UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the steering wheel to the right to make a right turn, the steering was significantly wobbly. The contact related the failure to NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V153000 (Steering). Additionally, the contact stated that the vehicle was experiencing a fuel leak. The vehicle was taken to the Subaru dealer, where it was purchased. The vehicle was not diagnosed or repaired. An unknown Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. The manufacturer was notified of the failure and informed the contact that unknown recalls were previously performed on the vehicle. The failure mileage was approximately 85,200.
No injuries · No fire · No crash
Airbags
No injuries · No fire · No crash
The contact owns a 2006 Saturn Ion. The contact stated that while driving at an undisclosed speed, the vehicle stalled. Additionally, the key was stuck in the ignition switch. The vehicle was taken to the dealer, who informed the contact that the ignition lock cylinder needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer; however, the parts to do the repair were not available. The manufacturer was made aware of the failure. The failure mileage was approximately 100,764.
No injuries · No fire · No crash
The contact owns a 2006 Saturn Ion. The contact stated while exiting a driveway and making a turn, the steering wheel became difficult to turn. There was no warning light illuminated. The contact checked the power steering fluid reservoir and there was power steering fluid in the reservoir. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 90,000.
No injuries · No fire · No crash
The contact's mother owns a 2006 Saturn Ion. The contact stated that after driving the vehicle to his residence and parking the vehicle in the garage, he observed that a puddle of gasoline had accumulated overnight underneath the vehicle from the fuel tank by the driver's side rear wheel. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The contact stated that the failure might be related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer had been informed of the failure. The failure mileage was approximately 84,000.
No injuries · No fire · No crash