Volkswagen · Model Report
Showing safety data for the 2001 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.
No injuries · No fire · No crash
The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks unlocked twice while I was driving the car. After the second time, I tried to lock the car doors by pressing the lock button on the driver's door console but the doors would not locked. At that time I noticed that the two interior lights in the back seat area were turned on. All the doors of the car were properly shut. When the airbags deployed I was driving on the smooth 1 year old concrete section of Hwy 494. I did not hit anything on the highway. After the deployment, I parked on the shoulder, shut off the engine and opened the passenger door to air out the car. After about 5 minutes, I got back in the car and drove home. The automatic locks worked again. The interior lights automatically turned off. The drive home was uneventful.
No injuries · No fire · No crash
TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.
No injuries · No fire · No crash
ABS LIGHT ON AND BREAK LIGHT FLASHING
No injuries · No fire · No crash
STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS MILEAGE WENT WAY DOWN AND AND SMELLS LIKE GAS AND HE WAS TOLD THAT HE WAS DRIVING A BOMB BASICALLY. IT COULD BE AROUND $1000 TO FIX IT. NONE OF US HAVE THAT KIND OF $ AND HES STILL HAS $800 LEFT OWEING ON IT. HELP
No injuries · No fire · No crash