Hyundai Kona Complaints

964 consumer complaints on file.

#11700814November 21, 2025
UNKNOWN OR OTHER
While slowing down from highway speed during hot weather, the front passenger door suddenly became unlatched and partially opened. A warning alert sounded, and I had to pull the door closed. There were no prior warnings or symptoms, and the dealer has not been able to reproduce the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700360November 19, 2025
UNKNOWN OR OTHER, ENGINE
The component that failed was the connecting engine rod bearing. The engine is currently in the vehicle located at a hyundai dealership. The connecting engine rod bearing failure came after 1 or 2 engine miss-fires. The vehicle suffered poor performance, I was unable to start the car and properly accelerate the vehicle. The vehicle has exhibited poor acceleration/ jerk acceleration since purchase. However, this incident occurred immediately during initial startup in a parked position. The vehicle rode roughly upon initial observance of this engine miss fire which led us to deem the engine and car unsafe to use. The vehicle was initially towed to an independent service center where they identified the engine missfire code. The vehicle was then towed to our frequently used independent servicer where they said the problem related to low compression in the engine possibly something internal in the engine. Next we towed the vehicle to our preferred hyundai dealership. Hyundai confirmed the engine missfires and connecting rod bearing failure. A claim is in process with Hyundai to assess the vehicle further. The check engine light came on when the engine miss-fired initially. An earlier check engine light came on for a missfire earlier in the 2025 and earlier in 2022 and in 2023 which led to a catalytic converter replacement. While not certain, we think that low compression and poor engine performance has plagued the vehicle since purchase. The vehicle drive jerky(poor/delayed acceleration when pressing the gas) and had early catalytic converter issues prior to 50k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699982November 17, 2025
ELECTRICAL SYSTEM
the headlights in this model Kona keep burning out after 9 months or so. I have replaced them multiple times in the last 5 years on both left and right sides. I use glove to put in the bulbs and are very careful not to let my hands touch the bulb. I have never had this happen with any other car I have owned. I suspect an electrical system issue, or perhaps wiring, but that is speculation. I have not had this inspected by the dealership. The latest date of failure is listed below.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699974November 17, 2025
ENGINE
Engine light was on - I was told by Belmont Enterprise on Sept 17th to keep driving the vehicle even though it needed repairs immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699021November 12, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
The timing system was repaired in February 2025. After similar symptoms of vehicle stalling, the check engine light came on Found a software update that needed to be completed to determine if engine needed replaced. Dealership has refused for seven weeks to complete the entire job of the update which includes running a diagnostic of codes. Instead, they have been arguing that the timing system needs replaced and not providing the codes from the safety software update. Obviously there's a much deeper issue if the timing system keeps breaking down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698455November 9, 2025
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
My Kona N Line is not functioning well. Especially after driving for a longer period of time. About 60% of the time, upon letting go of my brake, the car jerks. Going from 0 - 5 mph is the worst. The car definitely hesitates many times. Again, it is when I have driven it for over 10 minutes. I took the car to a service department in El Monte, CA on 11/1. They cannot find the problem. They rode with me and it did not show at that time. They released the car to me. The Kona N has a recall but not my car, the Kona N Line. The recall is for the same problem. I am extremely frustrated. I have another appointment on Tuesday of this week to take to the Glendora service department. I don't know what to do. I am not one to complain but this is not safe. This is my fifth Hyundai. Nothing but good cars until now. Please advise. [XXX] [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698269November 7, 2025
UNKNOWN OR OTHER
I’ve been having issues that align with the Safety Recall 239 to repair a condition involving the Electric Power Control Unit ("EPCU"). I seem to be having by a coolant leak, my car is overheating, has stalled and has struggled to start. I started noticing something wasn’t right a couple of weeks ago but wasn’t sure what until more “symptoms” have occurred since and I found the recall information. My air conditioner also will stop blowing cool air when the over heating happens. No lights have come on my dash board alerting me of anything needing to be serviced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697786November 5, 2025
ENGINE, UNKNOWN OR OTHER
I have gotten a oil change over a month ago and my car is still running low on oil. Sometimes my car would shut off while I’m driving on the road with cars behind me. I have gotten my car oil topped off three different times since getting my oil change. It also makes a fan like noise as well. There’s no leak at all. It’s very bizarre.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696969November 1, 2025
ELECTRICAL SYSTEM
Hyundai has multiple complaints regarding Horn malfunction in the Hyundai Kona. I went to use my horn today to prevent an accident and found my horn does not work. I have checked my fuses and relays and neither are blown leading to the horn to be unable for use
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696653October 30, 2025
ELECTRICAL SYSTEM
Horn was going in and out of working for the first few months after purchase. Now the horn does not work at all. It is not the fuse. As seeing through other complaints this is a very common problem and should be on Hyundai to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695903October 27, 2025
ENGINE
Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695939October 27, 2025
ENGINE, POWER TRAIN
The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the vehicle shakes and stutters on the verge of shutting off. This happened twice on [XXX]. I experienced a full vehicle shut off on [XXX} while the vehicle was stationary, but shifted into drive . In August, the vehicle stuttered and shook before shutting off. I have reported three instances of this issue to my local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695711October 26, 2025
ENGINE, UNKNOWN OR OTHER
My Kona has been stalling/hesitating when accelerating. It has been happening for a little over a year. It got very bad and the check engine light came on. I had it towed to Hyundai dealership and they said it was the fuel injectors so I paid to have those replaced, they said my warranty didn’t cover it. Replacing the fuel injectors made the car drivable but it was still stalling/hesitating but Hyundai said it was working properly. So I took it home. I have been driving it and it just keeps stalling and hesitating more and more. It is stalling and hesitating and has lack of power when I try to accelerate. I am afraid one day I’ll stall in traffic and get hit or cause an accident. I have also just realized my Kona has been using excessive oil. I just had an oil change mid August and today had to add at least 3 quarts. Even when I had my oil changed, the shop said I barely had maybe a quart in there, when it was just changed in May. We do not see any oil leaking out from anywhere. I have no choice but to use it to get around and Hyundai said it was working properly. I have recently looked online and I seen a lot of other owners reported the same issues. I have contacted Hyundai but they say theres nothing they can do. I am not sure where to go from here.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695615October 25, 2025
ELECTRICAL SYSTEM
This is second time all electrical has gone dead in the car. First time I took car in for an update and now something is still draining the battery. I have read multiple posts online of this issue. The car has less than 5000 mile on it
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695177October 23, 2025
ELECTRICAL SYSTEM
I had the radiator replaced by the Ourisman Hyundai Laurel dealership on 10/1/25. Radiator replacement was under warranty. On 10/4/25car overheated while driving. I pulled the car over and called for a tow truck. Car was leaking lots of coolant. Brought it to service center at Ourisman Hyundai Laurel, they stated “the hose to the thermostat was not all the way on. Put hose on correctly no more leaking.” On 10/15/25 multiple lights came on the dashboard including the master warning light. Took car to Ourisman Hyundai Laurel again; received the car back, dealership stated “ TECH COULD NOT DUPLICATE THE LIGHTS POPPING ON DASHBOARD. UPON FURTHER DIAGNOSIS TECH FOUND THAT THERE WAS A CONNECTOR NOT GETTING THE PROPER CONTACT TO COIL NUMBER 1 TECH RECONNECTED THE CONNECTOR AND TEST DROVE THE VEHICLE FOR 5 MILES. NO CONCERNS PRESENT AT THIS TIME.” On 10/20 I brought the car in to Ourisman Hyundai Laurel again because Electronic Stability Control light as well as ABS warning light and several other warning lights came on multiple times. Ourisman Hyundai Laurel service technician said they could not duplicate the problem and there is nothing they can do. This is a safety issue because it concerns the electronic stability control and brakes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694303October 18, 2025
FUEL/PROPULSION SYSTEM
The fuel system appears to have a small leak from either a bad seal or a problem fuel line.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693601October 15, 2025
POWER TRAIN, UNKNOWN OR OTHER
The DCT(Dual Clutch Transmission) has always been an issue since I purchased the vehicle. Anytime I would be going at a slow pace in a drive-thru or traffic on the freeway the car would jolt and shake. I brought my car to a Hyundai dealership in 2021 at 36,000 miles and was told this was normal with the transmissions provided by Hyundai and there was no need to worry. Now, at 72,000 miles I was driving down CA-60 when my car transmission died. The car would not go when I was giving it gas and would make a whirring noise when trying to accelerate across the freeway until I could pull off to the shoulder. It was extremely dangerous and I could've been hit by someone especially a semi-truck as it was sudden and I was in the left hand lane. I've been bringing it to an independent mechanic for years and he always told me to wait until there's a recall as it's a faulty transmission however there has not been a recall for my car yet. The car is now in possession of a Hyundai dealership however I was told since my warranty has passed they are not claiming any responsibility but that their transmission is faulty. There was no warning lamps or messages in the car just the issue of jolting while at slow paces prior to the transmission dying.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693682October 15, 2025
ENGINE
The engine shut down when the car stops at a red light or stop sign. There are metal shavings in the oil due to issues with the pistons.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693239October 14, 2025
UNKNOWN OR OTHER
Car keeps stalling no matter what speed you're driving. Took the car to NTB and they said nothing is wrong with it. It continues to happen even in busy highways where someone almost ran into the back of me. Not safe to drive. Concerned as numerous forums suggest this is a problem with 2019-2021 Hyundai Konas.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692910October 12, 2025
ENGINE
Burning oil faster than normal
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Kona