2022-2025 Audi A5, S4, S5 Continental Tire Recall 44CT

Why This Matters: Safety Risk

Continental Tire the Americas, LLC (CTA) has initiated a voluntary safety recall for certain passenger tires due to a non-compliance condition. The design of these tires can lead to higher flexing in the tread shoulder, causing heat buildup. This condition may result in a belt edge separation, potentially leading to a partial or full loss of the tire's tread or belt.

Such a failure significantly increases the risk of a crash, which could lead to serious injury or even death for vehicle occupants and others on the road. Additionally, affected tires may exhibit symptoms like localized tread wear in the shoulders, excessive vibrations, and increased noise.

What's Being Recalled

This recall, identified by Audi as campaign code 44CT, involves specific Continental passenger tires found on certain 2022-2025 Audi A5, S4, and S5 vehicles. The non-compliance condition means the tires do not meet certain safety standards, posing a potential hazard.

The affected tires may have been installed as original equipment, sold as replacement tires, or are currently in dealer inventories. All tires identified as part of this recall will be replaced at no cost to the owner.

Symptoms of Affected Tires

Owners of vehicles impacted by this Audi A5 Continental tire recall might notice several indicators of the issue. These can include localized tread wear specifically in the tire's shoulder areas, which is an unusual wear pattern. Drivers may also experience excessive vibrations while driving, or an increase in tire noise compared to normal operation. These symptoms are a direct result of the tire's internal structural issues.

Manufacturer's Remedy

Audi dealers are prepared to address this recall under campaign 44CT. The repair process involves inspecting all four tires on affected vehicles. If any tire requires replacement due to this recall, the dealer will handle the ordering of new tires through their tire vendor, distributor, or a representative of the tire manufacturer.

Detailed instructions for the repair and claiming process are available to technicians through ELSA and the Service References tool in Elsa2Go. This ensures a standardized and correct procedure for all affected vehicles. The replacement of affected tires will be performed free of charge to the owner.

Important Warnings for Dealers and Owners

Audi has issued critical directives regarding this recall. It is a violation of federal law for dealers to deliver any new motor vehicle or any new or used item of motor vehicle equipment, including tires, covered by this notification until the defect is remedied. Dealers must correct the issue prior to delivery for sale or lease.

Furthermore, dealers are prohibited from delivering any pre-owned vehicles in their inventory that are involved in this safety or compliance recall until the defect has been remedied. Dealers are also instructed to check their daily campaign open inventory report or OMD for affected vehicles and to repair every affected inventory vehicle before delivery to consumers. Owners should be aware that vehicles cannot be delivered until the necessary tire replacement is completed.

Owner Action

If you own a 2022-2025 Audi A5, S4, or S5, and are concerned about the Audi A5 Continental tire recall, you should schedule an appointment with your authorized Audi dealer immediately. Continental will be notifying end consumers and car owners identified as having affected tires. The repair became available on September 13, 2024. Your dealer will inspect the tires and replace any that are found to be affected by recall 44CT, free of charge.

---

Source: NHTSA ID: 11009231