Porsche Cayenne Complaints (2005)

46 consumer complaints on file.

#11695787October 27, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Porsche Cayenne. The contact stated that fuel was leaking from the vehicle. There was an abnormal fuel odor. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline). The contact replaced the fuel filter and repaired the vehicle. The contact called the local dealer and was informed that parts were on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 157,290.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603601July 21, 2024
UNKNOWN OR OTHER
headlamp wiring and turn signal failures. Big hazard!! Why is in the headlight assembly including the headlight wire harness is corroding due to the heat this is a common issue that I see that’s online. Everyone is having the same issue with the same type of vehicle this needs attention immediately and recalled before the media gets wind of this. The group chats that I am in is starting to do a petition because this was reported to you guys numerous amount of times as I can see in our group chats so please call this recall because it is a safety hazard to the roads. Headlights are going off as we’re driving due to that Issue please give me a email at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601645July 13, 2024
POWER TRAIN, SUSPENSION, FORWARD COLLISION AVOIDANCE: WARNINGS
The transmission has quite a bit of slop or play when placing it in park. I do not believe it could be parked safely in a residential driveway. Tranny knocks a little in low gears.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11497792December 16, 2022
FUEL/PROPULSION SYSTEM
We purchased the 2005 Porsche Cayenne from my brother-in-law in August of 2022. He had owned the vehicle for at least a year before I purchased it from him. Shortly after the purchase, I noticed the engine light came on. On 09/12/22 a strong smell of fuel was emitting from the vehicle in a Walmart parking lot in Denton, Texas at approximately 1030pm. I noticed a large puddle of gasoline on the ground under the vehicle and it was steady stream of fuel while the vehicle was running. The vehicle was completely unsafe to drive for fear of ignition and fire. Due to the time and location, I had the vehicle towed to my mechanic approximately 3 miles away for diagnosis and/or repair. The closest Porsche dealership was approximately 25 miles away and the tow bill would have been excessive. Mechanic identified the problem as a cracked fuel filter flange/housing that sat on top of the fuel pump. The cracked fuel housing was replaced and the total for parts and labor was $462.48. No leaking fuel since repair. A few weeks later my brother-in -law contacted me and advised he had just received a recall (OCTOBER 2022) in the mail from Porsche for the exact part I had repaired (17V-576 / AH10). He mailed me the recall and I contacted Porsche for a reimbursement. They stated they only refund for repairs done at a Porsche dealership. I believe Porsche should cover the repair cost for their faulty equipment even after the recall was received. A Porsche Service Center would charge Porsche Corporate much more for this repair than what I paid. Please assist me in getting a refund for my expense of ($462.48) for the repair of Porsche's recall. Thanks [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11491876November 2, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Porsche Cayenne. The contact stated that while refueling the vehicle with the engine running, the vehicle shut off. The vehicle hesitated while restarting. The contact detected fuel leaking from the vehicle. The check engine and oil light warning lights were illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11488239October 6, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Porsche Cayenne. The contact received notification of the NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline) however, the contact stated that while driving, he smelled a fuel odor throughout the vehicle. The contact stated that he started to feel dizzy and pulled the vehicle off the roadway. The contact then stated that upon inspecting the vehicle, he noticed that fuel had leaked under the hood of the vehicle onto the ground. The vehicle was driven to the destination. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed to have the vehicle towed to the dealer. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11302892January 29, 2020
FUEL/PROPULSION SYSTEM
PORSCHE RECALLED THIS FUEL PUMP (17V-576) AFTER I REPLACED FOR THE SAME REASON IT WAS RECALLED. I'VE CONTACTED PORSCHE SEVERAL TIMES AND THEY STILL HAVE NOT ADDRESSED REPLACING THE FUEL PUMP FILTER FLANGE. IT'S BEEN MORE THAN 2 YEARS NOW? WHAT CAN I DO?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11267395October 9, 2019
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT ALL FOUR DOOR LATCHES FAILED TO OPEN FROM OUTSIDE AND INSIDE THE VEHICLE. THE CONTACT CALLED PORSCHE ORLANDO (9590 US-17, MAITLAND, FL 32751, (407) 680-0785) AND WAS INFORMED THAT THERE WOULD BE A FEE TO REPAIR EACH DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: 5557958. THE APPROXIMATE FAILURE MILEAGE WAS 162,160.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11210362May 28, 2019
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
GOOGLE: CAYENNE WET FLOOR. ALL CAYENNE HAVE ISSUE WITH POOR WATER DRAINAGE SYSTEM ACCORDING TO THE WEBSITES. MY CAR WAS DRIVING FINE BEFORE I PARKED IT, THEN WHEN I TRY TO START IT, I GOT AN ERROR ON THE INFO DISPLAY IN RED: IGNITION LOCK FAULT, ABS BRAKE PROPORTIONING. NO CRANK FROM THE BATTERY, TRANSMISSION LOCKED IN PARK. SO I GOOGLED IT AND FOUND MANY OWNERS FROM AROUND THE WORLD REPORTING THIS ISSUE. THE DRAINAGE UNDER THE WINDSHIELD CAN GET BLOCKED EASILY WITH DEBRIS, AND CAUSE WATER TO OVERFLOW INSIDE THE CABIN AND OR ELECTRICAL MODULES LOCATED IN THE WINDSHIELD COWL AREA. ON THE DRIVER SIDE AS PER VIDEO, I REMOVED THE RUBBER CARPET AND FORCED LIFTED THE PERMANENT CARPET, AND FOUND POOL OF WATER UNDERNEATH, ON THE METAL FLOOR WAS A BUNCH OF WIRES CONNECTING TO THE CAR BATTERY UNDER THE DRIVER SEAT WERE ALL UNDER WATER. I STARTED EMPTYING BUT MORE WATER KEPT COMING, FOAMS, RUBBERS WERE ALL SOAKED. ACCORDING TO THE FORUMS AFTER REMOVING ALL WATER, I NEEDED TO LOCATE 3 SET OF WIRES AMONGST THE BUNCH, THESE 3 ARE JOINED BY TWISTING AND WRAPPED WITH ELECTRICAL TAPE/GAUGE FROM THE FACTORY. THESE WIRES SINCE EXPOSED ARE SUSCEPTIBLE TO CORROSION. 1 SET OF WIRE COMPLETELY SNAPPED, APPARENTLY 1 WIRE IS FOR ABS BRAKE, AND THE OTHER IS FOR IGNITION KEY LOCK THAT RENDERS THE CAR IMMOBILIZED. I FOLLOWED THE VIDEO DESCRIBING THE STEPS TO FIX THIS ISSUE MYSELF, AND BIG BOLD LETTERS ON VIDEOS TO DO NOT BRING THE CAR TO THE DEALER AS THEY WILL CHARGE THOUSANDS, IF MODULES NEED REPLACING, RUST AN OWNER RECORDED A VIDEO ONLINE OF HIS CAYENNE DASH STOP WORKING, ALL LIGHTS BLINKING WHILE THE CAR WAS IN MOTION. LUCKILY MINE MALFUNCTIONED WHILE PARKED AT HOME, NOT DRIVING WITH MY FAMILY. I HAVE 2 CAYENNE, A 2005 AND 2008 THAT MY WIFE DRIVES. I NEED TO FOLLOW FORUM INSTRUCTION IN CLEANING THE DRAINAGE AND REMOVING THE GROMMET THAT CAN BE BLOCKED AND CAUSE WATER NOT TO DRAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11174386February 4, 2019
FUEL/PROPULSION SYSTEM
I CALLED 3 TIMES TO HAVE MY RECALL REMEDIED AND PORSCHE DENIED ME EACH TIME BUT YOUR WEBSITE SAYS I HAVE AN OPEN RECALL, THEY TOLD ME IT IS BECAUSE THE RECALL WASN'T THAT IMPORTANT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11157001December 8, 2018
AIR BAGS, ENGINE, FUEL/PROPULSION SYSTEM
I NOTICED A RECALL ON YOUR SITE FOR MY VIN # BUT I HAVE NOT BEEN REACHED BY PORSCHE TO FIX. I'M UNSURE IF THIS HAS BEEN THE CULPRIT OF MY CHECK ENGINE LIGHT AND AIRBAG LIGHT BEING ILLUMINATED ON MY DASH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153996November 26, 2018
POWER TRAIN
DRIVING FROM NY CITY ON NOVEMBER 20, 2018 ALL OF A SUDDEN START HEARING LOUD CLUNKING/THUMPING NOISE FROM THE UNDER OF THE CAR. IT WAS SCARY. DROVE HOME VERY SLOWLY WITH FLASHERS ON. TOOK THE CAR TO THE PORSCHE DEALER IN ROCHESTER AND THEY DIAGNOSE AND QUOTE ME CLOSE TO $2000 TO REPLACE THE CARDAN DRIVE SHAFT. I DO NOT HAVE THE MONEY AND CAR IS PARKED IN THE DRIVEWAY AT HOME
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153097November 21, 2018
AIR BAGS
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE AIR BAG DEPLOYED WITHOUT WARNING OR A CRASH. THE PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO INJURIES. THE CONTACT CALLED PORSCHE OF TAMPA AT 813-936-2222 (LOCATED AT 103 E FOWLER AVE, TAMPA, FL 33612) AND WAS INFORMED TO CALL THE MANUFACTURER. THE MANUFACTURER WAS CALLED AND THE CONTACT WAS REQUESTED TO PROVIDE PROOF OF OWNERSHIP AND INSURANCE. THE INFORMATION WAS PROVIDED TO THE MANUFACTURER AND AN EMAIL WAS SENT TO THE CONTACT, REQUESTING A PICTURE OF THE VEHICLE. THE CONTACT EMAILED THE PICTURE AND DID NOT RECEIVE A RESPONSE. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT A CARFAX REPORT REVEALED THAT THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH. THE MANUFACTURER DECLINED FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,482.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11124415September 4, 2018
POWER TRAIN:DRIVELINE:DRIVESHAFT
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL CLANKING NOISE UNDERNEATH THE VEHICLE. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT WAS DETACHED AND SPLIT IN HALF AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. *DT DRIVESHAFT FAILED AND REPLACED TWICE 11/05/12 AT 69,400 MILES AND 9/3/18 AT 109,800 MILES. UPDATED 10/5/18*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11111666July 16, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN NOVEMBER OF 2017. THE CONTACT SPOKE WITH NEWPORT BEACH PORSCHE (445 EAST PACIFIC COAST HIGHWAY, NEWPORT BEACH, CA 92600, 877-891-0824) AND WAS INFORMED THAT THEY WERE NOT AWARE OF THE RECALL AND DID NOT HAVE PARTS. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED WITH CLAIM NUMBER: 01020600. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11102015June 15, 2018
TIRES, TIRES:TREAD/BELT
IN 2016, AT AROUND 85,000 MILES THE BIG O TIRES, LOCATED AT 3415 S MARYLAND PKWY, LAS VEGAS, NV 89169, INSTALLED FOUR NEW TIRE ON MY CAYENNE S, 2005. THE TIRE MANUFACTURER IS CONTINENTAL AND ALL TIRES ARE OF 275/45/19 SIZE. ANTICIPATING A 470 MILES TRIP ON JUNE 8, 2018 FROM LAS VEGAS TO MOAB, UT, ON THE PREVIOUS DAY I CHECK ALL TIRES FOR PRESSURE AND APPEARANCE. THE PRESSURE OF THE REAR TIRES WAS SET AT 40 PSI. NO VISIBLE DAMAGES WERE DETECTED. ON THE DAY OF THE TRIP, AT 80 MPH THE REAR LEFT TIRE SUDDENLY LOST PRESSURE REQUIRING SIGNIFICANT EFFORTS TO CONTROL THE VEHICLE. AS SOON AS I MANAGED TO STOP AND LOOK AT THE PROBLEM TIRE, I NOTICED THAT ABOUT 70% OF THE TREAD LAYER WAS SEPARATED FROM THE BODY OF THE TIRE. AT THAT TIME, THE ODOMETER INDICATED THAT THE TIRES WERE USED ONLY FOR ABOUT 3,500 MILES. WHEN I CONTACTED BIG O TIRE IN LAS VEGAS ON MONDAY, JUNE 11, 2018, THE FIRST COMMENT THE MANAGER WAS THAT THE ACCIDENT WAS CAUSED BY A DEFECTIVE TIRE. HOWEVER, TWO DAYS AFTER RECEIVING THE CAR AND THE DAMAGED TIRE, HE INFORMED ME THAT CONTINENTAL REFUSED TO TAKE RESPONSIBILITY IN THIS CASE. THEY HAVE DETERMINED THAT A LOW AIR PRESSURE CAUSED THE DAMAGE. KNOWING THE FACTS, I BELIEVE THAT CONTINENTALS CONCLUSION IS MOST PROBABLY INCORRECT. I STRONGLY RECOMMEND THAT FOR THE SAFETY OF MILLIONS OF USERS OF TIRES MANUFACTURED BY CONTINENTAL, THIS CASE IS INVESTIGATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11099994June 5, 2018
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PORSCHE OF HILTON HEAD, 107 DRIVERS WAY, HARDEEVILLE, SC 29927, (843) 208-3300) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11096251May 22, 2018
FUEL SYSTEM, GASOLINE
2005 PORSCHE CAYENNE. CONSUMER WRITES IN REGARDS TO FILTER FLANGE OF FUEL PUMP. *LD THE CONSUMER STATED THE VEHICLE FAILED WITH THE SAME DEFECT AS DESCRIBED IN THE RECALL, PRIOR TO RECALL BEING IN EFFECT. THE MANUFACTURER WAS NOTIFIED AND HAD NOT RESPONDED TO THE CONSUMER'S REQUEST FOR REIMBURSEMENT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11093250May 10, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT SMELLED A FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER'S SIDE FUEL TANK FLANGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. ONE MONTH AND THREE WEEKS LATER, THE CONTACT RECEIVED A RECALL NOTIFICATION IN THE MAIL FOR NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE). THE RECALL WAS FOR THE SAME FAILURE THAT THE CONTACT HAD GOTTEN REPAIRED PRIOR TO RECEIVING THE RECALL NOTICE. THE MANUFACTURER WAS INFORMED THAT THE FAILURE HAD BEEN REPAIRED PRIOR TO HAVING ANY KNOWLEDGE OF THE RECALL. THE MANUFACTURER STATED THAT THEY USUALLY USE A THIRD PARTY FOR REIMBURSEMENT; HOWEVER, THAT WAS NOT THE CASE FOR THIS RECALL SO REIMBURSEMENT WAS NOT POSSIBLE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 59,626. *TT UPDATED 9/20/18*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11091943May 4, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE S. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL PUMP, GASOLINE) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN NOVEMBER OF 2017. THE VEHICLE WAS TAKEN TO THE DEALER (THE COLLECTION, 200 BIRD ROAD, CORAL GABLES, FL 33146, PHONE (305) 444-5555), BUT THE PARTS WERE UNAVAILABLE. THE DEALER HAD BEEN WAITING FOR PARTS FOR MORE THAN NINETY DAYS. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE COLLECTION DEALER CONTACTED THEM CONCERNING PART AVAILABILITY. THE DEALER WAS INFORMED THAT THE PARTS WERE UNAVAILABLE AND THE MANUFACTURER DID NOT KNOW WHEN THEY WOULD ARRIVE. THE CONTACT WAS CONCERNED THAT THE VEHICLE MIGHT EXPERIENCE A FAILURE BEFORE PARTS BECAME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Porsche Cayenne