Kia Sorento Complaints (2018)

255 consumer complaints on file.

#11684064August 30, 2025
FUEL/PROPULSION SYSTEM, ENGINE, UNKNOWN OR OTHER
The Vehicle emits a strong fuel odor: seems to be around the rear of vehicle & front engine compartment of vehicle. Seems the fuel system, both low & high pressure fuel pumps and their pipes channels are leaking to emit a strong fuel odor. Extreme high volatile combustion & fire risk! Remedy: the fuel system including both low & high pressure fuel pumps & their pipes channels need replaced with strong, better engineered components! A newer vehicle like this should not be having fuel system failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683420August 27, 2025
EXTERIOR LIGHTING:HEADLIGHTS:BULBS
The contact owns a 2018 Kia Sorento. The contact stated that while driving at an undisclosed speed, the headlights failed to function as intended. The contact, who was a retired certified mechanic, inspected the headlights and determined that the passenger's side headlight bulbs were blown. The contact then noticed a burning odor in the circuit board inside the headlight. The contact stated that the front passenger's side headlight bulbs were replaced twice within three months due to failure. In addition, the contact stated that an unknown manufacturer's recall was performed approximately two years prior, and the multi-function switch knob was replaced. The contact stated that the headlights were not replaced at the time. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683033August 25, 2025
ENGINE, UNKNOWN OR OTHER
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine misfired due to a broken valve in one of the cylinders. This failure occurred approximately two months after completing the scheduled 100,000-mile service at a Kia dealership. The affected parts (valve, cylinder components) should still be available for inspection by Kia or a third party. 2. How was your safety or the safety of others put at risk? The vehicle suddenly lost power and stalled in the middle of the highway while driving at normal speed. This created a dangerous situation where I could have been struck by oncoming traffic while trying to safely exit the roadway. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was confirmed by a repair shop, which diagnosed the cause as a misfire due to a broken valve. I have service documentation of the diagnosis available. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has not yet been inspected by the manufacturer or insurance representatives, but it was inspected by the servicing dealership and/or an independent mechanic who confirmed the valve failure. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the complete failure, the check engine light illuminated and the vehicle began running roughly (misfiring). These symptoms appeared very shortly before the breakdown, giving me no meaningful time to react before the engine stalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682431August 22, 2025
ENGINE, ELECTRICAL SYSTEM
My vehicle started with oil issues took to dealer and the attempted to perform an oil consumption test however the vehicle would not pass the test as the oil would not last long enough for next test. Was advised I needed an engine, Kia refused to replace since it wouldn’t pass consumption test. I paid for engine replacement 1month later engine light comes on, again I return to Kia dealer they say engine needs replacement they replace supposedly through warranty. Drive for about 30 days and engine light comes on again takes to dealer and they say it’s the knock sensors code which is the same code that came up prior to engine replacement. The knock sensor was a recalled part that they replaced by them but now are refusing to replace even though they replaced it less then 12 months ago.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681804August 20, 2025
ENGINE
The contact owns a 2018 Kia Sorento. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound. Additionally, the contact stated that while driving and depressing the accelerator pedal all the way to the floorboard, the vehicle failed to exceed 18 MPH. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the failure was linked to the knock sensor detection system(KSDS). The vehicle was not repaired. The local dealer was unreachable. The manufacturer was not notified of the failure. The failure mileage was 85,798.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681664August 19, 2025
ENGINE
I was driving and the vehicle shut off. All electric still on lights, radio, dash, etc. No issues or noises indicating that the engine was having faliure. Did not overheat, had oil and gas. Just bought car used 6 months ago with 140k miles. Had it towed to Mechanic and was told the engine was locked. Engine repair is my only option that is going to cost 5-8k. Vehicle has been maintained regularly with only one previous owner and no major repairs ever needed to be done.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680395August 13, 2025
SEAT BELTS
The contact owns a 2018 Kia Sorento. The contact stated that the rear driver's side seat lap belt harness anchor pin had detached while the contact's son was attempting to wear the seat belt, rendering the seat belt inoperable. The vehicle was taken to the dealer, where an unknown diagnosis was made, and the contact was informed that there was a fee for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 76,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679919August 11, 2025
FUEL/PROPULSION SYSTEM
* High pressure fuel pump quick disconnect fuel line fitting leaking fuel. * Raw fuel leaking poses a risk of fire and danger to the vehicle occupants. Raw fuel leaking in a closed in area as it did in my garage could have lead to an explosion due ignition of the fuel vapors. * My vehicle was repaired by a KIA dealership. The dealership noted that they've seen this issue several times in the past few months including one instance where the fuel line fitting actually fell off. The dealership acknowledged this failure hasn't yet become a recall issue which is why I'm filing a complaint with the NHSTA to establish a record of the issue. * The component was probably discarded by the dealership. The dealership didn't mention sending the part out for inspection or reporting the issue to the manufacturer. Galeana KIA did provide 2 pictures of the fuel leak area. I've attached these to this form. * There were no warning lamps or messages for this type of leak. The vehicle drove as normal. It wasn't until I parked the vehicle in my garage that I noticed a strong smell of raw fuel.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679947August 11, 2025
EXTERIOR LIGHTING
My lights are set to auto but when driving they randomly switch off. The dash shows the switch from auto to off but the control is still set to auto. I have to manually switch the control off and then back on for the lights to come back on. I’ve also noticed a few times in the morning my lights are on. My switch is set to auto and my car is completely off but the lights are on. This is very unsafe as it happens at night and I can’t see the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679393August 8, 2025
ENGINE
I am writing to express my concern regarding a serious issue with my 2018 Kia Sorento equipped with the 2.4-liter engine. The vehicle has been experiencing excessive oil consumption—approximately one quart every 400 miles—which I believe may be indicative of a manufacturing defect. Based on similar issues reported with more recent Kia models, including those involving potentially defective piston oil rings, I am concerned that my vehicle may be affected by a similar issue. As you are aware, defective piston rings can lead to long-term engine damage, sudden loss of power, and even an increased risk of engine fire. Given the severity of the symptoms and potential safety implications, I respectfully request that this matter be formally investigated and that Kia consider extending the recall or offering a resolution for affected 2018 Sorento models. I look forward to your prompt response regarding this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678060August 3, 2025
EXTERIOR LIGHTING
The headlights will randomly turn off while driving, mostly when turning on the right blinker. This has been happening a few times a month since I got the vehicle in 2017. More recently, the bottom brake lights and running lights have been shorting out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675515July 23, 2025
ENGINE
Excessive oil consumption, 4 quarts in 2000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668658June 23, 2025
ENGINE
Engine oil is always law. Engine eats lots of oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668487June 22, 2025
UNKNOWN OR OTHER
The car is not able to shift out of park unless the shift interlock release button is depressed. This issue has occurred intermittently in the last year but has been consistent in the past few weeks of the submission of the complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668489June 22, 2025
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: WARNING
An intermittent error occurs where these services stop working. It was last for a day or two and then the error will clear. I am not able to be alerted to passing cars or cars in my blind spot when changing lanes. And if there is a situation to suddenly stop the emergency automatic braking system will not be engaged.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665687June 9, 2025
ENGINE, POWER TRAIN
GDI engine carbon buildup causing very high gas consumption and damage . Should carbon buildup break free it will cause engine falure resulting in engine seizure while at speed. Loss if property and life imment. Only soulition is disassembly to remove buildup. Another failure is corrosion on shift cable causing gear falure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665245June 6, 2025
STEERING
The steering started to fail and would be hard to steer while driving.I then looked further online and found that a recall was issued for the steering column and how dangerous it was to continue driving the vehicle for the cross as stated in the recall could seperate and one could lose steering and cause a crash so we; my wife and I managed to get the car safely to the dealer for further diagnostic only to find out that although a recall was issued for the steering problem. Our vin was not included and we had to pay for the repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664737June 3, 2025
STEERING
Sometimes this condition hardly noticable and other times very stiff then move steering wheel slightly and full assist. Seems more prevalent after driving 1/2 hour or more on expressway steering becomes stiff and ratchety. This causes steering to stick whenever driving at highway then driver is putting more effort to overcome stuck wheel. When breaks loose vehicle goes to far in that direction then sticks again causing to stick again and over corrects other direction. This goes from annoying and uncomfortable to just plain dangerous depending on conditions speed weather and proximity to other vehicles or obstacles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660816May 14, 2025
ENGINE
Engine burns and eats up lots of engine oil. Engine oil is always low.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657908April 30, 2025
STRUCTURE:BODY
2018 Kia Sorento. Snow White Pearl paint started delaminating at about 45,000 miles. Now it has 51,000 miles and I have multiple spots where it is delaminating on the hood, front bumper, and fender. Also, where the paint is delaminating I am also starting to see small chips on the paint below since the clear coat is gone. I cant believe my car paint is having issues and it only has 51,000 miles on it. It has been stored in a garage for the life of the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento