Hyundai · Model Report
Showing safety data for the 2020 model year only.
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
Hyundai Dealership, Pedder Hyundai of Poway, applied recall 9C2 to 2020 Santa Fe on 10/20/2026. Vehicle idle is now rough at startup and gas pedal angle no longer is reliable for controlling vehicle speed. Engine surges and jerks during initial operation on residential street due to software change. The vehicle did not operate in this manner for the last six years. I never felt like I had erratic engine control due to gas pedal response. I would like this recall removed and the original software re-applied, or my car bought back by Hyundai.
No injuries · No fire · No crash
My incident relates to peeling paint on my white 2020 Hyundai Santa Fe. The paint has started to bubble, crack and peel off on the rear hatch of the vehicle. Hyundai has had issues with white color paint peeling off on a variety of their vehicles, across multiple years. Hyundai issued an extended warranty program (Z05) to cover the issue. I took my Santa Fe to the Hyundai dealer body shop near me to assess my peeling paint issue. While at the body shop facility I saw and took photos of multiple white Santa Fe's and Tucson's with peeling paint that appeared to have the same paint issue my 2020 Santa Fe is starting to exhibit. Both the Hyundai dealership body shop and Hyundai's Customer Care center have stated that my specific VIN number is not covered for the issue. The Hyundai Customer Care center stated that they are unable to add me VIN number to their coverage, but advised me that if the Z05 Warranty Program for the paint defect is expanded in the future, and my VIN number becomes included, I would then be reimbursed for expenses I have incurred to address the problem. 10/20/26 - The body shop has now updated that Hyundai will cover 90% of the cost to repair the paint damage for this specific incident, but I am still pressing for them to completely cover the repair. I would also like to see my VIN number added to the Z05 Warranty Program coverage so that I, too, would receive coverage for any additional paint peeling issues should they arise during the remaining warranty period of my vehicle. I have included a picture of my Santa Fe's peeling paint issue, and a picture of one of the random cars from the Hyundai dealer body shop exhibiting the same problem.
No injuries · No fire · No crash
The vehicle is experience severe, progressive engine oil consumption, completely depleting its engine oil below the safe operating limit ("Low" mark on the dipstick) every 500 miles. This creates an imminent risk of sudden engine seizure, catastrophic mechanical failure, and sudden stalling at highway speeds. The authorized dealers (Safford Hyundai Manassas) and corporate case management (Case #43193472) have failed to fix the issue after multiple visits. Furthermore, dealership service staff explicitly instructed me that I must continue operating the vehicle for an additional 1000 miles even if the oil falls below the safe "Low" limit to satisfy corporate test parameters. Forcing a consumer to drive a vehicle with depleted engine oil is a severe safety hazard to myself and other drivers on the road. The manufacturer is also underreporting oil consumption volumes on service invoices to avoid warranty repairs.
No injuries · No fire · No crash
THERE IS A RECALL FOR THE SAME ISSUE ON THIS MODEL … I HAVE A CLAIM INTO HYUNDAI TO ALLOW MY VEHICLE TO BE REPAIRED UNDER THE SAME RECALL. This is a very dangerously problem and wish it to be investigated for the 2.0 Turbo as well. X Hyundai issued two main fuel-related recalls for the 2021 Santa Fe equipped with 2.5-liter turbocharged engines due to risks of fuel leaks and fires: & • Campaign 206 (NHTSA Recall 21V308000 / May 2021): The fuel pipe connecting the high-pressure fuel pump to the fuel rail may not have been tightened to the proper torque during manufacturing. Dealers inspected and retightened the connection for free. • Campaign 207 (NHTSA Recall 21V524000 / July 2021): Covering select 2021-2022 Santa Fe and Sonata models with 2.5L turbo engines, this recall addressed fuel pipes from a specific production run installed with insufficient torque or improper concentricity. Dealers inspected and either retightened or replaced the fuel pipe at no charge.
No injuries · No fire · No crash
I do not know what caused this. Here is what happened. While parking the car suddenly accelerated, over the curb, on the sidewalk narrowly missing the building because I turned hard right to avoid the building and I was able to brake to a stop glancing off a concrete pillar. We could have been hurt crashing into the wall/windows, anyone on the walk would have been hurt & anyone in the store could have been hurt. The car was towed to Hatchette Hyundai-East waiting to be looked at. There is no police report because it was private property and no damages except to my car. No warning lamps or messages. I remember 2 previous incidents that happened recently. While driving in normal city traffic, my passenger asked if I had speeded up? It was morning traffic, so I didn’t really think about it. Later that day while returning home there was a weird thing that happened. Again, in traffic, the car engine did something weird, but I thought it was the car reacting to the car beside me being too close. It was like it downshifted, slowed down and then resumed normally. The only other time I had any problem was on May 9th near Lawrence, Ks. The car began vibrating and felt like it was going on rumble strips when I accelerated and did not get up to speed. If I let off the gas it quit. I had the car taken to McCarthy Hyundai-Lawrence, Ks. They diagnosed an issue from the computer codes and completed repairs having the car from Monday until Wednesday.