Volkswagen GTI Complaints (2016)

67 consumer complaints on file.

#11774037October 27, 2026
STRUCTURE:BODY
On sunday october 18 i was having lunch inside my car and the sunroof exploded out of no where,i got out of the car to see what fell on it and nothing was around, i called my insurance and they told me that they don't cover that because they work with safelite and safelite doesn't do sunroof. I went and procceed to call a volkswagen dealer to explain what happend and they told me i need to call volkswagen costumer care wich i did. When i called them they told me to call the dealer seems like nobody wants to take care of this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721581March 2, 2026
STEERING
While driving my 2016 Volkswagen GTI MK7 Autobahn Edition with approximately 37,000 miles, the power steering suddenly and without warning failed completely. The steering wheel became extremely difficult to turn, requiring significant physical force to operate. Simultaneously, both the TPMS (Tire Pressure Monitoring System) warning light and the ESC (Electronic Stability Control) warning light illuminated on the dashboard. I brought the vehicle to an authorized Volkswagen dealership, Deel Volkswagen in Miami, Florida. The dealership diagnosed the issue as a complete failure of the steering rack and pinion assembly and quoted approximately $6,000 for replacement. This failure occurred at only 37,000 miles — far below any reasonable expectation of component life for a steering rack, which should last well over 100,000 miles under normal use. The failure was sudden, with no prior warning signs or gradual degradation. A sudden and total loss of power steering assist while driving at any speed constitutes a serious and unreasonable safety risk, as it dramatically increases the force required to steer and can cause loss of vehicle control. A review of MK7 GTI owner forums and communities reveals this is a recurring and documented issue among this vehicle population, suggesting a systemic defect in the steering rack assembly used in this model. I am requesting that NHTSA investigate whether a safety defect exists in the 2016 Volkswagen GTI steering system that warrants a recall and manufacturer-funded remedy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719667February 21, 2026
ENGINE, FUEL/PROPULSION SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
NHTSA Recall 24V-110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V-110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is at their 'discretion.' I am reporting a failure by the manufacturer and the dealer to remedy an active safety defect, leaving me with an unsafe, undriveable vehicle."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711276January 15, 2026
UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677730August 1, 2025
FUEL/PROPULSION SYSTEM
Fuel is leaking from near the gas tank when the car is running and creates a puddle- I took my car to the local VW dealership in February to get the Suction Jet Pump Recall completed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675516July 23, 2025
UNKNOWN OR OTHER
I was driving on the highway, and heard a quiet sound like someone sprinkling sand on my windshield for about 10 seconds. All of a sudden, the sun roof burst and shattered with a loud pop. Luckily the internal slide-able screen webbing kept the glass from entering the compartment (except a bit of glass dust and small shards). I never heard a rock hit, or any other cause. I believe the ‘sand sprinkling’ sound was the ‘spider web’ cracks spreading prior to the burst. Obviously that is extremely dangerous while driving on the highway. If it wasn’t for the internal screen keeping the glass off me, it could have been much worse. I was able to pull off the highway and temporarily secure the glass with some cardboard and packing tape.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635998January 14, 2025
ENGINE
Repeated issues with leaking water pump and broken seals under the intake manifold causing vehicle to be underivable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605953August 1, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The contact stated while the vehicle was parked, the contact became aware of fuel leaking from the rear of the vehicle. The vehicle was towed to the dealer where the vehicle was diagnosed with a fuel leak coming from the fuel tank suction pump. The contact was informed that the fuel tank suction pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000. VIN tool confirms part not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11584518April 22, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Volkswagen Golf GTI. The contact stated that while driving at an undisclosed speed, there was an abnormally strong gasoline odor coming from the exhaust. The contact stated that while attempting to fill the tank, the tank failed to accept more than a half tank of fuel. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was contacted and diagnosed the vehicle with a failure of the fuel pump which was replaced; however, the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when the part would be available. The failure mileage was approximately 160,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581655April 8, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline). The contact stated that while refueling, the gasoline was leaking from the vehicle from an unknown location. The vehicle was taken to an independent mechanic where it was diagnosed that the carbon canister was clogged with fuel and needed to be replaced. The vehicle was repaired started the vehicle was losing motive power. On another occasion, nine months later, the failure reoccurred. The vehicle was taken to a dealer where it was diagnosed and determined that the purge valve, fuel tank, N80, carbon canister, and other unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 24,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574698February 29, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2016 Volkswagen Golf GTI. The contact stated that while making a turn at an undisclosed speed, there was water leaking through the sunroof. The contact stated that the sunroof frame had previously been replaced; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed that the sunroof frame needed to be replaced for the second time; however, the part was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562029December 27, 2023
ENGINE AND ENGINE COOLING
The contact owns a 2016 Volkswagen GTI. The contact stated that while starting the vehicle, the vehicle experienced a rough start, and the temperature gauge was fluctuating. Additionally, an unknown triangle warning light was illuminated. Additionally, the contact became aware that the coolant level was significantly low, and that the vehicle was overheating while activating the heater. The vehicle was taken to the dealer where it was diagnosed that the water pump needed to be replaced. The vehicle was then taken to an independent mechanic, where the water pump was replaced; however, the failure recurred. The contact stated that the vehicle was overheating, and he noticed that coolant was leaking underneath the vehicle. Additionally, the contact stated that while driving on a bridge, the low coolant level warning light illuminated, and the vehicle was overheating. The contact stated that the vehicle was taken to an independent mechanic several times and the water pump was replaced four times; however, the failure persisted. The vehicle was taken to an independent mechanic where the water pump was replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11536443August 4, 2023
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2016 Volkswagen GTI. The contact stated that while driving at an undisclosed speed, the sunroof leaked water into the fuse box. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11499865January 3, 2023
AIR BAGS
The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426137July 23, 2021
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Volkswagen Golf GTI. The contact stated that soon after purchasing the vehicle, she had difficulty placing gas into the fuel tank as fuel would spill out during fill up. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling). The vehicle was taken to a dealer who informed her that there were no recalls on the vehicle. The contact was then referred to the manufacturer who also confirmed that the vehicle was not under recall. The contact was referred to the NHTSA for assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413570April 23, 2021
FUEL/PROPULSION SYSTEM
THE CAR ON IS LEAKING GASOLINE FROM BACK OF THE GAS TANK, THE CAR VAS IN MOTION AND I SMELL GASOLINE FROM MY CAR AND MAY CAUSE A FIRE BECAUSE IS NEAR THE WHEEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11408156April 14, 2021
ENGINE, POWER TRAIN
FAILURE OF THERMOSTAT HOUSING CAUSING COOLANT LEAK AND WATER PUMP FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397227February 21, 2021
ENGINE
FAILED THERMOSTAT HOUSING/COOLANT LOSS. ACTIVE COOLANT LEAK FROM WATER PUMP/THERMOSTAT HOUSING AT 35,956 MILES. DEALER REPLACED THERMOSTAT ASSEMBLY, WATER PUMP, UNION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11396358February 15, 2021
FUEL/PROPULSION SYSTEM
THE SUCTION PUMP (PART 5Q0-201-029) IN THE EVAP EMISSION CONTROL OF MY VEHICLE FAILED ON FEBRUARY 7 2021 CAUSING FUEL TO BE BROUGHT INTO THE CHARCOAL CANISTER AND THEN INTO THE PURGE VALVE. THIS LED TO HEAVY FUEL SMELL IN MY VEHICLE AND REQUIRED REPLACEMENT OF SUCTION PUMP, CHARCOAL CANISTER AND PURGE VALVE. NOTE THAT THIS FAILURE WITH EXACT SAME DESCRIPTION WAS IDENTIFIED AS PART OF THE SAFETY RECALL 20Y6 (HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2016/RCRIT-16V647-1179.PDF) ISSUED BY NHSTA ON OCTOBER 13 2016 AND MY VEHICLE WAS PART OF THIS RECALL. IT WAS CLAIMED THAT THE ISSUE WAS FIXED ON MY VEHICLE ON JUNE 28 2017 AS PART OF THIS RECALL BY VW DEALERSHIP. HOWEVER, THE SUCTION PUMP WHICH FAILED ON FEBRUARY 7 2021 HAD THE MANUFACTURING DATE STAMP OF 15.08.15 WHICH INDICATES THAT PERHAPS VW DIDN'T REPLACE THE SUCTION PUMP AS PART OF THE RECALL REPAIR OR REPLACED IT WITH ANOTHER FAULTY SUCTION PUMP WHICH STILL HAD THE ISSUE (SINCE THE MANUFACTURING DATE OF THE FAILED SUCTION PUMP IS ALMOST 2 YEARS BEFORE THE DATE OF RECALL REPAIR). VW OF AMERICA HASN'T PROVIDED ME CLEAR ANSWERS TO MY QUESTIONS STATED BELOW (SEE ATTACHED LETTER DATED FEBRUARY 13 2021, THAT I SENT TO VW OF AMERICA RAISING THESE CONCERNS): I) WOULD THIS SUCTION PUMP THAT FAILED AND WHICH WAS MANUFACTURED ON 15.08.15 WILL HAVE THE FIX FOR THE ISSUE IDENTIFIED IN 20Y6? II) WHAT WAS THE MANUFACTURING DATE OF THE SUCTION PUMP ORIGINALLY INSTALLED ON MY VEHICLE BEFORE THE RECALL REPAIR WAS PERFORMED? VW OF AMERICA REPLIED TO ME ON FEBRUARY 15 2021 STATING THAT THEY WON'T HELP ME WITH THIS REPAIR AS THE PART WAS OUT OF WARRANTY. HOWEVER, THEY DIDN'T PROVIDE ME ANSWERS TO THE SPECIFIC QUESTIONS I RAISED. IF THE RECALL REPAIR WAS NOT DONE PROPERLY, ISN'T VW STILL RESPONSIBILE TO FIX THE ISSUE THAT MY VEHICLE SUFFERED AND I WOULD ALSO LIKE THEM TO PROVIDE ME CLEAR ANSWERS TO THE ABOVE TWO QUESTIONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11394604February 4, 2021
POWER TRAIN
CLUTCH MASTER AND SLAVE CYLINDER FAILED AT 34,700 MILES. BECAUSE HYDRAULIC FLUID CONTAMINATED CLUTCH PLATE AND FLYWHEEL THOSE WERE ALSO REPLACED. FAILURE OCCURRED AT LOW SPEEDS ON A COMMERCIAL STREET. SYMPTOMS: CLUTCH PEDAL DROPPED TO THE FLOOR AND WOULD NOT COME BACK UP. HYDRAULIC FLUID LEAKED OUT FROM UNDER THE CAR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen GTI