Toyota Highlander Complaints

958 consumer complaints on file.

#11669130June 25, 2025
POWER TRAIN
I have a high pitched whine noise during acceleration from the transmission area. The noise gets louder with acceleration but goes away immediately when I take my foot off the gas pedal and starts again when you press the gas pedal again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669022June 24, 2025
STRUCTURE
The contact owns a 2022 Toyota Highlander. The contact stated while the vehicle was parked, the contact became aware that the mounting pad on the driver's side front bumper had detached and fallen off the vehicle. The dealer was made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668934June 24, 2025
POWER TRAIN
The transmission has gone out on my 2021 Highlander. It was inspected by the Toyota dealer. I was told by them that this is a known issue with these trucks. There are no warning lights but just a whine when driving the car and I believe it does put my safety as well as other at risk as this could go out at any moment.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668835June 24, 2025
POWER TRAIN
There is a known defect with transmissions in certain model years of Toyota cars, mine being one of them, per this TSB: [XXX] The transmission can catastrophically fail but Toyota will not replace the defective part unless the vehicle is still under warranty. I had the Toyota dealer verify that the transmission is beginning to fail and requires replacement. The transmission has begun to emit a "whining" noise. Should the transmission fail catastrophically during operation, it could cause a sudden loss of power, seize a drive wheel, or another event causing a loss of vehicle control. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667488June 17, 2025
POWER TRAIN
Whine noise when vehicle is in motion and accelerating. Took it to the dealer for inspection, and advise to replace the transmission
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666993June 15, 2025
POWER TRAIN
Transmission makes whine noise upon accelerating. Cannot be fixed except with new transmission. The longer you drive, the longer it affects and damages other parts. Mechanic was amazed that my relatively new Toyota needed over $10k in repairs. Toyota denying there’s a problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666931June 14, 2025
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, ENGINE
Yesterday, as I do a couple times a month, I went to switch parking places, putting my 2021 Toyota Highlander where my 2007 Mazda was parked, in order to drive it and keep the battery from dying. After starting both cars I first moved the Mazda to make room for the Toyota. As I was slowly steering the Toyota at (idle speed) into the now vacant parking spot, the car accelerated on it's own, prompting me to hit the brakes, but to no avail. The car jumped the curb hitting, knocking over and and damaging a large ceramic planter and small tree in my neighbor's yard. My split second reaction upon having no brakes and a run away car was to push it out of drive, which ended up putting the car into reverse, causing a harsh jolt, followed by the car accelerating again on it's own, in reverse towards another neighbor's garage. I live in a condo complex, so all of this took place within about 30 feet of forward/backward/forward motion. My second split second decision (with no brakes) to avoid smashing into the garage was throwing it back into drive, which sent it accelerating back towards the parking place again. This time I had the presence of mind to push the power button on the dash, allowing me to barely come to stop before jumping the curb again. Whole thing lasted about 15 seconds. I had an appointment to attend, so after a brief conversation explaining to my (now outside) neighbor what happened, I left in the older car. Returning later in the day I found damage to the front of my Toyota and wonder if my transmission is damaged as well. I'm reimbursing my neighbor today. I've not attempted to drive the Toyota since, and am seeking your advice on how best to proceed, whether I should initiate contact with Toyota regarding this incident, or is that something you should initiate? Please advise. Thank you.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11666776June 13, 2025
SERVICE BRAKES
Brakes "let go" for a second or so when using. I have noticed this when coming to a stop sign at low speeds and especially if road surface is uneven. It does not happen all the time but it is very scary to suddenly lose the brakes! This puts others at risk because the car briefly speeds up when the brakes let go. It has happened at least twenty times while driving this SUV, most recently today. Please issue a recall for this!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666644June 12, 2025
POWER TRAIN
The transmission has a whining, grinding noise and occasional jerks vehicle. I had dealership look at the vehicle and they said it's a problem with this model but Toyota has not done a recall they issued a service bulletin. I was told it needs replacement but Toyota has been reluctant to work with owners outside of the service manufacturers warranty. This proved true, I was denied any goodwill assistance, and after several days of requesting why they denied any assistance, I'm not able to get an answer. This is a safety issue that they are aware of and not taking proper acceptance and assistance in rectifying. We carry our new born and toddler grandchildren in this vehicle as well as elderly parents. The thought of a total transmission failure on a busy highway or street is terrifying, I asked the dealership service manager about the safety of driving the vehicle and he recommended not operating it until it's replaced. In my[XXX] I haven't asked the government for anything, but I am asking you to look into this matter and if called for mandate a recall.. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666627June 12, 2025
POWER TRAIN
The transmission is making a whining noise when accelerating. I took the vehicle to a Toyota dealership and they said the transmission needs to be replaced. And I asked why the Highlander only has 58 thousand miles on it. How is it already going out. And they couldn’t give me an answer
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666516June 12, 2025
SERVICE BRAKES
My 2021 Toyota Highlander Hybrid has a braking issue identified in Toyota Service Bulletin T-SB-0059-23, Hybrid Regenerative Brake Transition Feeling Improvement. When going downhill and applying the brake, the vehicle lurches forward temporarily as the braking system transitions from regenerative to hydraulic braking. The first time my vehicle did this, it was very alarming and I had to take additional measures to slow my vehicle as I was driving downhill. My vehicle frequently demonstrates this problem, however, I did not report it to my local Toyota dealer because I read in an online chat group that it was a characteristic of this vehicle. Although the TSB recommends a Reprogram of the Brake Actuator Assembly Control Module, the repair is only covered under the Toyota Basic Warranty which is in effect for 36 months or 36k miles, whichever occurs first. My vehicle is past the warranty limit, and because I did not report it to my dealer previously, this repair is not covered under the TSB or the Toyota Basic Warranty. Toyota Highlander Hybrid model years 2020-2022 are affected. The Technical Service Bulletin was issued August 29, 2023, so if a 2020 model Highlander Hybrid has this problem, 2020 models would have already passed the warranty limit by the time the TSB was issued and thus would not be covered. This is a safety risk as drivers can lose control of the vehicle when braking, particularly when going downhill. The Warranty should be extended, or this problem should be elevated to a RECALL so that older affected vehicles, or those with higher mileage can be covered under warranty. Drivers should not have to pay for a recognized problem that affects the safety of this vehicle and has been identified in a Technical Service Bulletin. This problem puts drivers at risk of losing control of the vehicle and the problem can be mediated with a software reprogram. T-SB-0059.23 should be elevated to a RECALL, or extended regardless of age or mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666261June 11, 2025
POWER TRAIN
My transmission started whining at 63,000 miles and my mechanic said it needs to be replaced. However, there is a nationwide backorder on Toyota transmissions. That should be a sign to NHTSA that this is a widespread issue and needs a recall! Of course this was right after the 60,000 mile Toyota warranty. I have extended warranty but it doesn't cover consultations or taxes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665662June 8, 2025
POWER TRAIN
I have a 2021 Toyota highlander platinum. The car makes whining noise when accelerating my car has 70k miles and according to Toyota my warranty expired at 60k miles it’s a common issue with these cars and Toyota knows that but they won’t help with the fix. This affected a lot of people and they want almost 11k for a trans replacement. If it’s a common issue with all their cars then they should take full responsibility and fix the cars. I hope you guys could be of help and hold they accountable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665294June 6, 2025
POWER TRAIN
Transmission failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665077June 5, 2025
UNKNOWN OR OTHER
My 2021 Toyota Highlander, purchased with 16k miles, has a leak in the AC system in the rear of the vehicle (as of May 2025, at 3 years 10 months into the vehicle's service, with 28k miles). This pipe runs the length of the car and costs $2000-$3000 to repair. This was confirmed at an independent service center that used leak detection dye to identify the problem. I am finding multiple reports of people having this problem in young Toyota vehicles (<4 years old) and with low miles. I believe this is a design flaw and not indicative of normal corrosion, as the vehicle does not exhibit corrosion elsewhere in the under carriage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664890June 4, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER, VISIBILITY/WIPER
This is a supplemental complaint to add more detail to a prior submission. I am the original owner of a 2021 Toyota Highlander with 10,000 miles at the time of the issue worsening to the point that I finally broke down and was forced to pay the Toyota dealership's hefty diagnostic fee. The air conditioning system has failed due to a refrigerant leak in the rear A/C lines, specifically near the exhaust area under the vehicle. The dealership diagnosed the issue and quoted me over $3,000 to replace “all necessary components in the rear.” They offered no coverage or goodwill repair despite the vehicle’s age and mileage. Upon researching the issue for longer than a year at this point, I discovered far too many similar complaints from other Highlander owners (years 2019–2021) describing identical failures — typically rear A/C lines corroding, cracking, or leaking prematurely. In some cases, customers were told Toyota is aware of the issue but not issuing a TSB or recall. In other cases, dealers said no permanent fix exists. These repairs are prohibitively expensive and, in some reports, recurring due to poor line placement or dissimilar metal corrosion near heat sources. This significantly impacts safety in several ways: Impaired Visibility: The AC system is integral to effective defogging and defrosting of the windshield, especially in humid or cold conditions. Without it, visibility is severely compromised, increasing the risk of an accident. Driver Impairment: In extreme temperatures, lack of climate control can lead to driver fatigue, distraction, and reduced concentration, posing an indirect safety risk. I am reporting it to request NHTSA monitor the trend. This seems to reflect a possible engineering or design flaw, and the number of similar owner reports suggests it may warrant further review by Toyota and NHTSA. Customers should not be facing multi-thousand-dollar repairs on near-new vehicles with basic systems failing. Thank you for tracking this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664841June 4, 2025
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Premature AC refrigerant leak and failure in system in the 2021 Toyota Highlander due to corroded/defective rear AC lines located near the exhaust/spare tire, observed at very low mileage and upon official inspection at the nearest Toyota dealership. Noticed early in ownership and decided to have the vehicle scanned when air being released only continued to grow warmer in the sweltering summer months. Reporting due to advice from friends and owners in my exact situation with the very same issue as well as the pricey three-thousand dollars and upwards quote to have this work done from Curry Toyota, 3026 E Main St, Cortlandt, NY 10567. Vehicle purchased new to avoid these very issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664736June 3, 2025
ENGINE
I am seeing a transmission slip and also engine whining noise. There is a widely known issue with this transmission failing. My serial number A3A20M01780 falls right outside the scope of the TSB issued by Toyota for these transmissions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664579June 3, 2025
POWER TRAIN
Experiencing erratic transmission shifts and jerking. Intermittent in nature.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664219June 1, 2025
POWER TRAIN
My transmission is failing in my 2021 Toyota Highlander. Has started making the high pitched whining noise. Fix is to replace the whole transmission. Dealer has confirmed and does have the transmission on order.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Highlander