MY 99 ESTEEM STARED PULLING TO ONE SIDE WHILE DRIVING. AS I ATTEMPTED TO GET IT HOME THE WHEEL WOULD RUB ON THE INNER FENDER WELL WHEN TURNING. UPON INSPECTION WHEN I GOT HOME I FOUND THE DRIVER SIDE SUBFRAME RUSTED THROUGH ON TOP AND OUTER SIDES WITH ONLY THE INSIDE PORTION INTACT. THIS PART HAD BENT ALLOWING MY WHEEL TO CHANGE POSITION. THE REST OF THE UNDERCARRIAGE SEEMS TO BE IN GOOD SHAPE WHILE THIS SECTION HAS RUSTED AWAY. THANKFULLY, THIS DID NOT HAPPEN AT HIGHWAY SPEED OR THAT I DID NOT HIT A POTHOLE WHILE DRIVING. THIS COULD HAVE BROKEN AND CAUSED TOTAL LOSS OF CONTROL, ENDING IN INJURIES AND/OR FATALITIES NOT ONLY TO THE OCCUPANTS OF MY VEHICLE BUT TO OTHER CARS IN MY VICINITY. I UNDERSTAND THAT THIS IS NOT UNCOMMON ON THIS VEHICLE AN SINCERELY BELIEVE THAT THIS IS AN ISSUE THAT MERITS IMMEDIATE ATTENTION BEFORE PEOPLE ARE KILLED. *TR *KB
No injuries · No fire · No crash
SUB FRAME OF 1999 SUZUKI ESTEEM HAD RUSTED THRU .I WAS DRIVING AT 70 MILES PER HOUR WHEN THE SUB FRAME CRACKED AND PUSHED THE PASSENGER FRONT TIRE BACK AGAINST THE FENDER CAUSED THE FRONT TIRE TO LOCK UP WHICH CAUSED ME TO WRECK. I SPOKE WITH SUZUKI AND GAVE THEM MY VIN NUMBER AND WAS TOLD THAT PART WAS ON RECALL AND TO HAVE MY CAR TOWED IN AND THEY WOULD FIX THAT PART. TWO DAYS LATER I WAS CALLED AND TOLD THAT THE RECALL HAD EXPIRED 3 MONTHS EARLIER. I WAS NEVER NOTIFIED AND WAS ALSO WONDERING HOW A RECALL ON A SAFETY ISSUE COULD EXPIRE. I HAVE SEEN HUNDREDS OF COMPLAINTS ON FORUMS ABOUT THE SAME ISSUE AND IT IS ALWAYS THE PASSENGER SIDE. *KB
THE OUTSIDE PLASTIC DOOR HANDLES BREAK INSIDE THE DOOR WHEN OPENING THE DOOR. THEN TO ENTER THE CAR ANOTHER DOOR MUST BE USED. THESE HANDLES ARE VERY WEAK, AND SHOULD BE RECALLED. I HAVE REPLACED FOUR ON THE DRIVERSIDE FRONT DOOR, TWO ON THE PASSENGERS SIDE FRONT DOOR, AND ONE ON THE PASSENGERS SIDE REAR DOOR. *TR
No injuries · No fire · No crash
FRONT SUSPENSION CROSSMEMBER CORROSION OF 1999 SUZUKI ESTEEM GLX WAGON I HAVE THIS VEHICLE AND RUNNING OK FOR 5 YEARS. WHEN I DID MY ANNUAL CHECK UP THIS WEEKEND, IT WAS FOUND OUT THAT THE FRONT SUSPENSION CROSSMEMBER HAS BEEN RUST-THROUGH AND FORMED A CRACK IN THE AREA OF THE RIGHT FRONT LOWER CONTROL ARM ATTACHMENT BRACKETS. BY VISUAL INSPECTION, THIS MEMBER IS HIGHLY CORRODED COMPARED WITH OTHER PARTS ON THE BOTTOM OF THE VEHICLE. THE MECHANIC DID MY INSPECTION WAS SURPRISED THAT I WAS STILL DRIVING THIS VEHICLE BECAUSE IF I HIT A POTHOLE ON THE ROAD AND THIS SUSPENSION CROSSMEMBER COULD EASILY BREAK AND WOULD LOOSE CONTROL OF THE CAR AND I COULD BE KILLED. I DID A LITTLE SEARCH ONLINE AND FOUND OUT THIS IS A COMMON PROBLEM IN SIMILAR MODELS OF SUZUKI VEHICLES. HOWEVER, THERE HAS BEEN NO RECALLS ON THIS ISSUE. I THINK THIS IS A VERY SERIES ISSUE AND COULD CAUSE SERIES INJURIES AND FATALITIES NOT ONLY OF THE DRIVER OF THE VEHICLE BUT OTHER DRIVERS ON THE ROAD AS WELL. I WOULD NOT HAVE FOUND OUT OF THIS ISSUE IF I HADN'T DONE THE ANNUAL CHECK UP. A SIMILAR CORROSION PROBLEM WAS ALSO FOUND IN THE 1999-2004 CHEVROLET TRACKER AND GM INITIATED A RECALL ON THIS. I WILL TOW MY CAR TO THE DEALER TO FIX IT BUT I FEEL I SHOULD FILE A COMPLAINT TO LET OTHER OWNER KNOW THIS PROBLEM AND HOPEFULLY SAVE SOME LIVES. THANK YOU. WEI TU *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 1999 SUZUKI ESTEEM. WHILE DRIVING AT 55 MPH IN DRY CONDITIONS THE VEHICLE BEGAN TO PULL TO THE RIGHT AND PRODUCED A RUBBING NOISE. THE CONTACT STATED THAT UPON ARRIVING AT THE MECHANIC SHOP THE FRONT PASSENGER SIDE WHEEL COLLAPSED. THE MECHANIC INSPECTED THE VEHICLE AND DIAGNOSED THAT A POSSIBLE CAUSE OF FAILURE WAS THE AIR CONDITIONER LEAKING AND MAY HAVE RUSTED THROUGH THE VEHICLE'S FRAME. THE CURRENT AND FAILURE MILEAGE WERE 130,000.*AK THE CONSUMER HAS INCLUDED PICTURES OF THE FRAME DAMAGES. UPDATE 5/3/07 *TR
No injuries · No fire · No crash