Subaru WRX Complaints (2004)

42 consumer complaints on file.

#11084965April 13, 2018
FUEL/PROPULSION SYSTEM
HAVING RECENTLY MOVED TO A COLD WEATHER STATE, I DISCOVERED THAT WHEN THE TEMPERATURE IS BELOW FREEZING THERE IS A SMELL OF GASOLINE IN THE PASSENGER CABIN. AFTER DOING SOME RESEARCH, SUBARU APPEARS TO BE AWARE OF THIS PROBLEM AND IN FACT ISSUED A RECALL ON EARLIER MODEL VEHICLES FOR THE SAME ISSUE. THE FUEL LINES AND CLAMPS SHRINK IN COLD WEATHER ALLOWING FUEL TO LEAK AT THE FUEL FILTER OR MORE PROBLEMATICALLY ONTO THE INTAKE MANIFOLD NEAR THE TURBO. THIS HAS BEEN RESOLVED IN NEWER MODEL VEHICLES, BUT FOR SOME REASON SUBARU DECIDED NOT TO ISSUE A RECALL FOR THE 2004-2005 VEHICLES HAVING THIS PROBLEM. WHEN THE VEHICLE WARMS UP, THE HEAT OF THE ENGINE REDUCES OR ELIMINATES THE LEAKS. ALTHOUGH I WAS ABLE TO TIGHTEN THE HOSE CLAMPS, I SUSPECT THAT NEXT WINTER I WILL BE FACING THE SAME ISSUE AND/OR A $500-1000 REPAIR BILL FROM THE DEALER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11057300December 29, 2017
ENGINE, FUEL/PROPULSION SYSTEM
DURING COLD WEATHER FUEL SMELL COMING FROM ENGINE AND IS LEAKING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10946917January 23, 2017
FUEL/PROPULSION SYSTEM
I HAVE A 2004 WRX AND WHENEVER IT GETS COLD LOTS OF FUEL LEAKS FROM UNDER THE INTAKE MANIFOLD THERES A RECALL FOR THE SAME ISSUE IN 2002 2003 BUT IT STILL DOES IT ON MY CAR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10897983August 23, 2016
AIR BAGS
TAKATA RECALL/SUBARU RECALL CAMPAIGN WQR-53 NHTSA RECALL NO. 15V-323 RECEIVED A RECALL NOTICE IN MAY 2015 EXPLAINING THAT THE AIRBAG WAS RECALLED AND WOULD NEED TO BE REPLACED. LETTER STATES THAT UNTIL THE REPAIR IS PREFORMED, DO NOT ALLOW PASSENGERS TO RIDE IN THE FRONT PASSENGER SEAT. I RECENTLY RECEIVED ANOTHER LETTER WITH THE SAME INFORMATION STATING THAT WHEN SUBARU ACQUIRES A SUFFICIENT SUPPLY OF PARTS TO PERFORM THE REPAIR, THEY WILL CONTACT ME ABOUT MAKING AN APPOINTMENT. I CALLED SUBARU 6 MONTHS AGO AND WAS TOLD THAT A DEALERSHIP SHOULD "LEND" ME A VEHICLE UNTIL THE REPAIR IS COMPLETE. I LEFT SEVERAL MESSAGES WITH DEALERSHIPS IN THE AREA AND NO ONE RETURNED MY PHONE CALL. IT HAS BEEN OVER A YEAR AND I AM NOT ABLE TO HAVE PASSENGERS IN MY VEHICLE. I USE MY CAR FOR WORK AND I NEED THIS FIXED. IT IS NOT SAFE TO DRIVE THIS VEHICLE AND I DO NOT WANT TO HAVE MY CHILDREN IN THE CAR UNTIL IT IS FIXED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10819641January 12, 2016
FUEL/PROPULSION SYSTEM
DURING VEHICLE OPERATION IN COLDER WEATHER (32 DEG F OR COLDER), THERE IS A STRONG FUEL SMELL COMING FROM THE ENGINE BAY. FUEL LINES ARE LEAKING IN AN AREA CLOSE TO THE AIR INTAKE. THIS DOES NOT HAPPEN DURING WARMER WEATHER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10779126October 1, 2015
AIR BAGS
WAS NOTIFIED IN JULY 2015 OF DEFECTIVE PASSENGER SIDE AIR BAG WITH WARNING TO NOT USE THE PASSENGER SEAT.UPON FOLLOWUP WITH SUBARU ON 10-1-2015 WAS TOLD THAT PARTS WOULD NOT BE AVAILABLE UNTIL AFTER 12-1-2015. THIS MEANS 5 MONTHS WITHOUT FULL USE OF MY VEHICLE. THEIR LETTER REGARDING NHTSA RECALL 15V-323 INFORMED M TO CONTACT NHTSA AT THIS WEBSITE IF SUBARU FAILED TO REMEDY THE VEICLE WITHOUT CHARGE IN A TIMELY MANNER. 5 TO 6 MONTHS IS NOT A TIMELY MANER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10672351January 14, 2015
ENGINE, FUEL SYSTEM, GASOLINE
STRONG SMELL OF RAW FUEL COMING INTO PASSENGER COMPARTMENT DURING VERY COLD OUTSIDE TEMPERATURES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671183January 8, 2015
FUEL SYSTEM, GASOLINE
IN BELOW-FREEZING TEMPERATURES, THERE IS A FUEL SMELL COMING FROM THE ENGINE BAY. IT SEEMS TO START AT APPROXIMATELY 20 DEGREES FAHRENHEIT, AND BECOMES INCREASINGLY STRONG AT LOWER TEMPERATURES. ON A RECENT MORNING WHEN THE TEMPERATURE WAS 9 DEGREES FAHRENHEIT, THE SMELL WAS STRONG ENOUGH TO CAUSE A LIGHT-HEADED SENSATION. THIS APPEARS TO BE A KNOWN PROBLEM, WITH THERE ALREADY BEING A RECALL FOR SIMILAR VEHICLES. MANY VEHICLES EXCLUDED FROM THE RECALL, INCLUDING MY OWN, SEEM TO EXPERIENCE THE SAME PROBLEM. EVEN WORSE, SOME WHO HAVE HAD THE RECALL FIX PERFORMED HAVE STATED THAT THE FIX PRESCRIBED BY THE RECALL DOES NOT ALWAYS RESOLVE THE PROBLEM COMPLETELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654124November 11, 2014
AIR BAGS
AS A RESULT OF A MULTI-VEHICLE TRAFFIC ACCIDENT THE PASSENGER SIDE AIRBAG DEPLOYED CAUSING THE FEMALE OCCUPANT TO HAVE A FRONTAL SKULL FRACTURE FROM SHRAPNEL LIKE PIECES AND NEURO TRAUMA. THESE INJURIES LEAD HER TO BE UNCONSCIOUS AND ON LIFE-SUPPORT FOR 6 DAYS AND ULTIMATELY HER DEATH......UPDATED 11-24/14 *BF
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
1
#10626516August 20, 2014
FUEL/PROPULSION SYSTEM
FUEL LINES LEAK UPON COLD START UP IN THE WINTER. FUEL LEAKS ALL OVER ENGINE BLOCK, MY FEAR THAT THIS CAN CAUSE A FIRE. SUBARU'S ANSWER IS TO BRING IT IN, SPEND MONEY TO HAVE THE CAR LOOKED AT. ALL THE WHILE THEY WILL NOT PROVIDE ME WITH A COMP CAR AND THIS IS MY ONLY CAR. WITH WORK, SCHOOL AND TRYING TO MOVE AT THAT TIME IT WAS NOT POSSIBLE TO RELEASE THE CAR TO THEM AND HOPE IT LEAKED ON THAT DAY FOR THE TECH OR RISK HANDING OUT CASH EVERY TIME I TAKE IT IN FOR THEM TO LOOK AT. THEY KNOW THEY HAVE AN ISSUE THEY DON'T WANT TO FIX ANY LONGER. THIS IS A KNOWN ISSUE FOR SOME WRX'S AND THEY SAY THE PROBLEM WAS TAKEN CARE OF IN 2004, OBVIOUSLY NOT. IT APPEARS MY CAR WAS BUILT IN MID 2003...... AND IS POSSIBLE IN MY OPINION THAT MY CAR COULD HAVE BEEN BUILT WITH THESE FAULTY PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563930February 11, 2014
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE
WHEN IN FREEZING TEMPERATURES, MY CAR IS LEAKING GASOLINE IN THE ENGINE COMPARTMENT. GASOLINE FUMES ARE ENTERING THE PASSENGER COMPARTMENT CAUSING NAUSEA,DIZZINESS AND COUGHING (HENCE I AM CLAIMING/CONSIDERING THIS AS PERSONAL INJURY). I CANNOT ALWAYS CLOSE THE EXTERNAL VENT BECAUSE OF FOGGING. THIS HAPPENS ALMOST EVERY TIME THE TEMPERATURE DROPS BELOW FREEZING. WORSE, I AM AFRAID OF THE ENGINE CATCHING FIRE. I WILL TAKE MY CAR TO THE DEALER FOR REPAIRS. I JUST WANT TO REPORT THIS. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10561735January 27, 2014
FUEL/PROPULSION SYSTEM
AFTER STARTING MY CAR IN COLD WEATHER, I NOTICED A STRONG SMELL OF GAS. I FOUND THAT THERE WAS GAS POOLING ON TOP OF MY ENGINE ON THE PASSENGER SIDE, UNDER THE INTAKE MANIFOLD. I TURNED THE CAR OFF AND THE GAS STOPPED LEAKING, BUT WHEN I TURNED IT ON AGAIN, I COULD SEE IT DRIPPING ON TO THE LOCATION THAT IT WAS POOLING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561186January 23, 2014
FUEL SYSTEM, GASOLINE
ON COLD MORNINGS LESS THAN 10 DEGREES A STRONG FUEL SMELL ENTERS THE VEHICLE. THIS ISSUE WAS SUBJECT TO RECALL ON 2002 AND 2003 MODEL CARS YET 2004 MODELS ALSO EXPERIENCE THIS PROBLEM. THIS IS A WIDE RANGING PROBLEM THAT EFFECTS MANY CARS ALL THE UP TO THE 2007 MODEL YEAR OF THE SUBARU IMPREZA. THIS PROBLEM HAS BEEN WELL DOCUMENTED SINCE 2002 ON THE LARGEST SUBARU IMPREZA WEB FORUM. HTTP://FORUMS.NASIOC.COM/FORUMS/SHOWTHREAD.PHP?T=131755. IT'S ABOUT TIME SUBARU FIXES THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10556567December 18, 2013
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
WHEN I START MY CAR WHEN IT IS COLD OUT 20 DEGREES OR BELOW MY GAS LINE NEAR THE FUEL RAIL LEAKS ON THE PASSENGER SIDE OF THE ENGINE UNTIL THE CAR WARMS UP. IT LEAKS A LITTLE UP TO ENOUGH TO POOL ON THE ENGINE..IT WORRIES ME BECAUSE IT IS ON THE TURBO SIDE OF THE ENGINE WITH THE EXHAUST WHICH TEMPERATURES CAN REACH UP TO 1500 DEGREES. THE CAR COULD EASILY CATCH FIRE. IT IS A KNOWN PROBLEM IN SUBARU IMPREZA WRX MODELS 02-05 AND HAS BEEN BROUGHT TO SUBARUS ATTENTION MULTIPLE TIMES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543452September 13, 2013
FUEL SYSTEM, GASOLINE
STARTED VEHICLE AFTER SITTING OVERNIGHT IN SUB-30 DEGREE WEATHER AND A VERY STRONG SMELL OF RAW FUEL WAS EVIDENT IN VEHICLE. THIS HAPPENED ON MANY MORE OCCASIONS; IN ANY SITUATION WHERE THE VEHICLE WAS GIVEN TIME TO SIT IN COLD WEATHER. AFTER THE CLAMPS WERE TIGHTENED ON THE LINES, THE SMELL WAS DECREASED; BUT AFTER FEAR OF A FIRE THE LINES AND CLAMPS WERE THEN REPLACED BY MYSELF. AS SUBARU OF AMERICA WOULD NOT EXTEND THE RECALL TO MY 2004 VEHICLES AND I COULD NOT AFFORD TO PAY RETAIL FOR THE REPAIR. THIS WAS VERY DISAPPOINTING, AS THIS IS MY FIRST SUBARU AND IT WAS EVIDENT THAT THE DESIGN WAS FAULTY. AFTER REPLACING THE LINES AND CLAMPS, IT SEEMS AS THOUGH THE PROBLEM HAS BEEN RESOLVED. HOWEVER, I CANNOT RULE OUT THE POSSIBILITY OF REQUIRED REPAIR IN THE FUTURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10494441January 23, 2013
FUEL/PROPULSION SYSTEM
WHEN THE WEATHER WAS VERY COLD OUT, ABOUT 10F THERE WAS A NOTICEABLE GAS SMELL OUTSIDE THE CAR AND IN THE CABIN WHEN THE HVAC TURNED ON. THIS IS A FUEL LINE ISSUE WHICH IS KNOWN TO SUBARU - THERE IS A RECALL ON 2002-2003 WRX MODELS. HOWEVER THERE IS NO RECALL ON LATER MODELS SUCH AS MY 2004 WRX, WHICH ALSO SUFFER FROM THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10494457January 23, 2013
FUEL/PROPULSION SYSTEM
AT TEMPERATURES AT OR BELOW 15F THERE IS A FUEL LEAK FROM THE INLET MANIFOLD. CAN SEE GASOLINE LEAKING NEAR WHERE THE FUEL LINE ENTERS THE MANIFOLD. LEAK STOPS ONCE VEHICLE HAS WARMED UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393598March 29, 2011
FUEL SYSTEM, GASOLINE
I HAVE A 2004 WRX AND WHEN THE VEHICLE IS LEFT OUTSIDE DURING VERY COLD TEMPERATURES, AT STARTUP, THERE IS A PROMINENT FUEL SMELL. THIS SEEMS TO OCCUR IF I LEAVE THE VEHICLE PARKED FOR AN EXTENDED PERIOD OF TIME (3+ HOURS) AT 20 DEGREE F OR BELOW. THERE HAVE BEEN NUMEROUS REPORTS REGARDING THIS DEFECT REPORTED ON THE NASIOC FORUMS. IN ADDITION, THERE IS A RECALL REGARDING THIS SAME DEFECT FOR THE 2002-2003 WRX'S. I AM GREATLY CONCERNED ABOUT THE RISKS ASSOCIATE WITH RAW FUEL BEING DISPERSED ON THE ENGINE UPON STARTUP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374858January 5, 2011
FUEL SYSTEM, GASOLINE
DURING COLD WEATHER (~36 F), THERE IS A STRONG FUEL SMELL IN THE CABIN. THE SMELL SEEMS TO BE COMING FORM THE ENGINE COMPARTMENT (PASSENGER SIDE). THE SMELL DISAPPEARS AFTER THE ENGINE WARMS UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10369538December 7, 2010
FUEL SYSTEM, GASOLINE
2004 SUBARU WRX STI. STRONG FUEL SMELL IN CABIN DURING COLD WEATHER. UPON START OF COLD ENGINE, AFTER A FEW MINUTES. SMELL OVERWHELMS CABIN TILL VEHICLE REACHES OPERATING TEMP. APPROX. 5-10 MIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Subaru WRX