Ram 3500 Service Bulletins
2,690 manufacturer communications on file.
- April 22, 2016•Document ID: 10224663Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- 0805016
- Date Added:
- October 24, 2022
- Manufacturer:
- RAM
SummaryHeadlamps May Be Out Of Adjustment Or Alignment
Associated Products (4)Associated Documents - April 22, 2016•Document ID: 10224659Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 0804616
- Date Added:
- October 24, 2022
- Manufacturer:
- RAM
SummaryThis Bulletin involves updating the (ASCM) software.
Associated Products (6)Associated Documents - April 22, 2016•Document ID: 10139963Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- 08-050-16
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryHeadlamps May Be Out Of Adjustment Or Alignment This bulletin involves adjusting the headlamps to specified alignment. The customer may describe that the headlamps are out of alignment or oncoming vehicles are flashing their bright lights at them.
Associated Products (4)Associated Documents - April 22, 2016•Document ID: 10139959Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- 08-046-16
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryFlash: Air Suspension Control Module (ASCM) System Enhancements This Bulletin involves updating the (ASCM) software. A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message Battery Voltage Low - Start Engine to Change Ride Height which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.
Associated Products (6)Associated Documents - April 22, 2016•Document ID: 10076507Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- 08-050-16
- Date Added:
- July 14, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Headlamps May Be Out Of Adjustment Or Alignment. OVERVIEW: This bulletin involves adjusting the headlamps to specified alignment. SYMPTOM/CONDITION: The customer may describe that the headlamps are out of alignment or oncoming vehicles are flashing their bright lights at them.
Associated Products (4)Associated Documents - April 22, 2016•Document ID: 10076503Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
- Mfr Comm. #:
- 08-046-16
- Date Added:
- July 14, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements SYMPTOM/CONDITION: A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message Battery Voltage Low - Start Engine to Change Ride Height which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.
Associated Products (6)Associated Documents - April 22, 2016•Document ID: 10076286Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- 08-050-16
- Date Added:
- July 7, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Headlamps May Be Out Of Adjustment Or Alignment. OVERVIEW: This bulletin involves adjusting the headlamps to specified alignment. SYMPTOM/CONDITION: The customer may describe that the headlamps are out of alignment or oncoming vehicles are flashing their bright lights at them.
Associated Products (3)Associated Documents - April 22, 2016•Document ID: 10076282Service Bulletin/Repair InstructionsSUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 08-046-16
- Date Added:
- July 7, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements OVERVIEW: This Bulletin involves updating the (ASCM) software. SYMPTOM/CONDITION: A customer may describe the following: **Cluster stays awake after ignition is turned off for 10 minutes or more.** False message Battery Voltage Low - Start Engine to Change Ride Height which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and trying to move the suspension from trailer ride height to normal ride height.
Associated Products (6)Associated Documents - April 20, 2016•Document ID: 10224657Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 0804416
- Date Added:
- October 24, 2022
- Manufacturer:
- RAM
SummaryFlash: Radio Frequency Hub Module (RFHM) Enhancement
Associated Products (5)Associated Documents - April 20, 2016•Document ID: 10139957Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 08-044-16
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryFlash: Radio Frequency Hub Module (RFHM) Enhancement This bulletin involves updating the RFHM software. Customers may describe the instrument cluster is illuminating by itself after the ignition has been off for an extended period of time (10 minutes or more).
Associated Products (5)Associated Documents - April 20, 2016•Document ID: 10139956Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:CRUISE CONTROL
- Mfr Comm. #:
- 68277402A
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryAdaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage can occur from mud, ice, snow, front end damage, bracket damage, the sensor not attached to the bracket properly or an aftermarket fascia installed. This fault can occur intermittently in muddy or icy/snowy conditions and is considered normal operation. Under some circumstances, a misaligned sensor can also cause the C1266 DTC, please complete an alignment procedure. No replacement is required.~ 2) If you are replacing this part due to the cluster displaying ?ACC/FCW Unavailable Service Required?, please check the DTC fault codes. This will indicate which module needs to be serviced (TCM, PCM, ESP/ABS, etc). This fault is not due to the ACC Sensor. No sensor replacement is required.~ 3) If you have fault code DTC C125E ACC Sensor Adjustment Required, please verify that the radar sensor is fully seated in the clips and there is no damage (if clips are damaged on a 2013 or earlier vehicle, order P/N 68085813A$, otherwise please replace the module), please verify there is no blockage to the sensor due to mud, ice, snow, front end damage, bracket damage or the sensor not attached to the bracket properly. Perform the Vertical Alignment and the Electronic Horizontal Alignments procedure as stated in the service manual. Please note, if the horizontal alignment procedure will not complete, check the vertical alignment and confirm that the sensor is seated properly. Rerun the horizontal alignment procedure. No sensor replacement is required. **Hints for running Horizontal Alignment procedure: A) Verify speed is between 45 and 75 mph, B) verify the road is relatively straight with signs, poles, guard rails, etc C) Do not tail a vehicle too closely this inhibits the learning procedure
Associated Products (127)2016 Chrysler 2002016 Chrysler 3002016 Chrysler 300C2016 Chrysler Pacifica2016 Chrysler Town and Country2016 Dodge Avenger2016 Dodge Challenger2016 Dodge Charger2016 Dodge Dart2016 Dodge Durango2016 Dodge Grand Caravan2016 Dodge Journey2016 Dodge Viper2016 Fiat 5002016 Fiat 500e2016 Fiat 500L2016 Fiat 500X2016 Jeep Cherokee2016 Jeep Compass2016 Jeep Grand Cherokee+ 107 moreAssociated Documents - April 20, 2016•Document ID: 10076501Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 08-044-16
- Date Added:
- July 14, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Flash: Radio Frequency Hub Module (RFHM) Enhancement SYMPTOM/CONDITION: Customers may describe the instrument cluster is illuminating by itself after the ignition has been off for an extended period of time (10 minutes or more).
Associated Products (5)Associated Documents - April 20, 2016•Document ID: 10076280Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- 08-044-16
- Date Added:
- July 7, 2016
- Manufacturer:
- RAM
SummarySUBJECT: Flash: Radio Frequency Hub Module (RFHM) Enhancement SYMPTOM/CONDITION: Customers may describe the instrument cluster is illuminating by itself after the ignition has been off for an extended period of time (10 minutes or more).
Associated Products (4)Associated Documents - April 19, 2016•Document ID: 10219712Service Bulletin/Repair InstructionsSTRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- 2301716
- Date Added:
- September 15, 2022
- Manufacturer:
- RAM
SummaryThe customer may describe scratches on the driver?s side of roof.
Associated Products (2)Associated Documents - April 19, 2016•Document ID: 10219694Service Bulletin/Repair InstructionsSTRUCTURE:BODY:BUMPERS
- Mfr Comm. #:
- 2300116REVD
- Date Added:
- September 15, 2022
- Manufacturer:
- RAM
SummaryThis bulletin involves adding a rubber bumper to the console lid to prevent the lid from binding.
Associated Products (8)Associated Documents - April 19, 2016•Document ID: 10209583Service Bulletin/Repair InstructionsSTRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- 23-017-16
- Date Added:
- April 4, 2022
- Manufacturer:
- RAM
SummaryThe customer may describe scratches on the driver?s side of roof.
Associated Products (2)Associated Documents - April 19, 2016•Document ID: 10209545Service Bulletin/Repair InstructionsBACK OVER PREVENTION; EQUIPMENT
- Mfr Comm. #:
- 23-001-16 REV. D
- Date Added:
- April 4, 2022
- Manufacturer:
- RAM
SummaryThis bulletin involves adding a rubber bumper to the console lid to prevent the lid from binding.
Associated Products (8)Associated Documents - April 19, 2016•Document ID: 10224672Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 2300116REVD
- Date Added:
- October 24, 2022
- Manufacturer:
- RAM
SummaryCenter Console Lid Binding
Associated Products (9)Associated Documents - April 19, 2016•Document ID: 10139972Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- 23-017-16
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryRoof Damage Repair This bulletin involves identifying and repairing scratches in the paint on left side of roof. The customer may describe scratches on the driver?s side of roof.
Associated Products (2)Associated Documents - April 19, 2016•Document ID: 10139971Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 23-001-16 REV. D
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryCenter Console Lid Binding This bulletin involves adding a rubber bumper to the console lid to prevent the lid from binding. The customer may describe a binding or audible clicking condition when the center console lid is being opened or closed.
Associated Products (10)Associated Documents