Toyota Highlander Complaints (2004)

286 consumer complaints on file.

#11739508May 22, 2026
ENGINE, STEERING
Hello, I am the Buyer of the subject Vehicle, Upon doing my research, I found out several reports stating that The subject vehicle's 2.4L engine has manufacturing defect, that causes Head Bolts to get stripped/melt down in to oil causing Engine failures and Life threating risk in the middle of the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618886October 9, 2024
AIR BAGS, WHEELS
My car malfunctioned my tire locked up while I was driving on the high way causing me to spin out of control and skid all the way into a guard rail totalled my car out and not one air bag went off
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11572352February 16, 2024
AIR BAGS
The passenger airbag occupancy sensor in my car has stopped sensing a passenger has been stuck on "OFF" for the past 2-6 months (I believe) even when an adult is sitting in the seat. I don't know exactly when this problem began because there was never any warning light or error message which is a massive safety oversight since I could have been in accident with no knowledge that it wasn't working properly. The car is currently at the dealership and they are telling me it's $1300 to replace the sensor and that there is no way to bypass the sensor and just have it "ON" for the safety of my passenger. There is already a recall for this same system in newer Highlanders, but why is there no support for older Highlanders?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11552313October 27, 2023
STRUCTURE:BODY:BUMPERS
The contact owns a 2004 Toyota Highlander. The contact stated while driving at an undisclosed speed, the front bumper inadvertently detached. The vehicle was taken to an independent mechanic where it was determined that the front lower bumper covers had been attached with mounting tabs and that the bumper assembly had failed and needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11386458January 4, 2021
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE AND PRESSING TO BRAKE PEDAL, THE PEDAL FAILED TO RETURN TO THE IDLE POSITION. THE VEHICLE STABILITY CONTROL MESSAGE DISPLAYED ON THE INSTRUMENT PANEL AND THE VEHICLE FAILED TO EXCEED 40 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS THEN DRIVEN TO THE LOCAL DEALER GROOVE TOYOTA LOCATED AT 5460 S BROADWAY, ENGLEWOOD, CO 80113 HOWEVER, THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE MANUFACTURER WAS NOT YET CONTACTED. THE FAILURE MILEAGE WAS 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11355039September 14, 2020
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL, STEERING
WHILE TRAVELING THROUGH A HIGHWAY CONSTRUCTION ZONE MY CAR SUDDENLY BECAME HARD TO STEER, AND MY SPEED BECAME GREATER, TRIED TO (BREAK) DECELERATE THE CAR BEGAN SLIDING OUT OF CONTROL-PLOWING INTO THE ROAD CONSTRUCTION BARRIERS PART LODGED IN FRONT PASSENGER WINDSHIELD. THE CAR WENT THROUGH THE DITCH BECAME AIRBORNE THROUGH A ROD IRON FENCE SHATTERED THE REAR SECOND-ROW RIGHT SIDE WINDOW SPUN OUT , AND CAME TO REST JUST FEET FROM THE SOME PILEINGS. THIS IS THE INFORMATION OF MY DAUGHTER WHOM IS AN OUT OF STATE COLLEGE SENIOR AND VERY SHAKEN UP FROM THIS ORDEAL, THIS HER STATEMENT TO THE BEST OF MY KNOWLEDGE. POSSIBLY THE PLACEMENT OF THE 🚧 COULD HAVE BEEN A CONTRIBUTOR, AND THE UNCONTROLLABLE ACCELERATION. VEHICLE WAS BOUGHT USED A YEAR AGO. CAN YOU HELP UP LEARN WHY?
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11153718November 26, 2018
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. UPON APPLYING MINIMAL PRESSURE TO THE ACCELERATOR PEDAL, THE ACCELERATOR PEDAL BECAME STUCK AND THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE, A DUMPSTER, AND ALMOST STRUCK A GROUP OF CHILDREN BEFORE COMING TO A STOP. IN AN ATTEMPT TO STOP THE VEHICLE, PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL AND THEN THE BRAKE PEDAL. THE VEHICLE FINALLY STOPPED AND WAS TURNED OFF. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SEVERE PAIN TO THE NECK AND BACK, WHICH REQUIRED MEDICAL ATTENTION. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE CRASH. THE VEHICLE WAS SUBJECT TO NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 170,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11022298September 8, 2017
SEAT BELTS
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT ASSEMBLY MALFUNCTIONED AND THE FABRIC MATERIAL STRAP BECAME FRAYED AND SHREDDED AT THE BUCKLE LOCATION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (ATLANTIC TOYOTA IN LYNN, MASSACHUSETTS) AND MANUFACTURER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11004382July 11, 2017
UNKNOWN OR OTHER
THE TRANSFER CASE IS LEAKING AFTER ONLY 68000 MILES. THE LEAKING OIL DROPS OVER THE HEATED EXHAUST PIPE WHICH CAUSES FUME IN THE CABIN THROUGH AIR CONDITION AND FAN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10971175April 7, 2017
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), TRACTION CONTROL SYSTEM
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOOR. THE TRACTION CONTROL, CHECK ENGINE, VSC, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 10V499000 (SERVICE BRAKES), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,489.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954090February 12, 2017
ENGINE
MY TRAC OFF LIGHTS, ENGINE AND OIL LIGHT CAME ON WHEN I WAS DRIVING TO WORK. I WORK FAR FROM HOME SO I TOOK IT TO THE VALVOLINE NEAR MY JOB TO CHECK THE OIL. I DIDN'T WANT TO DRIVE MY CAR HOME IF THERE WAS NO OIL. THEY CHECKED THE OIL, UNDERNEATH MY CAR AND SAID EVERYTHINGWAS FINE AND TO TAKE TO MY MECHANIC TO CHECK THE ENGINE. I TOOK IT TO MY MECHANIC WHO KEPT IT FOR 4 DAYS AND SAID ITS THE OIL SLUGE AND HE WAS TRYING TO SAVE THE ENGINE. MY MECHANIC SAID THEY HAD A LEXUS IN THE WEEK BEFORE WITH THE SAME PROBLEM. I CHECKED ONLINE AND FOUND OUT THERE WAS RECALL FOR THIS PROBLEM IN 2002, AND TOYOTA ONLY CONTACTEDTHE ORIGINAL OWNERS NOT ALL PEOPLE WHO HAD REGISTERED CARS. I BOUGHT THIS SECOND HAND THROUGH CAR MAX IN 2010 AND THIS SHOULD HAVE BEEN CORRECTED THEN. MY CAR HAS 145,000.00.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10906228September 13, 2016
ENGINE
THE OUTER RING OF THE CRANK SHAFT PULLEY HAS PULLED AWAY FROM THE INNER RING CAUSING DAMAGE TO ALL SYSTEM AND CAN AFFECT STEERING. THIS ALREADY HAS A RECALL FOR MY MAKE, MODEL AND YEAR, BUT NOT FOR MY VIN NUMBER. IT SEEMS STRANGE THAT THIS EXACT SAME THING THAT HAS THE RECALL AFFECTS MY CAR, BUT REPAIR IS NOT COVERED. SHOULD RECALL BE EXPANDED TO INCLUDE OTHER VIN NUMBERS??
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10884668July 13, 2016
ELECTRICAL SYSTEM
THE PASSENGER SIDE IN THE REAR WINDOWS ARE DEFECTIVE. THEY WILL NOT POWER UP OR DOWN THE WINDOWS IN THE BACK OF SUV. ALSO THE FRONT PASSENGER SIDE IS NOW NOT OPERATING UP OR DOWN. THE POWER WINDOW PARTS HAVE FAILED TWO YEARS AGO, AND NOW IT'S HAPPENING AGAIN. THIS 2004 SHOULD BE INCLUDED IN THE OTHER RECALLS ON NEWER MODELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10883405July 7, 2016
STEERING
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE REQUIRED GREATER EFFORT TO STEER. WHILE STEERING THE VEHICLE, THERE WAS AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WERE IT WAS DIAGNOSED THAT THE STEERING INTERMEDIATE STAFF ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872252June 2, 2016
AIR BAGS
THIS HAS BEEN GOING ON FOR TWO DAYS NOW. THERE IS A BUZZING LIKE SOMETHING IS MALFUNCTIONING ON MY PASSENGER SIDE COMING FROM THE DASH I BROUGHT THE VEHICLE TO PEP BOYS AND THEY SAID THAT MY AIR BAG IS MALFUNCTIONING. IS RESULT OF THIS MY JOB WON'T LET ME DRIVE PATIENTS BECAUSE OF THE DANGER. THIS REALLY NEEDS TO BE FIXED. I KNOW FOR A FACT IT'S THE AIRBAG BECAUSE TOYOTA TOLD WHEN I BROUGHT IT THERE BECAUSE PEP BOYS TOLD GO TO THE DEALERSHIP FOR THEM TO CONFIRM AND IT WAS!. THIS HAPPENS IN MOTION AND A LITTLE WHILE IN MOTION. WHEN IT IS HUMID OUTSIDE THE BUZZING IS EVEN WORSER TO WHERE THE SIDE PANEL VY DRIVERS LEFT LEG VIBRATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10861258April 25, 2016
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNED A 2004 TOYOTA HIGHLANDER. WHILE DRIVING 20 MPH AND MAKING A RIGHT TURN, THE VEHICLE ACCELERATED TO APPROXIMATELY 75 MPH. THE VEHICLE CRASHED INTO AN OAK TREE. THE CONTACT WAS KNOCKED UNCONSCIOUS AND TAKEN TO THE HOSPITAL. THE CONTACT SUSTAINED KNEE, BACK, SHOULDER, AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND LATER DEEMED DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10854642April 10, 2016
ELECTRONIC STABILITY CONTROL (ESC)
I WAS DRIVING ABOUT 15 MPH ON A CITY STREETAND THE VSC INDICATOR LIGHT CAME ON AND THE VEHICLE STARTED BREAKING ON ITS OWN. A LOUD SCRAPPING SOUND WAS HEARD. IT WAS ABOUT 70DEGREES AND SUNNY AND THE CAR THOUGHT I WAS GOING DOWN A SLIPPERY SLOPE. I STOPPED THE VEHICLE. EVERY TIME I GOT ABOVE 8-10 MPH THE LIGHT WOULD COME ON AND THE CARE WOULD START BREAKING BECOMING UNABLE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10852145March 29, 2016
ELECTRONIC STABILITY CONTROL (ESC)
IN FEB 2005 WHILE DOING ABOUT 30 MPH THE VSC LIGHT CAME ON AND STARTED BRAKING, ON IT'S OWN, TO THE RIGHT MAKING IT ALMOST IMPOSSIBLE TO DRIVE. THE NEXT MORNING THE CAR WAS TOWED TO THE TOYOTA DEALER. THE CAR DISPLAYED NO CODES AND THEY SAID THAT THEY HAD CALIBRATED THE STEERING ANGLE SENSOR. WE HAD NO FURTHER PROBLEMS UNTIL MAR 24, 2016. THIS TIME THE VSC INDICATOR CAME ON AT ABOUT 40 MPH. IF I SLOWED DOWN TO ABOUT 20 MPH THE INDICATOR WOULD GO OFF. WE WERE ABLE TO DRIVE THE CAR HOME BUT THE CAR BRAKED, ON IT'S OWN, SEVERAL TIMES. WE HAVE AN APPOINTMENT WITH THE TOYOTA DEALER. I'M AFRAID THAT THE EXPENSE TO REPAIR IT MAY COME CLOSE TO WHAT THE CAR IS WORTH. NHTSA NEEDS TO WAKE UP AND INVESTIGATE THIS ISSUE. IT'S BEEN GOING ON FOR A LONG TIME. THIS PROBLEM COULD RESULT IN A SERIOUS ACCIDENT IF IT OCCURRS AT HIGHWAY SPEEDS. I CAN'T IMAGINE WHAT WOULD HAPPEN IF THE CAR BRAKES ON IT'S OWN AT 75 MPH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821589January 21, 2016
AIR BAGS
CAR IN MOTION @45 MILES AN HOUR AT 8AM 12/29/14. DRIVER LOST CONSCIOUSNESS DUE TO MEDICAL EVENT, WHICH RESULTED IN AUTO RUNNING OFF ROAD AFTER HITTING CURB AND SIDEWALK, THEN HITTING A ROADSIDE FENCE AT AN ESTIMATED 45 MPH. THE CAR THEN ROLLED AND LANDED ON ROOF. DRIVER WAS SEAT-BELTED. NONE OF THE AIRBAGS DEPLOYED DURING THE COLLISION. DRIVER SUFFERED TRAUMA TO HEAD AND OTHER INJURIES. CAR WAS RATED BY INSURER AS COMPLETELY TOTALED.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
45
#10808336December 4, 2015
VISIBILITY/WIPER
HEAT DOESN'T WORK AND A/C INTERMITTENTLY BLOWS COLD OR HOT. WINDSHIELD AND WINDOWS WILL FOG UP IN BAD WEATHER AND WITHOUT HEAT I CAN'T DEFOG THEM FORCING ME TO PULL OVER AND MANUALLY WIPE THE FOG OFF EVERY FEW MINUTES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Highlander