Volvo S80 Complaints (2008)

26 consumer complaints on file.

#11758318August 20, 2026
ELECTRICAL SYSTEM
The contact owns a 2008 Volvo S80. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that several unknown warning lights were illuminated. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed with a failed Central Electronic Module (CEM). The contact was informed that the CEM needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671194July 3, 2025
FUEL/PROPULSION SYSTEM, AIR BAGS, SEAT BELTS
I bought this car from elderly people. After I bought it and drove, there's lots of thing not according to safety standard? I asked them (seller) but they don't have any answer, due to their age. So, since last Tuesday, I am driving as it is. Hardly I put 250 miles so far. There's belt sign, Air bag sign, and Low tire air sign. All signs are showing in my dashboard and stays as long as car is on. So, I am scared to death to drive this car, car itself in a mint condition and it's got only 131K miles. Still there's is more life left on this car. I am also senior citizen and retired person. So, I need help to get these fixed asap please.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460775April 14, 2022
STRUCTURE:BODY
Front subframe has multiple holes due to excessive engine heat. The front subframe rots prematurely and causes paint to flake off so rust forms.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454606March 1, 2022
STRUCTURE:BODY
Sub frame cracking due to rust.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436848October 14, 2021
SUSPENSION
The subframe is rotting prematurely and this issue is only present on the v8 equipped models. Cars in very good shape but the subframe is almost rotted totally through above the exhaust. Due to the poor layout of the exhaust which causes the paint on the welds to flake off and then the subframe begins to rust from the inside out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424126July 9, 2021
UNKNOWN OR OTHER
The front windshield is leaking, such that the driver's side front and rear floors flood, even with a light rain. Enough water comes in that the padding, carpet, floor mat and rubber floors mat are all under water. When it rains, we see water droplets and water trails on the inside of the windshield. The windshield is original and has never been replaced. We've never had a car that leaked like this and don't expect that cars should turn into small swimming pools inside when it rains.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365977October 23, 2020
UNKNOWN OR OTHER
DRIVING ON HIGHWAY AND CLOSED SUNROOF SHATTERED. NO DEBRIS CAME FROM VEHICLES AHEAD. THE VEHICLES WERE MORE THAN 500 FEET AHEAD, AND I WAS LOOKING AHEAD ON THE HIGHWAY WHEN IT SHATTERED. CAUSE UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11099971June 5, 2018
SEAT BELTS
AFTER STARTING MY CAR I TRIED TO PUT ON MY SEAT BELT BUT IT WOULD NOT EXTEND OUT SO I COULD NOT PUT IT ON. THIS HAPPENED LAST NIGHT AND THE PROBLEM STILL PERSISTS TODAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11063128January 16, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2008 VOLVO S80. WHILE FUELING THE VEHICLE, THE CONTACT NOTICED AN EXTREMELY STRONG ODOR OF FUEL EMITTING INTO THE VEHICLE. THE VEHICLE WAS NOT INSPECTED AND DIAGNOSED BY A DEALER. THE VEHICLE WAS TAKEN TO AN INSPECTION STATION AND PASSED THE INSPECTION, BUT THE MECHANIC ALSO INDICATED TO CHECK THE FUEL SYSTEM DUE TO A STRONG ODOR OF FUEL. THE INDEPENDENT MECHANIC ADVISED THAT THE VEHICLE BE SERVICED BY A DEALER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE), BUT THE CONTACT DID NOT RECEIVE A NOTIFICATION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11062718January 14, 2018
FUEL/PROPULSION SYSTEM, SEAT BELTS, VEHICLE SPEED CONTROL
WHILE TURNING INTO A PARKING SPACE FROM THE LANE OF A PARKING LOT, WITH MY FOOT ON THE BRAKE, MY VOLVO S80 ACCELERATED SO POWERFULLY IT COULD BE HEARD YARDS AWAY. I APPLIED THE BRAKE HARDER BUT THE CAR WOULDN'T STOP AND SURGED OVER A WHEEL STOP, IT WAS STILL SURGING SO I STARTED PUMPING THE BRAKE, THE CAR FINALLY CRASHED INTO A PIPE BOLLARD BRINGING IT TO A STOP, THE CAR WOULDN'T TURN OFF, THE ELECTRICAL WAS GOING HAYWIRE AND I COULD NOT GET THE CAR INTO PARK TO REMOVE THE KEY. UPON IMPACT THE SEAT BELT DID NOT HOLD MY MOTHER INTO PLACE AND THE AIRBAGS DID NOT DEPLOY. I AM THE ORIGINAL OWNER OF THIS 2008 VOLVO S80 AWD WITH 58K MILES ON IT IN PRISTINE CONDITION. I HAVE HAD PROBLEMS IN THE PAST WITH THE COOLING FAN MODULE, ENGINE RUNNING HOT, THE SCU MODULE, MAP SENSOR, A FAULTY FUEL SENSOR, FAULTY SCHRAEDER VALVES, FAULTY ALTERNATOR AND VOLTAGE REGULATOR, FAULTY AC COMPRESSOR BUT NEVER A POWER SURGE TO THIS EXTREME.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11062721January 14, 2018
FUEL/PROPULSION SYSTEM, SEAT BELTS, VEHICLE SPEED CONTROL
WHILE PULLING INTO A PARKING SPACE FROM THE DRIVING LANE OF A PARKING LOT, MY VOLVO HAD A SURGE OF POWER THAT COULD NOT BE CONTROLLED/STOPPED BY APPLYING THE BRAKES. I WAS BARELY IN MOTION WITH MY FOOT ON THE BRAKE WHEN WE (MY MOTHER, SISTER, AND I) HEARD THE ENGINE ROAR AND THE CAR SURGED FORWARD. I APPLIED MORE PRESSURE TO THE BRAKE BUT THE CAR WOULD NOT STOP AND WENT OVER A WHEEL STOP SO I THEN STARTED PUMPING THE BRAKE. THE CAR FINALLY STOPPED MOVING ONCE IT HIT A PIPE BOLLARD BUT THE ENGINE WOULD NOT TURN OFF, MY ELECTRICAL WENT HAYWIRE AND I COULD NOT GET THE CAR IN PARK TO REMOVE THE KEY. UPON IMPACT THE PASSENGER SEAT BELT DID NOT HOLD MY MOTHER IN PLACE AND THE AIR BAGS DIDN'T DEPLOY. I AM THE ORIGINAL OWNER OF THIS CAR WHICH WAS IN PRISTINE CONDITION BUT NOW WRECKED. I HAVE ALL THE SERVICE RECORDS FOR THIS CAR AND HAVE HAD PROBLEMS IN THE PAST WITH THE FOLLOWING ITEMS; FAULTY COOLING FAN MODULE, ENGINE RUNNING HOT, FAULTY BATTERY CELL, FAULTY SCU MODULE, FAULTY STARTER, FAULTY MAP SENSOR, FAULTY OIL LEVEL SENSOR, FAULTY POWER STEERING RACK,FAULTY FUEL PRESSURE SENSOR, FAILING LAMP SOCKET, FAULTY SCHRAEDER VALVES, FAULTY ALTERNATOR AND VOLTAGE REGULATOR, AND A FAULTY AC COMPRESSOR.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11018754August 21, 2017
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
1. IN FEBRUARY 2017, WHILE IN MOTION ON A CITY STREET, ALTERNATOR FAILED, VEHICLE WAS TOWED TO DEALERSHIP, ALTERNATOR WAS REPLACED 2. IN AUGUST 2017, WHILE IN MOTION ON CITY STREET, MESSAGE DISPLAYED ALERTING ON ENGINE OVERHEAT -- SLOW DOWN SPEED - THEN STOP IMMEDIATELY. VEHICLE WAS TOWED TO DEALERSHIP. ON DIAGNOSTICS, WAS ESTABLISHED THAT ONLY ONE FAN WAS WORKING ON THE COOLING FAN ASSEMBLY CAUSING OVERHEAT. 3. WHILE AT DEALERSHIP FOR REPAIRS OF THE COOLING FAN, DIAGNOSTICS ESTABLISHED THE FOLLOWING: - CODE ECM-PO19000: WAS RECOMMENDED TO REPLACE FUEL RAIL PRESSURE SENSOR FIRST (IF SAME CODE COMES BACK IN THE FUTURE, A FUEL PUMP REPLACEMENT WAS RECOMMENDED) - TAG LIGHT BULBS REGULARLY GO OUT - NEGATIVE BATTERY CABLE IS CORRODED; REPLACEMENT NEEDED - POWER STEERING LINE LEAKING FROM RACK TO COOLER, REPLACEMENT NEEDED; RESERVOIR REPLACEMENT NEEDED -- HAS INTERNAL FILTER - POWER STEERING FLUID IS WHITE-CONTAMINATED - REPLACE NEEDED FOR THE FRONT STRUTS, MOUNTS, AND SUPPORT PLATES: STRUTS LEAKING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10995142June 14, 2017
UNKNOWN OR OTHER
SUNROOF BLEW UP, OR SPONTANEOUSLY COMBUSTED. WAS NOT HIT BY AN OBJECT, LOUD SOUND WAS HEARD PRIOR TO THE INCIDENT. CAR WAS IN MOTION AT THE TIME, GOING ABOUT 60MPH. CONDITIONS CLEAR, COOL TEMPERATURES NOT VERY HOT OR COLD OUTSIDE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872983June 7, 2016
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL* THE CONTACT OWNS A 2008 VOLVO S80. WHILE DRIVING VARIOUS SPEEDS, THE SUN ROOF FRACTURED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,310.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748945August 16, 2015
UNKNOWN OR OTHER
I WAS DRIVING ON THE HIGHWAY AT APPROX 3PM. MY 11 YEAR OLD SON WAS ALSO A PASSENGER IN THE VEHICLE. I WAS ON WIDE OPEN HIGHWAY - NO STORMS - NO VEHICLES ON THE HIGHWAY NEAR ME. ALL OF A SUDDEN, THERE WAS A LOUD NOISE, SOUNDED LIKE A BOMB EXPLODED. I FELT SHARP PIECES OF GLASS AND SAW GLASS IN THE COMPARTMENT OF THE VEHICLE, LOOKED UP AND THE SUNROOF HAD SHATTERED. I FIRST ATTEMPTED TO SLIDE THE GLASS ALL THE WAY BACK SO THAT THE GLASS WOULD NOT CONTINUE TO FALL AND CUT US. THEN I REALIZED THAT WAS NOT A GOOD IDEA SO I CLOSED THE SUNROOF BACK AND THE CLOSED THE CLOTH ROOF COVERING. I HAD TO WAS ABLE TO DRIVE THE VEHICLE TO PICK MY DAUGHTER UP FROM HER LOCATION AND GET US HOME SAFELY. THE FOLLOWING DAY, I TOOK THE VEHICLE TO VOLVO TO SEE IF THIS WAS COVERED UNDER MY EXTENDED WARRANTY OR IF VOLVO WOULD PAY SINCE THEIR VEHICLE WAS DEFECTIVE. THE SERVICE MANAGER OF VOLVO OF CHARLOTTE CALLED ME A LIAR - SAID THAT THIS WOULD NOT HAPPEN UNLESS SOMETHING HIT THE VEHICLE. I EXPLAINED TO THIS GUY THAT NOTHING HIT THE VEH, I WAS ON WIDE OPEN ROAD - GOOD SUNNY WEATHER WITH NO VEHICLE IN SIGHT. HE CONTINUED TO CALL ME A LIAR. CALLED MY INSURANCE COMPANY TO REPORT THE CLAIM TO HAVE IT ON RECORD AND FOR POSSIBLE SUBROGATION RIGHTS .
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#10621542August 11, 2014
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM:IGNITION
TL* THE CONTACT OWNS A 2008 VOLVO S80. THE CONTACT NOTICED THAT THE ENGINE COOLING SYSTEM WARNING INDICATOR ILLUMINATED AND THE AIR CONDITIONING PERFORMANCE REDUCED WHILE AT A TRAFFIC LIGHT. THE FAILURE OCCURRED MULTIPLE TIMES. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD NOT START WHEN THE KEY WAS INSERTED INTO THE IGNITION. WHEN THE VEHICLE WAS TAKEN TO THE DEALER FOR AN OIL AND FILTER CHANGE, THE MECHANIC REPLACED THE FAN CONTROL MODULE ACCORDING TO NHTSA CAMPAIGN NUMBER: 09V218000 (ENGINE AND ENGINE COOLING). THE CONTACT WAS UNAWARE OF THIS RECALL PRIOR TO THE REPAIR BEING PERFORMED. THE FAILURES RECURRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614582July 18, 2014
VISIBILITY:SUN/MOON ROOF ASSEMBLY, STRUCTURE
TL* THE CONTACT OWNS A 2008 VOLVO S80. THE CONTACT STATED THAT THERE WAS WATER LEAKING INTO THE VEHICLE FROM THE SUNROOF. AS A RESULT, THERE WAS WATER DAMAGE TO THE FRONT AND REAR FLOORBOARDS AND MOLD WAS PRESENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 52,000. ..UPDATED 08-25-14 *BF THE CONSUMER STATED VOLVO ADVISED THEY WOULD NEED TO REMOVE THE INTERIOR TO FULLY CLEAN AND DRY IT. THIS WAS NOT COVERED BY WARRANTY. THE MANUFACTURER DENIED ANY ASSISTANCE. UPDATED 09/2/2014 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10537976August 29, 2013
ENGINE
THIS 2008 VOLVO S80 HAS ALREADY HAD THE COOLING FAN CONTROL MODULE REPLACED THROUGH A RECALL.THE COOLING FAN STOPPED WORKING AGAIN CAUSING MY CAR TO OVERHEAT AND AIR CONDITIONER TO STOP WORKING. I CALLED CORPORATE AND THEY SAID THAT THEY ARE NOT RESPONSIBLE EVEN THOUGH IT IS THE SAME EXACT THING THAT WAS RECALLED (DUE TO THE RISK TO MOTOR VEHICLE SAFETY.) THEY CLAIM THAT ONCE THE RECALL REPAIR IS PERFORMED THE CAMPAIGN IS OFFICIALLY CLOSED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10511009May 7, 2013
FUEL/PROPULSION SYSTEM
MY VEHICLE'S FUEL GAUGE HAS NEVER WORKED CORRECTLY. WE HAVE TAKEN THE VEHICLE IN TO GET IT REPAIRED 4 TIMES IN THE PAST FIVE YEARS. THE ISSUE HAS NOT BEEN FIXED. I AM AFRAID THAT WITHOUT KNOWING THE CORRECT LEVEL OF FUEL IN THE TANK WE COULD GET IN AN ACCIDENT SHOULD THE CAR UNKNOWINGLY RUN OUT OF GAS ON A HIGHWAY. I HAVE DONE SOME RESEARCH ON THE WEB AND THIS SEEMS TO BE A COMMON PROBLEM THAT VOLVO IS DISREGARDING EXCEPT IN SOME LIMITED CASES. IT SEEMS TO BE AN ISSUE THAT COULD LEAD TO UNNECESSARY HIGHWAY DEATHS OR INJURIES IN A CAR GENERALLY ASSOCIATED WITH FAMILIES WITH SMALL CHILDREN LIKE OURS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10498122February 14, 2013
ELECTRICAL SYSTEM
INSTRUMENT CLUSTER PANEL FAULTY, UNABLE TO DETECT VEHICLE SPEED, BLINKER OPERATION, GAS IN FUEL TANK REMAINING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80