Nissan Titan Complaints (2004)

1,046 consumer complaints on file.

#10512109May 15, 2013
WHEELS, SUSPENSION
FOURTH RIGHT REAR AXLE SEAL. SECOND IN TWO WEEKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10511694May 13, 2013
POWER TRAIN, ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACTED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE EXHAUST MANIFOLD WAS CRACKED AND EXHAUST FUMES WERE LEAKING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE EXHAUST HEADERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 43,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10510902May 7, 2013
POWER TRAIN
RIGHT REAR AXLE SEAL LEAKS AND IF NOT REPAIRED IMMEDIATELY, FLUID LEAKS ONTO BRAKE ROTOR. HAS THE POTENTIAL OF LOSING ALL DIFFERENTIAL FLUID FROM REAR END CAUSING A COMPLETE DRIVETRAIN FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509804April 27, 2013
SUSPENSION
CATASTROPHIC FAILURE OF THE LEAF SPRING ON DRIVER SIDE REAR OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509090April 22, 2013
SEAT BELTS
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE SEAT BELT SEIZED AND BECAME DIFFICULT TO UNLOCK. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE SEAT BELT WAS WORKING PROPERLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505940April 11, 2013
ENGINE, VEHICLE SPEED CONTROL
DURING ROUTINE RECALL FOR ECM MODULE THE DEALER INFORMED ME THAT BOTH EXHAUST MANIFOLDS ARE CRACKED AS THIS HAS BEEN A RECURRING ISSUE WITH THIS MODEL VEHICLE CAUSING EXHAUST FUMES TO ENTER THE CABIN AND ALSO CAUSE POOR PERFORMANCE WITH THE VEHICLE. DEALER QUOTED THIS AS A $3200.00 REPAIR AND WILL NOT ASSUME ANY PORTION OF THE REPAIR. DEALER "BEAVERTON NISSAN" HAS INFORMED ME THAT THIS ISSUE IS DUE TO THE POOR QUALITY OF THE EXHAUST MANIFOLDS ANY POSSIBLE FAULTY WELDS ON THE PRODUCT COMBINED WITH MATERIAL THAT IS TOO THIN TO START WITH. THE PRESENCE OF EXHAUST FUMES IN THE CABIN WHILE IDLING AND/OR DRIVING IS A SEVERE SAFETY HAZARD. I HAVE OPENED A CASE WITH NISSAN NORTH AMERICA AND HAVE BEEN ADVISED BY THREE INDEPENDENT MECHANICS TO PARK THE VEHICLE UNTIL IT IS SAFE TO DRIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503519March 18, 2013
ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE DRIVER'S AND PASSENGER'S SIDE EXHAUST MANIFOLD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 125,000. UPDATED 5/9/13 *CN UPDATED 05/24/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503263March 16, 2013
SERVICE BRAKES, HYDRAULIC
JUST LAST FRIDAY (03-15-2013) AFTERNOON,WHILE LOOKING OVER THE TRUCK- I DECIDED TO LOOK UNDERNEATH IT TO GIVE IT A ONCE OVER. EARLIER IN THE WEEK I HAD NOTICED THE BRAKE PEDAL KIND OF SPONGY(ESPECIALLY IN THE MORNING). I THOUGHT THERE MIGHT BE A PROBLEM WITH THE BRAKES. TO MY SURPRISE I FOUND THAT BOTH REAR AXLES WERE SPLATTERED WITH FLUID(AXLE GREASE).I HAD READ THAT THIS WAS A PROBLEM WITH EARLY MODEL TITANS. I WENT INTO A TITAN FORUM AND FOUND THERE WERE A LOT OF FOLKS,THAT OWNED THESE TRUCKS-HAVING THE SAME PROBLEM. IN THE FORUM THERE WAS THIS VERY SITE TO REPORT THIS ISSUE.SO THUS THIS WRITING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503025March 14, 2013
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 NISSAN TITIAN. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE WOULD NOT STOP. THE CONTACT WOULD SHUT OFF THE ENGINE AND ONCE RESTARTED, THE VEHICLE WOULD RESUME NORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO PERFORMED A DIAGNOSTIC BUT WAS UNABLE TO GENERATE A FAILURE CODE. THE DEALER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED BEFORE ANY REPAIRS WOULD BE PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10501763February 28, 2013
POWER TRAIN, POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
THE REAR DIFFERENTIAL HAS BEEN WHINING SINCE 63,000 MILES AND LAST WEEKEND THE WHINING BECAME HOWLING AND THEN CLUNKING. MY MECHANIC SAYS SOMETHING INSIDE THE DIFFERENTIAL IS BROKEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10498033February 13, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE ENGINE MADE A RATTLING SOUND AND EXHAUST FUMES WERE SMELLED INSIDE THE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THERE WAS A HAIRLINE FRACTURE LEADING FROM THE CATALYTIC CONVERTER TO THE MANIFOLD THAT WAS CAUSING THE SMELL. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 95,391.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10497889February 12, 2013
SUSPENSION
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR DIFFERENTIAL AND AXLES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE AND CURRENT MILEAGE WAS 138,000...UPDATED 03/18/13 *BF THE CONSUMER STATED ALSO THE REAR END WAS LOCKING UP. UPDATED 04/26/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10497634February 10, 2013
POWER TRAIN
DRIVING ABOUT 40 MPH, I HEARD A LOUD POP COMING FROM THE REAR END OF THE TRUCK. NOW WHENEVER I DECELERATE, A WHINING NOISE IS HEARD FROM THE DIFFERENTIAL. TOOK THE TRUCK TO THE NISSAN DEALER IN IRVINE, CA AND THEY WANT TO REPLACE THE REAR DIFFERENTIAL AT A COST OF $2500.00. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496476February 5, 2013
SEAT BELTS
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT WEBBING FAILED TO AUTOMATICALLY RETRACT UPON ENGAGING. IN 2006, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V345000 (SEAT BELTS) EVEN THOUGH THERE WAS NOT A DEFECT. IN 2013, THE SEAT BELT RETRACTOR MALFUNCTION OCCURRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496387February 4, 2013
POWER TRAIN, STEERING, WHEELS
I WAS USING MY FOUR WHEEL DRIVE WHEN I NOTICED A LOUD CLUNK AND FOUND THAT MY AXLE HAD POPPED OUT OF THE FRONT DIFFERENTIAL. I AM AMONG OVER 1000S OF TITAN OWNERS WITH THIS SAME ISSUE THAT NISSAN KNOWS ABOUT AND HAS CAUSED MULTIPLE FAILURES IN OUR TRUCKS. IT ALSO CAUSED A FAILURE IN MINE. THE HAVE KNOWN ABOUT THIS ISSUE FOR YEARS NOW AND CHANGED THERE PART IN 07 FROM THE ORIGINAL NUMBER 38500-8S102 TO THE NEW PRODUCT NUMBER 38500-8S11B TRUCK IS A NISSAN TITAN 2004 SE KING CAB 4WD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496395February 4, 2013
AIR BAGS
I WAS DRIVING WEST BOUND 55 MPH WITH RIGHT OF WAY. OTHER DRIVER PULLED OUT IN FRONT OF ME HEADING NORTH. I HIT HIS PASSENGER SIDE. TOTALED MY TITAN. NO AIRBAG DEPLOYMENT. I SUSTAINED UPPER BODY INJURIES DUE TO NO AIRBAG SUPPORT. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10493239January 16, 2013
ENGINE AND ENGINE COOLING
EXHAUST MANIFOLD IS CRACKED AND LEAKS FUMES INTO CAB. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10490420December 29, 2012
POWER TRAIN
TRUCK STARTED MAKING LOUD GRINDING SOUND WHEN LETTING OFF ACCELERATOR AND COASTING. I WAS ADVISED BY MY MECHANIC TO REPLACE THE ENTIRE REAR END WITH A BRAND NEW ONE FROM NISSAN BECAUSE THEY HAD MODIFIED IT. OBVIOUSLY THEY NEW IT WAS A PROBLEM. $2500.00 REPAIR. GLAD THE DRIVE SHAFT DID NOT LOCK UP ON THE INTERSTATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10489442December 21, 2012
POWER TRAIN
I ENGAGED MY FRONT DIFFERENTIAL (4X4) AND PROCEEDED TO PUT DRIVETRAIN IN REVERSE AND WHILE BACKING UP THE PASSENGER SIDE FRONT AXLE POPPED OUT OF THE DIFFERENTIAL, I WAS NOT PULLING ANYTHING SO I WAS NOT UNDER ANY LOAD WHATSOEVER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10489020December 17, 2012
SERVICE BRAKES, SEATS
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE ABS BRAKING SYSTEM FAILED WITHOUT WARNING. THE ABS WARNING LIGHT WAS ILLUMINATED WHEN THE FAILURE OCCURRED. THE CONTACT STATED THAT THE VEHICLE HAD TO BE TURNED ON AND OFF IN ORDER FOR THE BRAKES TO WORK PROPERLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE VDC UNIT NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 85,000. UPDATED 1/29/13 *CN THE CONSUMER STATED THE MANUFACTURER WAS CONTACTED AND OFFERED TO PAY FOR ONE THIRD OF ALL REPAIRS FOR THE VDC AND SAFETY RESTRAINT SYSTEM. HOWEVER, THE CONSUMER IS IN DISAGREEMENT BECAUSE ALL ITEMS REQUEST FOR REPAIR POSE A SIGNIFICANT SAFETY CONCERN. UPDATED 2/7/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Nissan Titan