Volvo S60 Complaints (2004)

198 consumer complaints on file.

#10808882December 7, 2015
ENGINE, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL RAIL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10807716December 1, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING 65 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO BE DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10778030September 28, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHEN TURNING THE KEY INTO THE IGNITION SWITCH, THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748225August 12, 2015
ENGINE
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE STALLED ON MULTIPLE OCCASIONS WHILE DRIVING. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703247April 1, 2015
FUEL/PROPULSION SYSTEM
MARCH 2014: I WAS TRAVELLING ON A DIVIDED HIGHWAY AT 55 MPH AND THE CAR STALLED. MECHANIC STATED IT WAS THE FUEL PUMP. MAR 2015 : THIS SAME EVENT OCCURRED AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10691802March 3, 2015
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER, SEATS
TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE THE HEATED DRIVER SIDE SEAT WAS IN THE ON POSITION, A BURNING ODOR STARTED TO EMIT INSIDE THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACTED DISCOVERED A FLAME COMING FROM THE SIDE OF THE DRIVER SEAT. THE CONTACT INDICATED THAT THE FLAME SELF EXTINGUISHED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,000. UPDATED 4/7/15*CN
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10661751January 29, 2015
ENGINE AND ENGINE COOLING
2004 VOLVO S60R, EXPERIENCE TOTAL ENGINE SHUTDOWN AT APPROXIMATELY 30 MPH THE VEHICLE JUST QUIT RUNNING. CW A DIAGNOSTIC INVESTIGATION BY THE DEALER, CONFIRMED THE FUEL PRESSURE SENSOR WAS AT FAULT. THE SENSOR WAS REPLACED AT A COST OF $ 420.69. THE CONSUMER INQUIRED ABOUT A RECALL. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN RECALL # 07V226000. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679079January 27, 2015
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE ENGINE SEIZED. THE FAILURE HAD RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES AS LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 187,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10677090January 21, 2015
ENGINE, STEERING, SERVICE BRAKES
THE 2.4L 2004 VOLVO S60 EXPERIENCES ERRATIC BEHAVIOR AND ENGINE FAILURE WHEN OPERATING MULTIPLE CONCURRENT ELECTRICAL SYSTEMS. WHEN THESE SYSTEMS (OPERATED WITHIN SPECIFIED GUIDELINES) ARE USED CONCURRENTLY THEY CAUSE THE FOLLOWING CONDITIONS: ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF BRAKES. THE FOLLOWING IS A LIST OF ELECTRICAL CHANNELS THAT HAVE BEEN USED TO TRIGGER THE ENGINE FAILURE: BRAKES, INDICATOR LIGHTS (RIGHT OR LEFT) HEATED SEATS (X2) FRONT WINDSHIELD DEFROST MULTIPLE S60 MODEL OWNERS HAVE REPORTED HAVING EXPERIENCED THIS SAME ENGINE FAILURE WHICH CANNOT BE DETECTED BY THE MANUFACTURES DIAGNOSTICS TEST. WHEN TESTED THE BATTERY, ALTERNATOR AND COMPUTER ALL PRESENT POSITIVE READ-OUTS. HTTP://REPAIRPAL.COM/REPLACED-MAP-SENOR-AND-MAF-AIRFLOW-ENGINE-LIGHT-BACK-ON-HESITATE-STILL-CUT-OFF-321 HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2290017/VOLVO-S60-ENGINE-CUTS-OFF-WHILE-TURNING HTTPS://ANSWERS.YAHOO.COM/QUESTION/INDEX?QID=20110502120739AA0TJSR THIS IS A SERIOUS CONDITION THAT COULD RESULT IN A COLLISION OR EVEN DEATH. A RECALL ON THIS MODEL IS BEING IMMEDIATELY REQUESTED. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10681259January 7, 2015
STEERING
I AM WRITING ABOUT WHAT MAY BE DESIGN FLAW WITH THE VOLVO S60R THAT HAS ME VERY CONCERNED. MY FRONT TIRES RUB ON THE BODY IN THE WHEEL WELL WHEN I TURN SHARPLY INTO A PARKING SPACE. I DON'T THINK IT SHOULD DO THAT BUT I'VE BEEN TOLD IT'S "NORMAL" AND THE CAR "SETTLES" AS IT GETS OLDER. SEVERAL OTHER VOLVO S60 OWNERS HAVE THIS SAME PROBLEM WHERE THE TIRES RUB ON THE BODY. PLEASE LOOK INTO THIS. I BELIEVE IT WILL CAUSE SERIOUS CONSEQUENCES IN AN EMERGENCY SITUATION AND IT'S WEARING DOWN THE EDGE OF THE TIRES PREMATURELY, WHICH MAY ALSO BE DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668747December 29, 2014
SEATS, ELECTRICAL SYSTEM
DRIVER'S SIDE SEAT STARTED SMOKING WITHIN A FEW SECONDS OF STARTING THE VEHICLE WHILE BACKING OUT OF PARKING PLACE. SEAT HEATER WAS ON. IMMEDIATELY STOPPED AND TURNED OFF SEAT HEATER AND SMOKING STOPPED. QUARTER SIZE HOLE WAS BURNED INTO THE LEATHER SEAT BOTTOM ON THE DRIVER'S SIDE OUTSIDE PANEL. TOOK IT TO DARRELL WALTRIP VOLVO/SUBARU IN FRANKLIN, TN, AND THEY SAID IT WAS THE SEAT HEATER AND TOOK THE FUSE OUT. SAID IT WASN'T COVERED UNDER WARRANTY AND NO RECALL OUT. HOPE NO ONE HAS THIS PROBLEM DRIVING DOWN THE INTERSTATE. BEST REGARDS AND THANKS FOR ALL YOUR HARD WORK, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10667635December 22, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE WAS LEAKING A LARGE AMOUNT OF FUEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10661589December 2, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE STALLED.THE PROBLEM RECURRED NUMEROUS OF TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654041November 10, 2014
FUEL SYSTEM, GASOLINE
MY CAR WAS DYING ON THE HIGHWAY OR ON A REGULAR STREET ROAD. ENDED UP BEING THE FUEL PRESSURE SENSOR WHICH IS ON THE RECALL LIST BUT DIDN'T COME UP FOR MY VIN. I WAS DEALING WITH THIS FOR 6 MONTHS OR SO AND IT WAS VERY DANGEROUS. I DON'T UNDERSTAND WHY MY CAR ISN'T ON THE RECALL LIST. ANY HELP IS APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10651699October 31, 2014
POWER TRAIN, ELECTRICAL SYSTEM
WHILE DRIVING, THE CAR JERKS VIOLENTLY - THE SAME THING HAPPENS WHEN THE CAR IS IDLING (NO JERK, ONLY AN "CLICK" SOUND). IT HAPPENS ANYTIME BUT SEEMS WORSE IN THE SUMMER BUT I THINK IT'S HOT-HEAT RELATED. THE OTHER ISSUES ARE RELATED: -THE INTERIOR LIGHTS USUALLY COME ON -THE INSTRUMENT PANEL GOES COMPLETELY BLANK/LIGHTS GO OFF/NO AVAILABLE EMERGENCY LIGHTS -THE WINDSHIELD WIPERS MAKE ONE WIPE SOMETIMES -THE "REAR PASSENGER DOOR OPEN" WARNING COMES ON -THE "BRAKE FAILURE STOP SAFELY" WARNING COMES ON AND SOMETIMES "CHECK ENGINE" LIGHT COMES ON. NOT ALL OF THESE SYMPTOMS OCCUR EACH TIME. THERE ARE MORE SEVERE AND LESS SEVERE INCIDENTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10651726October 31, 2014
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE WOULD LOSE POWER AND EXHIBIT A SUDDEN INCREASE IN ENGINE RPMS BEFORE THE VEHICLE ACCELERATED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER DIAGNOSED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10630871September 4, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE DRIVING 70 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER HAS BEEN MADE AWARE OF THE PROBLEM AND STATED THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610925July 16, 2014
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE
LOSS ACCELERATION IN THE VEHICLE ON THE HIGHWAY AT 60 MPH. THE CAR WOULD NOT SPEED UP AND CONTINUE TO SLOW DOWN BUT NEVER CAME TO A FULL STOP. I WAS NOT ABLE TO GO PASS 40 MPH IN THE CAR AND ACCELERATION WAS SLOW. FIRST TIME IT HAPPEN, THE DEALER SAID THROTTLE BODY AND OIL COLLECTION SYSTEM NEEDED TO BE REPLACED. I REPLACED BOTH. IT HAPPENS AGAIN, TOOK IT TO A DIFFERENT PERSON, THE MECHANIC SAID FUEL CONTROL NEEDED TO BE REPLACED. I REPLACED THAT. IT HAPPEN THE THIRD TIME AND TOOK IT TO DEALER AND HE INFORMED ME THE SPARK PLUGS. I REPLACED THAT. NOW, THE PROBLEM IS STILL HAPPENING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609526July 10, 2014
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH ATTEMPTING TO COME TO A COMPLETE STOP, THE VEHICLE STALLED WITHOUT NOTICE. THE CONTACT MENTIONED ALL LIGHTS ON THE CONTROL PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO MADE THE CONTACT AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10596307June 5, 2014
ELECTRICAL SYSTEM
CAR WAS IN PARK AND RUNNING WHEN ELECTRICAL WIRES TO THE WINDSHIELD WIPERS CAUGHT FIRE. THE BUNDLE OF WIRES ARE HOUSED IN A RUBBER TUBE. MY UNDERSTANDING IS RUBBER IS QUITE FIRE-RESISTANT. THERE HAVE BEEN 5 RECALLS ON THIS MODEL, TWO WHICH WERE RELATED TO ELECTRICAL FIRES. NEITHER APPLIED TO THIS PARTICULAR CAR FIRE. LOCAL VOLVO DEALERSHIP WANTS NOTHING TO DO WITH THE SITUATION; THEY SEND US TO CORPORATE CUSTOMER SERVICE AND THEY, IN TURN SEND US BACK TO THE LOCAL DEALERSHIP . SERVICE MANAGER SAID HE WAS NOT A KNOWLEDGEABLE FIRE INSPECTOR AND SUGGESTED THAT WE HIRE AN EXPERT IN THAT FIELD. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Volvo S60