smart Fortwo Complaints (2008)

177 consumer complaints on file.

#11758392August 20, 2026
ELECTRICAL SYSTEM, POWER TRAIN
I was entering an intersection and missed judged the traffic light and was a bit to far forward, so I tried to reverse but the car would not shift to reverse. I have had an actuator replaced but the problem still happens intermittently where it will not shift to reverse. I have logged into smart car forums online and it seems to be an ongoing problem with many smart cars. I have not had the manufacturer look at it yet. Many on the forum said in some cases it is a software issue. But it is dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661330May 15, 2025
FUEL/PROPULSION SYSTEM
The 90 degree fittings(integral to the fuel pump) on top of the fuel pump cracked and leaks gasoline leading to a potential fire that could cause bodily injury for the driver and passenger. It is noticeable because of strong gasoline smell inside and outside of the car. There are many of the same complaints from Smart Car drivers in various forum.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616352September 25, 2024
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
The contact owns a 2008 Smart Fortwo. The contact received notification of NHTSA Campaign Number: 18V273000(Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the contact noticed there was smoke coming from the engine. The contact stated that the vehicle had caught on fire. No warning lights illuminated. The contact exited the vehicle quickly and entered a mechanic shop and a mechanic put on safety gloves to extinguish the fire with a fire hose. The fire was able to be extinguished by the mechanic. The mechanic mentioned that the insulation mat detached from the vehicle and caught on fire. No injuries were sustained. A fire report was not filed since the fire department was not at the scene. A Police report was not filed. The vehicle was towed to the contact's parents' home where it remained. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000. Parts Distribution Disconnect
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11613305September 8, 2024
ENGINE
Mercedes-Benz USA has no service centers on Long Island,NY that might fix the recall issue. For a time they were the only Smart Car service provider after Smart Car dealers were abandoned. MB USA currently will not do the recall and offers no reasonable alternative. The issue is potential engine compartment/total vehicle fire due to compartment insulation failure. Offers no suggestions for doing the recall service except one MB dealer in CT at one time might be able; if I research them.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612995September 6, 2024
ENGINE AND ENGINE COOLING
The contact's mother owns a 2008 Smart ForTwo. The contact received notification of NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling). The local dealer was notified of the recall but informed the contact that the recall could not be serviced at their location. The manufacturer was notified of the failure and referred the contact to a dealer that was 180 miles away. The manufacturer was informed that the owner of the vehicle was elderly and would not be able to travel that far a distance yet was offered no additional assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11611786August 30, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2008 Smart ForTwo. The contact received notification of NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer suggested that the vehicle be towed to another local dealer. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592424June 4, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2008 Mercedes-Benz Smart ForTwo. The contact received a notification of NHTSA Campaign Number: 18V273000 (Engine and Engine Cooling). The parts were available; however, the dealer list the manufacturer provided that the recall repair instructions were not available. The contact called multiple dealers however services could not be provided. The vehicle was not repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484742September 15, 2022
ENGINE, ELECTRICAL SYSTEM, SERVICE BRAKES
We were driving in Greensboro NC this afternoon on the way to my husbands birthday dinner when off of Bridford? Parkway our 2008 smart car passion for two started malfunctioning all lights flashing on instrument panel & brakes quit & another motorist drove up beside us with window down screaming GET OUT YOUR CAR IS ON FIRE!!! We managed to stop on side of road at woods & jumped out car was on fire looked like under back tires and engine in back! We grabbed what we could save & ran. 911 was called & fire and police came. 2 Witnesses also to event we have photos & videos. Our car burned all the way down to frame! Total loss! We could have died because we couldnt see the fire behind us under car & if not for the man we may have blown up!!
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11443181December 9, 2021
STEERING
2008 Smart Fortwo Pure, currently with 85,036 miles, factory equipped with optional POWER STEERING - ELECTRIC, power steering had worked fine until Fall 2020 when cold temperatures caused steering lock-up, until car interior warmed enough to unlock steering, behavior consistent throughout that winter. Once steering unlocked, steering was normal, until car sat & chilled sufficiently to re-lock steering, or fault disappeared with warmer Spring 2021 temperatures. NEW DEVELOPMENTS - December 2021, outside temperatures in the 20s F, it takes much longer, 30-60 minutes or longer with heat & blower on max heat, before steering unlocks. After steering unlocks, it can seem fully unlocked, BUT AT HIGHWAY SPEEDS AND FRIGID TEMPERATURES STEERING NOW GETS DANGEROUSLY STIFF AND STICKY AND STUCK-IN-POSITION MOMENTARILY WHILE DRIVING. Unlike some vehicles with steering lockable by key position for theft deterrence, THERE IS NO STEERING-LOCK-BASED ANTI-THEFT FEATURE ON THE FORTWO. I hope you’ll agree that any vehicle whose steering may lock-up in operation at highway speeds as a function of U.S. midwestern winter temperatures has a life-threatening steering safety defect worthy of further investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436171October 9, 2021
ENGINE, UNKNOWN OR OTHER
Engine fire destroyed vehicle while driving on Interstate at 65 MPH. Vehicle was serviced and maintained per manufacturer maintenance schedule at authorized dealer. No prior issues with vehicle. Vehicle also passed emission check on 09/29/2021 with no OBD error codes reported during inspection. Mileage: 60K
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11433011September 15, 2021
ENGINE
I am seeing melted and possible burnt material on the underside of the engine compartment cover and I am concerned for a fire to develop.. i have photos i will send
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422583June 28, 2021
ENGINE AND ENGINE COOLING
The contact owns a 2008 Mercedes-Benz Smart ForTwo. The contact stated while parking the vehicle, there was smoke coming from the engine compartment. The vehicle was on fire under the hood. The fire department was called to the scene and the fire was extinguished. A fire report was filed. The vehicle was not towed. There was no injury sustained. There was no warning light illuminated. Upon investigation, the contact associated the failure with NHTSA campaign number: 18V273000 (Engine and Engine Cooling). The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11397699February 24, 2021
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
CAN NOT TURN IGNITION KEY TO START THE CAR. CAR WAS PARKED IN A PARKING LOT. AFTER SEVERAL HOURS HAD TO PRY UP CONSOLE TO SWITCH THE THE YELLOW UP. THEN HAD TO PUT GEAR IN NEUTRAL. PUT OIL IN GEAR SHAFT AREA. PLUS BLOW OUT ANY DEBRIS THAT MIGHT HAVE FALLEN IN KEY HOLE. ALSO PUT LUBRICANT IN KEY SHAFT. WITH SEVERAL ATTEMPTS THE KEY FINALLY TURNED OVER. AFTER BEING STRANDED FOR FOUR HOURS IN 0 DEGREE WEATHER. MY VEHICLE REMAINS IN A PARKING LOT. HAVE NO IDEA WHERE TO TAKE THIS VEHICLE DUE TO NO DEALERS WORK ON A SMART CAR. HAVE NO IDEA WHAT OR HOW TO FIX THIS PROBLEM. THIS FAULTY MECHANISM NEEDS TO BE RECALLED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11372369October 30, 2020
ENGINE
WAS DRIVING AT 35 MPH AT NIGHT, LIGHTS FLASHED ON/OFF, HER A THUMP AND POP, CAR AND LIGHTS SHUT OFF, THEN A LARGE FIRE ERUPTED IN ENGINE COMPARTMENT. VEHICLE WAS TOTALLY DESTROYED.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11364972October 20, 2020
STRUCTURE
2008 SMART FOR TWO PASSION. CONSUMER WRITES IN REGARDS TO REAR INSULATION MAT SAFETY RECALL. *LD *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11361517September 28, 2020
ENGINE
THIS CONCERNS NHTSA RECALL #18V273. I BOUGHT THIS CAR NEW AT A DEALER 30 MILES FROM MY HOME. SMART HAS LEFT THE US MARKET AND THEIR WEBSITE SHOWS THE CLOSEST DEALER IS 220 MILES AWAY (ONE DIRECTION). THEIR WEBSITE SAYS THAT AUTHORIZED MERCEDES-BENZ DEALERS CAN PERFORM THE RECALL WORK. I TRIED MY LOCAL MERCEDES-BENZ AND THEY REFERRED ME TO A DEALER THAT IS OVER 100 MILES AWAY (ONE WAY). DOESN'T THE MANUFACTURER HAVE A RESPONSIBILITY TO PERFORM THE RECALL IN A REASONABLE MANNER? I BOUGHT THE CAR FROM A LOCAL DEALER, NOW IT WILL TAKE ME DOING A 200 MILE TRIP TO GET THIS RECALL DONE. SHOULDN'T THE MANUFACTURER BE REQUIRED TO ARRANGE FOR A LOCAL SERVICE CENTER TO DO THIS RECALL?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11339750July 16, 2020
ENGINE
WHILE DRIVING ON THE HIGHWAY AND WE NOTICED SUDDEN SMOKE WITHIN THE CAR. THE CAR GOT VERY HOT. WE STOPPED AND OPENED THE ENGINE COMPARTMENT IN THE TRUNK AND NOTICED THAT THE INSULATION MAT IN THE ENGINE COMPARTMENT WAS ON FIRE. WE DID NOT NOTICE ANY CAUSES THAT COULD HAVE LEAD TO THE BURN BESIDES THE MAT ITSELF.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11338562July 10, 2020
STEERING
TL* THE CONTACT OWNS A 2008 MERCEDES-BENZ SMART FORTWO. THE CONTACT STATED THAT WHILE DRIVING AND MAKING A TURN, THE VEHICLE LOSS POWER ASSIST WITHOUT WARNING. THE VEHICLE WAS TAKEN TO NEW COUNTRY MERCEDES-BENZ LOCATED AT 1 WESTON ST, HARTFORD, CT 06120, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 72,250.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11330324June 23, 2020
STEERING
POWER STEERING FAILS WHILE DRIVING AND BECOMES LIKE STEERING A MAC TRUCK EXTREMELY DIFFICULT TO TURN THE WHEEL FORCING THE VEHICLE TO GO STRAIGHT INSTEAD OF TURNING CAUSING THE CAR TO COME INTO ONCOMING TRAFFIC. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11330375June 23, 2020
ENGINE
RECALL CAMPAIGN NUMBER 2018060010. I LIVE IN BOISE, IDAHO. THE CLOSEST DEALER THAT CAN DO THE RECALL WORK IS IN DRAPER UTAH. THE DEALER WANTS ME TO DRIVE THE CAR TO UTAH TO HAVE THE RECALL DONE. DOESN'T SEEM LIKE A SAFE IDEA FOR ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to smart Fortwo