Hyundai Santa Fe Complaints (2001)

209 consumer complaints on file.

#10244752October 8, 2008
SUSPENSION:REAR
AS MY WIFE WAS BACKING UP THE 2001 SANTA FE SUV AT A LOCAL PARK, SHE HEARD A LOUD THUMP. SHE THOUGHT SHE WENT OVER A POTHOLE, AND GOT OUT OF THE CAR TO LOOK. SHE DIDN'T SEE A POTHOLE, AND GOT BACK INTO THE CAR. AS SHE DROVE DOWN THE ROAD, A RHYTHMIC SCREECH BECAME VERY LOUD FROM THE RIGHT REAR SIDE. SHE STOPPED THE CAR, AND AGAIN GOT OUT TO TAKE A LOOK. THE RIGHT REAR TIRE LOOKED NORMAL. SHE GOT BACK INTO THE CAR AND CONTINUED TO DRIVE HOME, SLOWLY. THE SCREECHING BECAME LOUDER AND LOUDER. WHEN SHE GOT HOME, SHE LOOKED AT THE RIGHT REAR TIRE AND WAS SHOCKED TO SEE THAT IT WAS CAVED INWARD, AND A METAL PART WAS BROKEN AND HANGING DOWN. THE CAR WAS NOT DRIVABLE IN THIS CONDITION, AND A TOW TRUCK HAD TO COME TO OUR HOME AND LOAD THE CAR ONTO A FLATBED TRUCK AND TAKE IT TO THE LOCAL HYUNDAI DEALER. THE HYUNDAI MECHANIC DISCOVERED THAT THE CENTER OF THE RIGHT REAR CONTROL ARM HAD FULLY RUSTED OUT AND THE SUSPENSION HAD BROKEN THROUGH. THE RIGHT REAR CONTROL ARM, THE LATERAL LINK, THE ABS SENSOR, CAM VOLT, AND NUT HAD TO BE REPLACED TO FIX THE PROBLEM. THE TOTAL COST WAS $1,549.22. THE DEALER TOLD ME THAT THIS WAS NOT COVERED UNDER THE WARRANTY OF THE CAR. I THOUGHT THIS WAS AN ISOLATED CASE. HOWEVER, AFTER DISCOVERING THERE WERE NUMEROUS CASES OF 2001 SANTA FE CONTROL ARMS RUSTING OUT, I DECIDED TO FILE AN NHTSA COMPLAINT. I AM VERY GRATEFUL THAT THIS DID NOT HAPPEN AS MY WIFE WAS DRIVING AT A HIGH SPEED ON THE TOLLWAY. IT IS MY OPINION THAT HYUNDAI SHOULD TAKE RESPONSIBILITY FOR THE POOR DESIGN OF THE CONTROL ARM. FURTHERMORE, IN THE PAST TWO WEEKS, I HAVE DISCOVERED THAT THE LEFT CONTROL ARM IS SHOWING THE SAME SIGNS OF RUST THAT CAUSED THE FAILURE OF THE RIGHT CONTROL ARM. IT WILL SOON NEED TO BE REPLACED, WHICH WILL BE EXPENSIVE. I FEEL IT SHOULD BE PART OF A SAFETY RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244898October 8, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IDLING AND AS THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE DRAMATICALLY ACCELERATED. THE RPM'S SURGED TO APPROXIMATELY 3,000. THE DEALER COULD NOT DUPLICATE THE FAILURE OR PROVIDE A SUFFICIENT REMEDY. AS OF OCTOBER 8, 2008, THE VEHICLE HAS NOT BEEN PROPERLY REPAIRED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242534September 17, 2008
SUSPENSION:REAR
MY DAUGHTER WAS PULLING OUT OF A PARKING LOT AND THE RIGHT REAR TRAILING ARM FAILED BECAUSE IT HAD RUSTED AND BROKE CAUSING THE REAR TIRE TO TURN OUT AND THERE WAS NO CONTROL OF THE VEHICLE, SHE JUST GOT OFF THE INTERSTATE RUNNING 70 MILES PER HOUR, THIS COULD HAVE HAD A REAL SAD OUT COME. WE ARE HAVING BOTH TRAILING ARMS REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241989September 12, 2008
STRUCTURE:FRAME AND MEMBERS
AFTER DRIVING OVER A POT HOLE THE VEHICLE CONTINUED TO PULL TO THE RIGHT AS IT WAS DRIVEN. THE NEXT DAY I TOOK IT TO A REPAIR SHOP FOR WHEEL ALIGNMENT. THE SHOP SAID THEY COULD NOT REPAIR IT AS THERE WAS A FIST SIZE HOLE IN THE FRAME WHERE IT HAD RUSTED THROUGH WHERE THE CONTROL ATTACHES TO THE FRAME. WHILE RESEARCHING THE INTERNET I LEARNED OF MANY SIMILAR DEFECTS REPORTED TO NHTSA I BELIEVE SOME HYUNDAI MODELS SHARE THE FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10237092August 5, 2008
STRUCTURE, SUSPENSION:REAR
MY 2001 SANTE FE WAS MAKING " CREAKING" NOISE BY THE PASSENGER SIDE REAR TIRE. I MADE AN APPOINTMENT FOR IT, BUT BEFORE THE APPOINTMENT I HEARD A LOUD THUD AND LOST CONTROL OF THE VEHICLE. FORTUNATELY I WAS ONLY GOING 35 MPH AND WAS ABLE TO SKID INTO A DRIVEWAY. THE REAR CONTROL ARM SNAPPED OFF DUE TO AN EXCESSIVE AMOUNT OF RUST. THE OTHER SIDE IS ALMOST RUSTED THROUGH. THE REPAIR SHOP HAD NEVER SEEN ANYTHING LIKE IT BEFORE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10236585July 31, 2008
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING AT 30MPH (2001 SANTA FE), I FELT A BIG JERK WHICH I NEVER FELT IT BEFORE WITH THIS CAR. AFTER THAT I MADE A RIGHT TURN AND MY CAR SUDDENLY STOPPED AND CHECK ENGINE LIGHT COMES ON. WHEN I RE-STARTED THE CAR, IT STARTED FINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10233333July 7, 2008
ENGINE AND ENGINE COOLING
CRANKSHAFT SENSOR FAILED ON MY 2001 4 CYLINDER HYUNDAI SANTA FE. THE CAR SUDDENLY STALLED AND WOULD NOT RESTART. I WAS DRIVING ON BUSY STREET IN THE WINTER EVENING AND, AT THE TIME, WAS ON CRUTCHES AND UNABLE TO NAVIGATE ON FOOT. I WAITED IN 20 DEGREE WEATHER FOR ABOUT 45 MINUTES UNTIL A POLICE PERSON RESCUED ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10229405May 31, 2008
SUSPENSION:REAR
RETURNING FROM 2 HOUR HIGHWAY TRIP, TURNED INTO DEVELOPMENT, HEARD LOUD SNAPPING NOISE. TOOK TO DEALER NEXT DAY, INFORMED DRIVER SIDE REAR CONTROL ARMS RUSTED THROUGH AND BROKEN, PASSENGER SIDE WELL ON WAY. AXLE WOULD ALSO NEED TO BE REPLACED. ONLY AXLE UNDER WARRANTY--HAD DEALER REPLACE SUCH. TOOK VEHICLE TO REGULAR GARAGE FOR REMAINDER OF REPAIRS. GARAGE EXTREMELY SURPRISED AT AMOUNT OF RUST CONTAINED IN REAR SUSPENSION----PAPER THIN. HAVE SAVED PARTS FOR ANYONE WISHING TO LOOK AT THEM. HAVE NOTED ON-GOING COMPLAINTS ABOUT 2001 HYUNDAI ELANTRAS WITH SAME PROBLEM--MUST BE A HYUNDAI ISSUE--AS MINE IS A SANTA FE. THIS IS A VERY DANGEROUS CONDITION AND COULD CAUSE MAJOR ACCIDENTS AND/OR DEATHS SHOULD CONTROL FAIL DURING NORMAL DRIVING CONDITIONS. WAS TOLD CONTROL ARM IS DEFECTIVE, AS THERE IS NO HOLES FOR ANY WATER/CONDENSATION TO DRAIN, THEREFORE WATER SITS AND RUSTS THEM OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225986April 28, 2008
SUSPENSION:REAR
VEHICLE: 2001 HYUNDAI SANTA FE I AM CONCERNED ABOUT THE SAFETY AND RELIABILITY OF A KEY SUSPENSION COMPONENT: THE RIGHT REAR BEARING ARM. THIS COMPONENT, WHICH ATTACHES THE RIGHT REAR WHEEL AXLE TO THE CHASSIS COMPLETELY FAILED DURING A DRIVE ON A SECONDARY ROAD AT SPEEDS UNDER 55 MPH ON APRIL 9, 2008. THE STEERING WHEEL JERKED TO THE RIGHT A QUARTER OF A TURN, AND THE VEHICLE ALMOST FLIPPED OVER. THE VEHICLE WAS TOWED. MY MECHANIC INFORMS ME THAT THIS COMPONENT SHOULD LAST THE LIFE OF THE VEHICLE. IN MY CASE, IT IS COMPLETELY CORRODED TO THE POINT WHERE IT COULD NO LONGER SUPPORT THE WEIGHT OF THE VEHICLE AND CAUSED A STRUCTURAL FAILURE. I HAVE OWNED MANY CARS, AND HAVE NEVER SEEN A WEIGHT BEARING SUSPENSION COMPONENT FAIL UNDER NORMAL DRIVING CONDITIONS. HAD THIS FAILURE HAPPENED ON THE FREEWAY, I AM SURE THE RIGHT REAR WHEEL WOULD HAVE COMPLETED DEPARTED THE VEHICLE RESULTING IN A COMPLETE LACK OF CONTROL AND PROBABLE DISASTER. WE CONSIDER OURSELVES VERY FORTUNATE THAT NO ONE WAS HURT. HOWEVER, THE DAMAGE TO THE CAR WAS EXPENSIVE. THE COST OF THE REPAIR WAS NEARLY $1,000. THE COST OF THE SUSPENSION COMPONENT ALONE WAS $567.79. I CONSIDER THIS FAILURE NOT A NORMAL CIRCUMSTANCE AND WOULD LIKE SOMEONE TO INSPECT THE PART AND VEHICLE FOR COMPLETE ANALYSIS. I HAVE THE OLD PART AS WELL AS DIGITAL PHOTOS OF THE FAILED COMPONENT FOR YOUR REVIEW AS WELL AS REPAIR DOCUMENTATION. I WOULD LIKE HYUNDAI TO COVER THE COST OF THIS EXPENSIVE REPAIR. IN MY OPINION, THIS COMPONENT SHOULD NEVER FAIL UNDER NORMAL DRIVING CONDITIONS AND CERTAINLY NEVER FAIL IN A VEHICLE THAT HAS NEVER BEEN INVOLVED IN AN ACCIDENT. THIS FAILURE HAS REALLY SHAKEN MY CONFIDENCE IN HYUNDAI'S DESIGN AND ENGINEERING QUALITY. IF WE HAD BEEN ON THE HIGHWAY, I AM CERTAIN THAT AN ACCIDENT WOULD HAVE BEEN INEVITABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10222673March 29, 2008
SUSPENSION:REAR
A-FRAME OF THE DRIVER SIDE REAR RUSTED THROUGH AND MY TIRE AND WHEEL FELL OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10215997January 25, 2008
SUSPENSION:REAR, STRUCTURE
FOR A FEW DAYS PRIOR TO THE INCIDENT, I THOUGHT I NEEDED TO HAVE THE BRAKES REPLACED ON THIS VEHICLE. EVERYTIME I APPLIED THE BRAKES, THE CAR WOULD SWERVE A LITTLE; THEN THERE WOULD BE A "THUMP" AT THE REAR OF THE CAR. ON THE DAY OF THE INCIDENT, THERE WAS A SIGNIFICANT NOISE AT THE REAR OF THE CAR, SO I LOOKED IN THE BACK STORAGE AREA THINKING SOMETHING WAS ROLLING AROUND-FOUND NOTHING. I CONTINUED DRIVING A FEW MILES, HEARING THE THUMPING NOISE AGAIN, I STOPPED AND LOOKED UNDERNEATH THE THE REAR OF THE VEHICLE THINKING THE SPARE TIRE BRACKET WAS BROKEN--SAW NOTHING. LATER IN THE DAY, AS I TURNED RIGHT THERE WAS A LOUD NOISE AT THE REAR. I TOLD MYSELF TO DRIVE SLOWLY--AND THEN THE RIGHT REAR TIRE BROKE CAUSING ME TO LOSE CONTROL OF THE CAR. FORTUNATELY FOR MYSELF, OTHER DRIVERS AND HYUNDAI I WAS DRIVING SLOW. THE CAR WAS FLATBEDDED TO THE HYUNDAI DEALER, WHO TOLD ME THAT THE REAR TRAILERING ARM "SNAPPED" OFF DUE TO AN IMPACT. THE SERVICE MANAGER STATED THAT HE HAD NEVER SEEN ANYTHING LIKE THAT AND WANTED TO WAIT FOR THE COMPANY REP BEFORE DECIDING WHAT TO DO. THE REP INSISTED THAT RUST HAD NOTHING TO DO WITH THE PART BREAKING AND THAT I NEEDED TO PAY 1100.00 FOR THE REPAIR (WHICH INCLUDED A NEW BRAKE LINE AND SHOCK DUE TO THE FAULTY PART) THE DEALERSHIP THEN DID NOT WANT TO GIVE ME THE PART BECAUSE IT WAS "TOO RUSTY" TO PUT IN THE CAR. THIS SEEMS TO BE THE 4TH VEHICLE REPORTING THE SAME PROBLEM. I DO HAVE THE PART AND WILL BE GOING TO THE LOCAL NEWS MEDIA TO COMPLAIN ABOUT THE SAFETY ISSUE NOT BEING ADDRESSED BY THE COMPANY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212087December 17, 2007
VEHICLE SPEED CONTROL
I WAS COMING TO A RED LIGHT AND LET OFF THE GAS TO COAST BEFORE PUTTING ON MY BRAKES(MY DAD TAUGHT ME WELL TO DO THIS INSTEAD OF BEING A QUICK BRAKER TO MAKE MY BRAKES LAST LONGER). AT ABOUT 25MPH MY CAR BEGAN TO ACCELERATE BACK UP TO 30, THEN 35, THEN 40. I PANICKED. I PRESSED THE BRAKES VERY HARD BUT THE RPM'S WERE STILL RISING AND I COULD HEAR THE ENGINE STILL ACCELERATING. I TRIED PUTTING IT INTO PARK, NO LUCK. I THEN TURNED THE CAR OFF WHILE IN PARK. SCARY!!!! MY KIDS WERE WITH ME. HAD I NOT BEEN ABLE TO STOP WE'D HAVE BEEN KILLED WHILE PLOWING INTO CROSS TRAFFIC TRAVELING AT 55MPH OR MORE! AFTER RESTARTING THE CAR, IT SEEMED BETTER. THEN 5 MILES DOWN THE ROAD IT DID IT AGAIN. I DROVE IT BACK HOME (8MILES) WITH NO INCIDENT. 2 DAYS LATER WHILE DRIVING MY SON HOME FROM SCHOOL, THIS EPISODE REPEATED 4 TIMES. WITH EACH "RESTART" IT BECAME MORE DIFFICULT TO START THE CAR AND I HAD TO WAIT (YES, IN TRAFFIC) 5 MINUTES BEFORE STARTING THE CAR AGAIN. I NEEDED TRANSMISSION WORK, TOOK IT IN, $2000 REBUILD. TOLD THEM ABOUT THE ISSUE AND THEY COULD FIND NOTHING BUT HOT MAYBE AFTER THE TRANSMISSION WORK WAS DONE IT WOULD RESOLVE. NOT A CHANCE. THEY ARE STUMPED AS TO WHAT'S WRONG. THEY'VE CHECKED THE THROTTLE BODY AND PARTS. NO CODES COME UP. THEY'VE UNHOOKED THE CRUISE CONTROL. MY HUSBAND DROVE IT HOME THIS PAST WEEKEND SO A FRIEND COULD LOOK AT IT AND SEE WHAT HE THOUGHT AND MY HUSBAND WAS DRIVING ON A LONG STRETCH OF ROAD WITH NO STOPS AND THE CAR WAS DRIVING AT 50MPH WITH HIM NOT PUSHING THE GAS PEDAL. HELP!!! THIS IS GOING TO HURT OR KILL SOMEBODY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10197266July 23, 2007
SUSPENSION:REAR
I WAS DRIVING MY 2001 HYUNDAI SANTE FE EASTBOUND ON INTERSTATE 275 IN WILDER KENTUCKY AT APPROXIMATELY 65 MILES PER HOUR AT APPROXIMATELY 10PM , WHEN I HEARD A POPPING SOUND AND SUDDENLY LOST CONTROL OF THE VEHICLE. MY WIFE AND TWO CHILDREN AGES 8 AND 11 WERE IN OUR SUV WITH ME. THE CAR SWERVED OVER THREE LANES OF TRAFFIC AND THE MEDIAN STRIP VEERING WILDLY FROM LANE TO LANE. THE VEHICLE ALMOST TIPPED OVER SEVERAL TIMES. FORTUNATELY, NO OTHER CARS WERE NEARBY AND I WAS ABLE TO BRING THE VEHICLE UNDER CONTROL. THE CAR WAS TOWED TO THE NEWPORT FIRESTONE STORE ON CAROTHERS ROAD. 859-491-1400. THE WHEEL WAS TURNED OUT APPROXIMATELY 10 DEGREES. THE SHOP FOUND THAT THE SUSPENSION TRAILING ARM HAD RUSTED THROUGH AND HAD ALMOST COMPLETELY SEPARATED INTO TWO PIECES. WE COULD EASILY HAVE BEEN KILLED OR SERIOUSLY INJURED. I SAVED THE PART. THE WHEEL WAS LITERALLY HANGING ON BY A THREAD. THE REPAIRS COSTS APPROXIMATELY $800. I CALLED HYUNDAI CUSTOMER SERVICE AND THEY WERE COMPLETELY UNRESPONSIVE. THIS IS NOT WHAT A CONSUMER WOULD EXPECT FROM A SIX YEAR OLD VEHICLE. I AM CONCERNED THAT OTHER CARS OUT THERE ARE TICKING TIME BOMBS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10195117July 2, 2007
SUSPENSION:REAR
TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD CRACKING SOUND COMING FROM THE PASSENGER SIDE REAR WHEEL. THE CONTACT LOST CONTROL OF THE VEHICLE AND BECAME WORSE WHEN HE DEPRESSED THE BRAKE PEDAL. THE VEHICLE BEGAN TO FISHTAIL, BUT GRADUALLY DECELERATED TO A COMPLETE STOP. THE CONTACT NOTICED THAT THE PASSENGER SIDE REAR WHEEL LOOKED AS IF IT WERE TURNED AT A 15 DEGREE ANGLE. THE VEHICLE WAS TOWED AND THE MECHANIC STATED THAT THE SUSPENSION TRAILING ARM WAS RUSTED AND CRACKED. THE CURRENT MILEAGE IS 103,000 AND FAILURE MILEAGE WAS 13,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10183537February 26, 2007
ELECTRICAL SYSTEM:STARTER ASSEMBLY
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTE FE. THE CHECK ENGINE LIGHTS ILLUMINATED AND THE VEHICLE WILL NOT SHIFT PROPERLY. WHILE DRIVING 55 MPH AND SHIFTING GEARS,THE GEAR STUCK FROM FOURTH TO THIRD GEAR. THE CONTACT TURNED THE VEHICLE OFF. THE VEHICLE OPERATED NORMALLY ONCE IT WAS RESTARTED. THE FAILURE USUALLY OCCURRED DURING RAINY OR DAMP CONDITIONS. THE DEALER INFORMED THE CONTACT THAT THE FAILURE WAS DUE TO A CRACKED CRANKSHAFT. THE VEHICLE WAS INSPECTED, AND THE CRANKSHAFT WAS REPLACED ON MARCH 30, 2004. AFTER THE CRANKSHAFT WAS REPLACED THERE WERE NO OCCURRENCES UNTIL MAY 2005 AND AUGUST 2005, WHEN THE COIL WAS REPLACED. THE VEHICLE OPERATED NORMALLY UNTIL NOVEMBER 2006. THE CURRENT AND FAILURE MILEAGE WAS 88,000.*AK THE CONSUMER HAS PROVIDED A RECALL FOR THE ELECTRICAL SYSTEM PERTAINING TO THE CRANKSHAFT POSITIONER AND INVOICES FOR THE REPAIRS. THE DEALER STATED THAT THE SPEED SENSOR HAS BEEN REPLACED. UPDATE 5/3/07*TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10175002December 2, 2006
SUSPENSION:REAR
TRAVELING ON THE HIGHWAY ABOUT 65 MILES PER HOUR THE VEHICLE SUDDENLY TURN TO THE RIGHT AND LUNGED DOWNWARD TO A POINT THE VEHICLE FELT AS IF IT WAS GOING TO FLIP OVER. I BROUGHT THE VEHICLE TO A REPAIR SHOP AND FOUND THE RIGHT REAR LOWER CONTROL ARM HAD RUSTED COMPLETELY THROUGH. I HAVE PICTURES OF THE PART IF NEEDED. WHEN THE REPAIR SHOP CALLED THE HYUNDAI PARTS DEPARTMENT THE PERSON ANSWERING THE PHONE SAID THIS TYPE OF PROBLEM WAS COMMON PROBLEM WITH SANTA FE SUVS. THAT NEXT THING THAT MADE ME THINK THIS WAS A PROBLEM THAT HYUNDAI WAS AWARE OF, WAS THAT THE REPLACEMENT PART HAD BE REDESIGNED AND NOW HAS WEEP HOLES SO NOT TO RETAIN WATER OR MOISTURE. THE REPAIR SHOP TESTED THE REMAINING CONTROL ARMS ON THE VEHICLE TO FIND THE LEFT REAR LOWER CONTROL ARM WAS ALMOST RUSTED THROUGH. THE REPAIR SHOP SAID THAT THIS VEHICLE HAS THE SAME DEGREE OF RUST ON THESE PARTS THAT A TEN YEAR OLD CAR WOULD HAVE. THIS VEHICLE IS ONLY SIX YEARS OLD AND HAS BEEN GARAGED DURING THIS TIME. HYUNDAI SEEMS TO BE AWARE OF THE DEFECT DUE TO THE REDESIGN OF THE PART IN QUESTION AND THAT HYUNDAI PARTS DEPARTMENT IS AWARE OF THE NUMBER OF FAILURES. IS HYUNDAI WAITING UNTIL THERE IS A SERIOUS INJURY OR A DEATH? *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171603October 23, 2006
ELECTRICAL SYSTEM:STARTER ASSEMBLY
DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. IT WAS MANEUVERED OFF THE ROAD AND TOWED TO THE DEALER WHO REPLACED THE CRANK SHAFT POSITION SENSOR. THERE WAS A NHTSA RECALL, # 03V030000, REGARDING THE ELECTRICAL SYSTEM; STARTER ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168622September 19, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH, A THUMPING NOISE WAS HEARD FROM THE FRONT OF THE VEHICLE. IT WAS DRIVEN TO THE DEALER WHO DETERMINED THE FRONT DRIVER SIDE LOWER BALL JOINT NEEDED TO BE REPLACED. THE PROBLEM REOCCURRED ON FOUR OTHER OCCASIONS AND THE LOWER BALL JOINT WAS REPLACED EACH TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166021August 19, 2006
ENGINE AND ENGINE COOLING:ENGINE, ELECTRICAL SYSTEM:12V/24V/48V BATTERY, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, VEHICLE SPEED CONTROL:LINKAGES, POWER TRAIN:MANUAL TRANSMISSION, EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SUSPENSION /CHECK ENGINE LIGHT /LOWER BALL JOINT: DEALER REPLACE @54,353 MILES, LOWER ARM IN 2004 AND 8/2006 REPLACEMENT IS NEEDED I HAVE TAKEN MY 2001 SANTA FE TO DEALER 8 PLUS TIMES FOR CHECK ENGINE LIGHT AND WAS TOLD FOUND TETHER ON GAS CAP NOT LETTING CAP CLOSE TIGHT ENOUGH /MOVED TETHER AND RAN EVAP TEST AND CHECK OUT OK . I WAS TOLD CAP LOOSE 8 PLUS TIMES THIS PROBLEM IS ON GOING. RETURN TO DEALER FOR JERK TRANSMISSION ISSUES I HAVE TO PUSH THE ACCELERATOR PEDAL TO THE FLOOR AND IT TAKES OFF SLOW AND ONCE GETS POWER THE CAR JERKS STARTS AS IF THE GEARS OR NOT SWITCHING OVER. DEALER SAID DO THE PRESSURE IN GAS CAP AND GAS CAP NOT CLOSED TIGHT ENOUGH EVAL TEST WAS DONE. BACK AT DEALER AFTER ROAD TRIP MY CAR WAS RUNNING AFTER BEGIN PARKED WITH A/C RUNNING AND I TURN CAR OFF AND CAR WOULD NOT START THOUGHT MAY BATTERY CHECK AND NO WATER WAS IN BATTERY I PUT WATER IN BATTERY AND LET CAR SIT FOR ABOUT HOUR AND CAR RESTARTED BACK AT DEALER EXPLAIN THIS ISSUE MY BATTERY WAS REPLACE I WAS TOLD FACTORY BATTERY WASN'T STRONG ENOUGH WAS FOR SANTA FE THIS IS 3RD BATTERY WITH IN FIVE YEARS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161110June 29, 2006
POWER TRAIN:CLUTCH ASSEMBLY
VEHICLE- HYUNDAI SANTA FE 2001 2.4L 58000 MILES SUDDEN CLUTCH FAILURE DUE TO EXCESSIVE SLIPPAGE CAUSED BY HYDRAULIC PROBLEM IN THE CLUTCH SLAVE CYLINDER. INTERNET RESEARCH INDICATES THIS IS A PERVASIVE PROBLEM WITH HYUNDAI CLUTCHES IN GENERAL. MANUFACTURER APPARENTLY IS IGNORING THE PROBLEM. IN EXCESS OF $2000 IN QUOTED REPAIRS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe