The smart opener (Contactless tailgate) operates as described below: Ignition key must be within 3 feet behind the vehicle, clear from any interference like a smartphone The customer must be at least an arms-length behind the vehicle Kick your foot forwards & backwards under the vehicle in one quick movement The taillights flash confirming that the trunk will open The trunk then successfully opens For more information an instructional video can be viewed which demonstrates the operation. Thanks to BMW of Tenafly for providing the video. tinyurl.com/Autotrunk1 https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/358...9/3/2016 Page 2 of 2 WARRANTY INFORMATION Not applicable. [ Copyright (c)2016 BMW of North America, Inc. ] https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/358...9/3/2016
Associated Products (122)Associated Documents