Porsche Boxster Complaints

190 consumer complaints on file.

#10454441April 8, 2012
SEAT BELTS
THE SEAT BELT ON MY VEHICLE, WHEN BUCKLED, HAS A TENDENCY TO NOT LATCH COMPLETELY AND ALLOWS FOR THE RELEASE WITHOUT PRESSING THE RELEASE BUTTON. ALSO WHEN IT IS LATCHED, THERE IS A TENDENCY FOR IT TO GET CAUGHT AND NOT RELEASE WITHOUT SIGNIFICANT PULLING FORCE ON THE BUCKLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448412February 18, 2012
ENGINE AND ENGINE COOLING, POWER TRAIN
THIS IS A VERY WELL KNOW IMS FAILURE ISSUE WITH PORSCHE BOXSTER WHICH CERTAINLY CALLS FOR A RECALL FROM PORSCHE. MY 2005 ENGINE WILL NEED TO BE REPLACED FOR 20K JUST BECAUSE OF THE VERY OBVIOUS DESIGN FLAW PORSCHE HAS IN ITS M96 ENGINES. I AM PRETTY SURE THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THIS IN PAST BUT NOBODY HAS EVER HEEDED TO IT. I SINCERELY RECOMMEND SOME ONE TO PLEASE LOOK INTO AND ASK PORSCHE TO ACCEPT AND RECALL M96 ENGINES FAILING DUE TO IMS. ANY CAR EXPERT OR MECHANIC OR DEALERSHIP CAN VOUCH FOR THE DESIGN FLAW PORSCHE HAS. ITS POTENTIALLY FATAL TOO. I SINCERELY REQUEST SOMEONE TO LOOK INTO THIS COMPLAINT WITH UTTERMOST SINCERITY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10443249January 10, 2012
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
MISFIRES DURING WARM UP, AFTER WARM UP THE ENGINE RUNS SMOOTH WITH HIGH RPM OF 1200 TO 1300. I HAVE TO TAP THE ACCELERATOR PAD TO LOWER THE RPM,AFTER COUPLE OF SECONDS THE RPM GOES BACK UP. WHEN IT REACHES 190 DEGREES RPM GOES HIGHER TO ALMOST 1500, TEMPERATURE GOES TO 210 DEGREES FAN TURNS ON FROM THE RADIATOR ON THE DRIVER SIDE BUT NOT ON THE PASSENGER SIDE, FAN ON THE ENGINE COMPARTMENT SOMETIMES TURNS ON AND SOMETIMES NOT . THEN THE ENGINE STOPS RUNNING AT 210 DEGREES, START UP BUT WON'T RUN. YOU HAVE TO WAIT FOR THE TEMPERATURE TO DROP DOWN TO 160 DEGREES, SOMETIMES ALL THE WAY DOWN. START IT UP THEN THE ENGINE RUNS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426168September 17, 2011
ENGINE AND ENGINE COOLING
MOTOR FAILED WHILE TRYING TO START IT. ALL VALVES BENT. REPLACED AT MY EXPENSE. I BOUGHT THE CAR NEW AND IT WAS SERVICED AS PER FACTORY RECOMMENDATIONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10423403August 29, 2011
ENGINE AND ENGINE COOLING
THIS LOW-MILEAGE VEHICLE EXPERIENCED A CATASTROPHIC ENGINE FAILURE AT FREEWAY SPEED. THE VEHICLE WAS CRUISING ON LEVEL FREEWAY WHEN THE ENGINE LOST POWER AND WHITE SMOKE BEGAN POURING OUT OF THE EXHAUST. THE ENGINE DIED AND WOULD NOT RESTART ON THE SIDE OF THE FREEWAY AND WAS TOWED TO A SERVICE FACILITY. AFTER COMPLETE DISASSEMBLY IT WAS DETERMINED THAT THE ENGINE WAS NOT REBUILD-ABLE DUE TO A SLIPPED CYLINDER SLEEVE WHICH RESULTED IN PISTON, CYLINDER HEAD AND BLOCK DAMAGE. DETAILED PHOTOS ARE AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10423382August 27, 2011
ENGINE AND ENGINE COOLING
WHILE PULLING AWAY FROM A STOP LIGHT IN LIGHT CITY TRAFFIC, ENGINE SUDDENLY HAD REDUCED POWER OUTPUT IMMEDIATELY FOLLOWED BY LOUD SOUNDS OF LOOSE METAL PARTS THROUGH OUT THE ENGINE COMPARTMENT. UPON INSPECTION BY A PORSCHE SPECIALIST, HE DETERMINED THAT THE ENGINE HAD SUFFERED INTERMEDIATE SHAFT FAILURE WHICH CAUSED CATASTROPHIC ENGINE FAILURE BY ALLOWING THE VALVES TO MAKE CONTACT WITH THE PISTON HEADS AND SHREDDING BALL BEARS WHICH SENT METAL SHAVING THROUGH THE OILING SYSTEM. THE ENGINE IS CONSIDERED NON-REPAIRABLE AND REQUIRES A COMPLETE REPLACEMENT ENGINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422028August 22, 2011
ENGINE AND ENGINE COOLING
ENGINE FAILURE WITH CAUSE DETERMINED TO BE CONNECTING ROD BOLT FAILURE, SUBSEQUENTLY LEADING TO DAMAGE TO NEARLY ALL INTERNAL ENGINE COMPONENTS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419222August 12, 2011
ENGINE AND ENGINE COOLING:ENGINE
CATASTROPHIC ENGINE DAMAGE DUE TO INTERMEDIATE SHAFT BEARING FAILURE. THERE ARE NO SIGNS THAT THE PART WILL FAIL. THERE IS A GRINDING NOISE IN THE ENGINE AND UPON STOPPING ALL THE OIL LEAKS OUT. AS SOON AS THE NOISE IS HEARD, THE ENGINE IS IRREPARABLE DAMAGED. INSTANT, CATASTROPHIC DAMAGE. ENGINE IS A TOTAL LOSS. BEARING IS A DEFECTIVE DESIGN AND HAS BEEN REDESIGNED IN NEWER MODELS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418537August 11, 2011
ENGINE AND ENGINE COOLING:ENGINE
TRAVELING 75MPH ON FREEWAY WHEN OIL & ENGINE LIGHTS CAME ON AND VEHICLE SIMULTANEOUSLY CAME TO DEAD STOP IN TRAFFIC; DIAGNOSED AS CATASTROPHIC ENGINE FAILURE BY DEALER SERVICE MGR., ENGINE REPLACED AT COST OF $17,000+. NO PRIOR WARNING. NO FAULT OF MY OWN PER SVC.MGR. 38K MILES ON 2005 VEHICLE, 3 MO OUT OF WARRANTY. MANY SIMILAR INCIDENTS REPORTED ON SEVERAL WEB SITES. SERVICE MGR REPORTED PORSCHE WELL AWARE OF THIS ISSUE BUT DOES NOTHING BECAUSE ITS TOO COSTLY TO REPAIR AND PREFERS TO HANDLE ON CASE BY CASE BASIS. SOMETIMES COVERS PART OF COST, SOMETIMES NOTHING. HAD I NOT BEEN ABLE TO BRAKE AND COAST TO STOP, I WOULD HAVE ROLLED OVER AND MOST LIKELY BEEN KILLED! DAMAGED ENGINE RETURNED TO PORSCHE IN GERMANY. I HAVE THE PART THAT BROKE FROM WHICH LITTLE BALLS SPEWED THROUGHOUT THE ENGINE. I AM INFORMED THIS OCCURS IN APPROX. 20% OF PORSCHE BOXSTERS AND OTHER PORSCHE VEHICLES FOR SEVERAL YEARS UNTIL THEY REDESIGNED THE BOLT IN 2010 MODELS. UNABLE TO DETERMINE HOW MANY INJURIES AND/OR DEATHS RESULTING FROM THESE CATASTROPHIC ENGINE FAILURES BECAUSE ACCIDENTS WOULD APPEAR TO BE FROM DRIVER ERROR AND NO ONE WOULD KNOW THE ENGINE FAILED UNDER THESE CIRCUMSTANCES! PORSCHE EMPLOYEES ARE INSTRUCTED NOT TO ACKNOWLEDGE KNOWING ANYTHING ABOUT THIS BEING AN ONGOING ISSUE AND NOT TO MAKE REPAIRS AT PORSCHE EXPENSE EXCEPT FOR THE CUSTOMERS WHO RAISE THE BIGGEST FUSS. ANOTHER BOXSTER WAS IN THE SHOP AT THE SAME TIME AS MINE FOR THE SAME PROBLEM. THE GOOGLE ADDRESS LINK BELOW SHOWS A PHOTO OF A BOXSTER CRANKSHAFT AND INTERMEDIATE SHAFT. ONE OF THE CONNECTING RODS BROKE NEAR THE PISTON WRIST PIN END AND THE INTERMEDIATE SHAFT IS DAMAGED. THIS CATASTROPHIC ENGINE FAILURE IS THE RESULT OF: 1) A SEIZED CONNECTING ROD BEARING, 2) A LOSS OF OIL PRESSURE, 3) BAD ORIGINAL COMPONENT DESIGN, 4) INTERMEDIATE SHAFT ASSEMBLY FAILURE (BOLTS OR MECHANICAL CONNECTION EG: WELD, CRIMP). THIS IS WHAT HAPPENED TO MY CAR. HTTP://WWW.RX8CLUB.COM/SHOWTHREAD.PHP?T=160705. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405468June 7, 2011
ENGINE AND ENGINE COOLING:ENGINE
MY 2005 PORSCHE BOXSTER, 23K MI, HAD CATASTROPHIC ENGINE FAILURE AT IDLE. THE ENGINE STALLED;I WAS ABLE TO RESTART BUT A LOUD CLANGING NOISE CAME FROM ENGINE. THE CAR THEN DIED AGAIN. THE MECHANIC SAID IT WAS DUE TO AN INTERMEDIATE SHAFT (IMS) FAILURE; THE REQUIRED ENGINE REPLACEMENT IS $14K. THE MECHANIC SAID HE HAS HEARD OF SIGNIFICANT NUMBER OF IMS FAILURES (BUT PORSCHE HAS NOT NOTIFIED OWNERS). THERE WERE NO INJURIES, BUT CERTAINLY ENGINE FAILURE LIKE THIS COULD HAVE SERIOUS CONSEQUENCES AT FREEWAY SPEEDS. PORSCHE FORUMS ON INTERNET SHOW FREQUENCY OF FAILURES FROM THIS DEFECT (POORLY DESIGNED BEARING ASSEMBLY ON IMS) IS VERY HIGH, AS MUCH AS 8-11% IN ONE FORUM POLL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405356June 6, 2011
ENGINE AND ENGINE COOLING
I WAS INTERESTED IN PURCHASING A 2000 PORSCHE BOXSTER S. I TOOK THE CAR TO A PORSCHE DEALER TO HAVE A PRE PURCHASE INSPECTION PERFORMED AND WAS NOTIFIED BY THE DEALERSHIP THAT THE 53,000 MILE CAR ACTUALLY HAD A FACTORY REPLACEMENT ENGINE INSTALLED FOR UNKNOWN REASON. I CONTACTED THE DEALERSHIP THAT ACTUALLY INSTALLED THE FACTORY REPLACEMENT ENGINE AND I WAS INFORMED THAT THE ENGINE WAS REPLACED AT 35,000 MILES FOR AN OIL LEAK. THE DEALERSHIP THAT PERFORMED THE INSPECTION REPORTED THAT A FEW MINOR ISSUES NEEDED TO BE ADDRESSED BUT OVERALL THAT THE CAR WAS IN EXCELLENT CONDITION. I TOOK OWNERSHIP OF THE CAR AND WITHIN 2,000 MILES OF MY OWNERSHIP, THE INTERMEDIATE SHAFT BEARING BOLT FAILED DESTROYING THE ENGINE. I HAVE BEEN IN CONTACT WITH OTHER PORSCHE BOXSTER OWNERS AND THIS PROBLEM IS VERY COMMON, EVEN ON ENGINES WITH 20,000 MILES ON THEM. AT THE MOMENT, THE ONLY FIX FOR THIS ISSUE IS AN ENGINE REPLACEMENT FROM THE DEALERSHIP AT A COST OF $8,000-$13,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10398191April 29, 2011
ENGINE AND ENGINE COOLING:ENGINE
2004 PORSCHE BOXSTER, 58-60K MI, HAD CATASTROPHIC ENGINE FAILURE AT 10 MI/HR. ENGINE STALLED; WAS ABLE TO RESTART AND DRIVE A FEW FEET, BUT BADLY MISSING. LOUD CLANGING NOISE FROM ENGINE. NO SMOKE. OIL DRAINED FROM CAR WHEN TILTED ON TOWTRUCK. DEALER FOUND INTERMEDIATE SHAFT (IMS) FAILURE; REQUIRED ENGINE REPLACEMENT AT $18K. DEALER SAID THEY HAD SEEN A SIGNIFICANT NUMBER OF IMS FAILURES (BUT PORSCHE HAS NOT NOTIFIED OWNERS). NO INJURIES, BUT CERTAINLY ENGINE FAILURE LIKE THIS COULD HAVE SERIOUS CONSEQUENCES AT FREEWAY SPEEDS. PORSCHE FORUMS ON INTERNET SHOW FREQUENCY OF FAILURES FROM THIS DEFECT (POORLY DESIGNED BEARING ASSEMBLY ON IMS) IS VERY HIGH, AS MUCH AS 8-11% IN ONE FORUM POLL. DEFECT FOUND IN MY97-08. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10396934April 20, 2011
ENGINE AND ENGINE COOLING
VEHICLE WAS 2005 PORSCHE BOXSTER. CAR ENGINE SELF-DESTRUCTED WHILE DRIVING HIGHWAY AT 70 MPH. CAUSE WAS FAILURE OF INTERMEDIARY SHAFT BEARING AT 29,000 MILES AS DETERMINED BY ENGINE DISSEMBLY. CAR HAD BEEN PROPERLY MAINTAINED AND SERVICED BY PORSCHE FACILITIES FOR ITS LIFE. INTERMEDIARY SHAFT FAILED AFTER BEARING FAILED, SENDING METAL PIECES THROUGHOUT ENGINE INCLUDING INTO OIL SUMP. TIMING BELT PERFORATED CAMSHAFT COVER. ENGINE WAS IRREPARABLE. THERE ARE MANY OTHER REPORTS ON INTERNET SITES, EASILY SEARCHABLE, FOR "PORSCHE ENGINE FAILURE" OF THIS TYPE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10395201April 7, 2011
ENGINE AND ENGINE COOLING
IMS ENGINE FAILURE. KNOWN ISSUES WITH PORSCHE. PORSCHE BOXSTER 49,500 MILES. PLACE CAR IN REVERES, ENGINE SEIZED. REPLACEMENT OF ENGINE NECESSARY. $8000- $15,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10389269March 10, 2011
ENGINE AND ENGINE COOLING:ENGINE
2005 PORSCHE BOXSTER. CONSUMER STATES ENGINE MADE GRINDING A SOUND AND WOULD NOT START *TGW THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER, WHERE HE WAS INFORMED THE VEHICLE NEEDED A NEW ENGINE. THE CONSUMER STATED NO ONE COULD PROVIDE AN EXPLANATION AS TO WHY A VEHICLE WITH SUCH LOW MILES WOULD NEED A NEW ENGINE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10381055February 7, 2011
AIR BAGS, EQUIPMENT, EQUIPMENT:OTHER:LABELS
THE AIRBAG LIGHT HAS COME ON FOR THE THIRD TIME. THE PROBLEM IS IN A SENSOR IN THE SEATBELT. EACH TIME IT IS THE SAME PROBLEM AND PORSCHE WANTS ME TO SPEND $550 TO REPLACE THE UNIT WITH THE FOURTH SENSOR. I HAVE DECLINED TO DO THIS AS THEY WILL NOT WARRANTY THE NEW UNIT. THIS IS A WELL KNOWN DEFECT IN THIS CAR ACCORDING TO SERVICEMEN AND THERE ARE SIMILAR COMPLAINTS ON YOUR WEBSITE. I HAVE CALLED AND WRITTEN TO PORSCHE WITHOUT RESPONSE. *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10375185January 7, 2011
FUEL SYSTEM, GASOLINE
TL*THE CONTACT 2005 PORSCHE BOXSTER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IN THE GARAGE HE SMELLED AN UNUSUAL ODOR. THE CONTACT DROVE THE VEHICLE OUT OF THE GARAGE AND NOTICED FUEL LEAKING. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM NOT TO DRIVE THE VEHICLE AND IT WAS TOWED TO A DEALER. THE DEALER REPLACED THE FUEL LINE. THE CONTACT STATED THE VEHICLE COULD HAVE CAUGHT ON FIRE WHILE DRIVING. THE FAILURE MILEAGE WAS 51,000. AFTER FURTHER INVESTIGATION THE PROBLEM WAS CAUSED BY SQUIRRELS EATING/ CLAWING THE FUEL LINE. IT WAS NOT A FAILURE OF THE PART. UPDATED 10/19/2011 *LN *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10368666December 2, 2010
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1997 PORSCHE BOXSTER. THE CONTACT STATED THE IGNITION SWITCH WAS CRACKED AND CAUSING ELECTRICAL FAILURES TO THE AIR CONDITIONER, WIPERS AND HEAD LIGHTS. THE CONTACT NOTICES A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 98V113000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER SHOULD EXTEND THE RECALL SINCE THE FAILURE WAS A KNOWN SAFETY DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360369October 13, 2010
SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM
MY 2011 PORSCHE CAYENNE HAS AN "AUTO STOP" FEATURE THAT KILLS THE ENGINE WHENEVER THE CAR IS STOPPED AT A STOP LIGHT OR STOP SIGN. WHEN THE DRIVER'S FOOT IS REMOVED FROM THE BRAKE, THE CAR ENGINE RESTARTS. THE STOP-START DELAY IS POTENTIALLY DANGEROUS. I WAS ALMOST REAR-ENDED BY A CAR THAT WAS BEHIND ME BECAUSE THE DRIVER WAS ANXIOUS TO "MOVE" AND MY CAYENNE'S ENGINE HAD TO RESTART BEFORE IT WOULD MOVE FROM THE STOP LIGHT. THIS SPECIAL FEATURE CAN BE TURNED OFF, BUT YOU MUST TURN IT OFF EVERY TIME YOU START THE CAR. OTHERWISE, THE AUTO STOP FEATURE WILL CONTINUE TO OPERATE. I CONSIDER THE AUTO STOP FEATURE TO BE PROBLEMATIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360051October 12, 2010
AIR BAGS:FRONTAL
PORSCHE BOXTER AIRBAG ( SRS) MALFUNCTION. SPONTANEOUS DEPLOYMENT. MONDAY, OCT.11 2010 APPROX. 2:00. VEHICLE HAD BEEN UNUSED FOR 4 WEEKS. I ATTEMPTED TO START THE VEH. BATTERY WAS ALMOST DEAD. NO ACTION FROM STARTER. VEH ALARM SOUNDED. ALARM REMAINED BLARING UNLESS KEY WAS IN #1 POSITION. I WENT INTO MY HOUSE ( TO CALL FOR ASSISTANCE. ) I HEARD A LOUD " BANG " . UPON RETURNING TO MY CAR I SAW THAT THE LEFT (DRIVERS) AIR BAG HAD DEPLOYED. I REMOVED THE KEY FROM THE VEHICLE. THE ODOR FROM THE AIRBAG WAS NOT PLEASANT. THERE WERE NO INJURIES. NO ONE WAS IN THE VEHICLE AT THE TIME OF THE SPONTANEOUS DEPLOYMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Porsche Boxster