Volvo · Model Report
Showing safety data for the 2006 model year only.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
The contact owned a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) and would like to be removed from the recall distribution list. The manufacturer was not contacted.
No injuries · No fire · No crash
The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted to schedule an appointment for the recall repair; however, the contact was unable to secure an appointment. The manufacturer was contacted and opened a case. The contact had not experienced a failure. Parts distribution disconnect.
No injuries · No fire · No crash
The contact owns a 2006 Volvo S60. The contact stated that the air bag was replaced under NHTSA Campaign Number: 21V766000 (Air Bags) and approximately 2 weeks later, while the vehicle was idling at a stop sign, the air bag compartment on the driver's side started smoking and the air bag warning light illuminated. The smoke then dissipated. There were no injuries or medical attention needed. The contact returned the vehicle to the dealer who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. the manufacturer was made aware of the failure. The approximate failure mileage was 84,190.
No injuries · No fire · No crash
My 06 s60 has blown 3 charge air hoses in the EXACT same spot. (The hose behind the radiator.) A golf-ball sized hole blows out in a bend in the hose while driving. The car will idle , but throttle up at all. The dealer says this is a fluke.
No injuries · No fire · No crash
Lug bolts 19 MM are rusted into the 330 MM Brembo Disk brakes, They take over 220 ft lb of force to break lose, and you can not do that safety on the side of the road to change a flat tire
No injuries · No fire · No crash