Kia EV6 Complaints (2023)

135 consumer complaints on file.

#11723608March 11, 2026
ELECTRICAL SYSTEM
In November 2025, after charging car overnight, backed out of driveway and began to drive. Within 100 feet, received red error message and tone: “Stop vehicle and check power supply”. Stopped the vehicle and got it towed to Kia dealer, who confirmed that the ICCU had failed, despite the car having received the software patch purporting to fix the problem. The ICCU was replaced under warranty within a week. We were fortunate that this occured very close to home, without safety consequences. Ten minutes later, the car would have been travelling at 65 on a highway with no shoulder for long stretches, which would have been very dangerous. This was a certified preowned EV6 with less than 9000 miles on it. The 12 volt battery was brand new, having been replaced 3 months earlier with an AGM battery as a possible preventative measure for this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722556March 6, 2026
ELECTRICAL SYSTEM
The ICCU fuse blew. As I was driving, the car began to lose power. Fortunately I was able to pull into a parking lot before I lost all power. It's the same issue as the recall SC327Y1 from NHTSA, which occurred although the software update had already been performed previously. The dealer is replacing the ICCU and ICCU fuse under SC327Y1 after inspecting it. I did receive a warning as I was driving that the car was low on power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722549March 6, 2026
ELECTRICAL SYSTEM
ICCU failed (first of two incidents).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722545March 6, 2026
ELECTRICAL SYSTEM
ICCU failed. Towed to dealer and awaiting a replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722118March 4, 2026
ELECTRICAL SYSTEM
The component that is seeming to fail in most KIA EV6's is the ICCU assembly. This is the component that failed in my KIA EV6 GT. Part# 364-1XFA0AQQK Also the ICCU Fuse, Part#375F2-GI040QQK FUSE-HIGH VOLTAGE. My safety and everyone around me was put at risk when the vehicle loss power due to this ICCU failure. As I entered the highway the vehicle starts loosing power. The vehicle gradually lost power more and more over time. I was able to make it to an exit driving at approximately 20-30 mph, and was able to drive it back to my house where it was then towed to a dealership. The problem has been confirmed by the dealer. I have the invoice to prove the repair of the ICCU. Yes there were warning messages on the screen when the ICCU failed. First, there was an audible "POP" which was the fuse blowing first. Once the fuse blows, it slowly kills the 12v battery and the car then looses power and you're no longer able to drive the vehicle. At that point, the ICCU is blown. The error message showing on the screen was: "CHECK ELECTRIC VEHICLE SYSTEM". Then the display starts blinking red and displays "STOP VEHICLE AND CHECK POWER SUPPLY". I have all the screenshots of the error messages the vehicle displays. The text message that is attached to this complaint is the service tech informing me that the 12v battery that they charged me $366.66 for, DID NOT FIX THE ISSUE. Yet they still charged me for the battery. This dealerships service department had my car from January 21, 2026 to March 4, 2026. A total of 42 days. At the time of the text message, it had already been past one month. I would like to be reimbursed for this cost.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722077March 4, 2026
POWER TRAIN
The ICCU failed. The vehicle suddenly stopped on the road, would not go into any gear and could not be moved whatsoever, was stuck on the side of the road in a dangerous position. Called roadside assistance, after a few hours the vehicle was towed to the nearest dealership. After a week the vehicle had the ICCU replaced under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721977March 4, 2026
ELECTRICAL SYSTEM
ICCU failure and IVCU fuse failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721743March 3, 2026
UNKNOWN OR OTHER
Dash board showed limited power couldnt accelerate above 10-12 mph pulled into residental area dash then showed warning sign 12v battery then car died in middle of street. Could not put car in neutral called dealership said car cannot be put in neutral without special tools. I had taken it in for recall in 2023 or 2024 cant remember. Luckily i was not on highway as i could not even turn on hazard lights and car shut off abruptly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721716March 3, 2026
ENGINE, FUEL/PROPULSION SYSTEM
On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive.\n\nThe next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message.\n\nI then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle.\n\nI attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.”\n\nThe vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced.\n\nThe ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721594March 2, 2026
POWER TRAIN, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
1st instance: Battery Coolant errors that occurred on and off. 2nd instance: The ICCU unit failed and car was not able to charge via level 2 and only fast charge. Car was still operable. Dealer replaced ICCU 3rd instance: The ICCU failed and car was rendered inoperable. Dealer Replaced ICCU. We are now on our third ICCU since we purchased the car in 11/26/2022. This would be considered a lemon law
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721162February 28, 2026
ELECTRICAL SYSTEM
While charging my vehicle at a level 2 charging station, my vehicle ceased charging. I received no other warnings or symptoms prior to my vehicle ceasing to charge. Upon being alerted by the Kia Access app that the charging stopped, I went to check my vehicle and none of my doors would unlock in response to the buttons on my keys. I had to manually unlock my driver side door in order to enter my vehicle. I attempted to start my vehicle and unplug/re-plug in the charger, but my vehicle would not start or charge. Using a portable jump starter, I was able to jump start my vehicle and begin charging again. However, after approximately 5 minutes of charging, my vehicle stopped charging and once again would not start. At that point, I called for my vehicle to be towed to a Kia Service Center. The Kia Service Center was able to reproduce the problem of my vehicle not starting or charging and informed me that there was an internal short circuit caused by a bad Integrated Charging Control Unit (ICCU). The bad ICCU shorted my ICCU fuse, resulting in the draining of my 12-volt battery. The ICCU and fuse were replaced at no cost to me. Although my vehicle is available for inspection upon request, the parts that malfunctioned have been replaced with new, functioning parts. My safety or the safety of others were not at risk in this situation, but I was fortunate that my 12-volt battery died while parked and charging, not while I was driving, which could have caused an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720624February 26, 2026
ELECTRICAL SYSTEM
While the vehicle was on the charger, the ICCU failed which then caused then fried my JuiceBox EV40 charger and flipped the dedicated circuit breaker. The car has since been repaired. I am concerned that this is a dangerous failure. If it happened on the road it potentially left me without propulsion. I'm also concerned that but for the circuit breaker functioning as designed it could have caused an electrical fire. My understanding is that this has been an ongoing problem with Kia and Hyundai EVs. I do not believe that Kia/Hyundai are taking responsibility for fixing the problem that have not plagued other manufacturers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720542February 25, 2026
ELECTRICAL SYSTEM
While driving the car we heard a loud pop in the cabin. That was followed by electrical warning lights on the dash. WE were only about a mile from home and did make it back safely at greatly reduced speed. The ICCU was confirmed to have failed by the dealership. The part was replaced. If we had been traveling on the highway it might have been difficult to find a safe place to exit the roadway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720337February 25, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, ENGINE
On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive. The next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message. I then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle. I attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.” The vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced. The ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719960February 23, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Pulling out of garage, car warned of limited speed and then within about 30 seconds completely shut down-- could not move, operate locks, etc. Car could not be started again and had to be towed away. 12v battery had been drained down to 4v due to failure of ICCU unit. Dealership replaced entire ICCU unit and fuse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719527February 20, 2026
ELECTRICAL SYSTEM
The ICCU went out on the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717524February 12, 2026
ELECTRICAL SYSTEM
ICCU failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716497February 7, 2026
ELECTRICAL SYSTEM
While driving in the evening with an estimated 180 miles range remaining a "pop" noise was heard. About a minute later a vague warning message the car had not displayed before appeared. We tried to make it home but concerning (and still vague) messages kept appearing quite rapidly. The car slowed down and came to a halt and died in an intersection. This all happened within five minutes of hearing the "pop" noise. Once the vehicle died the head and taillights went off and the car would not allow the emergency flasher lights to be turned on. It would not allow it to be put into neutral to allow it to be moved out of the intersection. It also would not allow any of its doors to be locked (manually or otherwise) except for the driver's door until the vehicle was repaired one week later. We found out following that the 12 volt battery had not charged due to a DC/DC converter input voltage sensor fault related to ICCU failure. The popping noise had been a fuse. As the applicable ICCU parts were replaced by the dealership I doubt they will be available for inspection. The safety of my family was put at risk by: - the car's warnings not clearly explaining what the issue was. - the car not giving clear indication of how quickly it would die. - the car dying in a busy intersection. - the car being unable to be shifted to neutral. - the car's warning flashers not being operational when it died in the middle of the intersection at night. - us being left without warmth in outside temperatures around 6 degrees Fahrenheit. The ICCU problem was confirmed by the dealership we purchased the vehicle from. The vehicle was only inspected by the dealership acting on behalf of Kia.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715439February 4, 2026
ELECTRICAL SYSTEM
With no warning except a pop, the vehicle iccu will fail and leave you stranded, very dangerous if you are driving on the parkway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715335February 3, 2026
ELECTRICAL SYSTEM
The ICCU has failed twice in my EV6. It is a fairly common issue for this vehicle. I had the ICCU replaced after the first failure, but it has failed again. There was no indication something was wrong with the car until I heard a pop and then the dash indicated "Check Electrical System"
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6