DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE ANTI-THEFT WARNING INDICATOR KEPT RANDOMLY ILLUMINATING. THE VEHICLE WAS ABLE TO START AND, AT TIMES, UPON ENTERING THE VEHICLE, THE KEY WOULD NOT TURN OVER TO START THE VEHICLE FROM THE IGNITION. THE DEALER REPLACED THE BATTERY AND THE IGNITION SWITCH, BUT THE FAILURE CONTINUED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V036000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
No injuries · No fire · No crash
IN PART DUE TO CORROSION OF THE LOWER CONTROL ARM, IT EXPERIENCED A SUDDEN STRUCTURAL FAILURE RESULTING IN A SIGNIFICANT LOSS OF STEERING CONTROL. THIS PROBLEM OCCURRED TWICE TO MY VEHICLE. THE FIRST TIME IT OCCURRED WAS WHEN CORNERING AN HITTING A SMALL POTHOLE. I HAD THE CAR REPAIRED BY A GM DEALERSHIP AND THE SECOND TIME A FEW YEARS LATER THIS OCCURRED AGAIN AND IT WAS WHEN I HAD TO STOP ABRUPTLY TO AVOID A CAR RUNNING A RED LIGHT. THIS WAS THE SAME PART THAT FAILED EACH TIME AND RENDERED THE VEHICLE UN-DRIVEABLE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. WHILE DRIVING 25 MPH, THE IGNITION SWITCHED OFF INDEPENDENTLY AND CAUSED THE STEERING WHEEL TO LOCK WITHOUT WARNING. THE FAILURE CAUSED A FOUR VEHICLE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE WAS DESTROYED. IT WAS UNKNOWN IF ANY INJURIES WERE SUSTAINED OR IF A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE TRACTION CONTROL, SERVICE ENGINE AND ABS WARNING LIGHTS ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART AND THE TRACTION WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
No injuries · No fire · No crash