GMC Savana Service Bulletins (2016)
1,277 manufacturer communications on file.
- December 14, 2015•Document ID: 10114968Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- PIP4864Q
- Date Added:
- August 15, 2017
- Manufacturer:
- GMC
SummaryThis Preliminary Information communication provides information to the technician about vehicles that may have "Exhaust Fluid Low", "Exhaust Fluid Empty - Refill Now", "Exhaust Fluid Range: XXX" or "Service Exhaust Fluid - See Owners Now" on the Driver Information Center. If the technician is working on 2010 and 2011 model years campaign 11001 has now been released. Other vehicles technician will need to check the Body Control Module and the scan tool to insure the latest calibration are installed in both. Then use the scan tool to check Reductant System Data in the Engine Control Module. Ensure that all three diesel exhaust fluid level sensors are active with the diesel exhaust fluid tank level showing 100%. If the tank level is below 100% add up to 2 gallons of diesel exhaust fluid. After adding the fluid, use a scan tool to reset the reductant fluid tank level. When the reductant level warning shows "none" the diesel exhaust fluid system reset and reprogram is complete.
Associated Products (26)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 6 moreAssociated Documents - December 9, 2015•Document ID: 10114954Service Bulletin/Repair InstructionsFUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY; FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
- Mfr Comm. #:
- PIT4943D
- Date Added:
- August 15, 2017
- Manufacturer:
- CADILLAC
SummaryThis Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review Techlink article from May 2013 titled "Using the Evaporative Emissions System Tester" Technician will need to follow these steps to help diagnose the issue. First after the P0442 has been verified do not disturb any of the fuel system components. The technician now can use the scan tool to close the Evaporative Emissions System. If possible change the tank pressure sensor units from inch_H2O to milimeter_Hg for better resolution. Now the vehicle can be stared to monitor the tank pressure sensor output value for approximately two minutes. If the tank pressure sensor value does change, pressurize the fuel tank side of the purge solenoid with the GE 41413-A / J 41413-A and the necessary adaptors. Now add smoke and allow pressure to stabilize for 2 minutes. If smoke is allowed to pass through the purge solenoid, replace the purge solenoid. If the tank pressure sensor value does not change, then install CH-48096 adaptor between the purge line from the canister and the purge solenoid. With the Evaporative Emissions System closed, pressurize the system through the CH-48096 adaptor and allow the system to completely stabilize, by observing the Press / Vac Gauge for a minimum of 5 minutes. Now add smoke to the system with GE 41413-A / J 41413-A after system stabilization. Now inspect the purge solenoid, engine side, fuel cap, canister vent solenoid filter and any line quick connects. When the leak is unable to be located, test under a vacuum condition. his type of leak may be detected by using the scan tool Purge/Seal function to create a vacuum in the Evaporative Emissions System and then observe the FTP sensor parameter for vacuum decay.
Associated Products (703)2016 Buick Cascada2016 Buick Enclave2016 Buick Encore2016 Buick Envision2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac Escalade2016 Cadillac Escalade ESV2016 Cadillac SRX2016 Cadillac XTS2016 Chevrolet Camaro2016 Chevrolet Caprice2016 Chevrolet City Express2016 Chevrolet Colorado2016 Chevrolet Corvette+ 683 moreAssociated Documents - December 1, 2015•Document ID: 10190510Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR:HANDLE:INTERIOR; STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR; LATCHES/LOCKS/LINKAGES:DOORS:LOCK
- Mfr Comm. #:
- 15-NA-076
- Date Added:
- April 20, 2021
- Manufacturer:
- GMC
SummarySome customers may comment that the side sliding door handle is broken or they are unable to lock the door using the key from outside of the vehicle. Affected door handles may fail due to an unintended durability issue and/or may not have proper clearance to an anti-theft shield that was added to the design for the 2016 model year. This improper clearance may prevent the normal function of turning the key cylinder from outside the vehicle.
Associated Products (2)Associated Documents - December 1, 2015•Document ID: 10190506Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
- Mfr Comm. #:
- 12-06-04-002E
- Date Added:
- April 20, 2021
- Manufacturer:
- GMC
SummaryInformation on Exhaust Fluid Range, Exhaust Fluid Quality Poor, Service Exhaust Fluid System or Service Emission System Driver Information Center Messages
Associated Products (28)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 8 moreAssociated Documents - December 1, 2015•Document ID: 10190504Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
- Mfr Comm. #:
- 07-08-49-020J
- Date Added:
- April 20, 2021
- Manufacturer:
- CHEVROLET
SummaryIPC Odometer Programming Method Quick Reference Guide Season Odometer Programming Methods in Use Today 1. IPC reprogramming and setup using the service programming system (SPS). 2. Odometer setup at the electronic service center (ESC) when using an exchange IPC/DIC. 3. Tech 2® The Tech 2 is used to set up a replacement BCM, which includes loading the odometer value that is displayed and stored in the IPC. A replacement IPC will display the previously stored vehicle odometer value, communicated from the BCM, after cycling the ignition or driving the vehicle. *The odometer programming is integrated as part of the BCM programming procedure. It is not a stand-alone event.
Associated Products (492)2016 Buick Enclave2016 Buick Encore2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac SRX2016 Cadillac XTS2016 Chevrolet Camaro2016 Chevrolet Colorado2016 Chevrolet Corvette2016 Chevrolet Cruze2016 Chevrolet Equinox2016 Chevrolet Express2016 Chevrolet Impala2016 Chevrolet Malibu2016 Chevrolet Silverado+ 472 moreAssociated Documents - December 1, 2015•Document ID: 10190503Service Bulletin/Repair InstructionsENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 06-00-89-031D
- Date Added:
- April 20, 2021
- Manufacturer:
- CHEVROLET
SummaryOEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Associated Products (598)2016 Buick Cascada2016 Buick Enclave2016 Buick Encore2016 Buick Envision2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac Escalade2016 Cadillac Escalade ESV2016 Cadillac SRX2016 Cadillac XT52016 Cadillac XTS2016 Chevrolet 35002016 Chevrolet Aveo2016 Chevrolet Camaro2016 Chevrolet Caprice+ 578 moreAssociated Documents - December 1, 2015•Document ID: 10190502Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- 02-06-01-022P
- Date Added:
- April 19, 2021
- Manufacturer:
- GMC
SummaryInformation on Diesel Engine Ticking Noise
Associated Products (54)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 34 moreAssociated Documents - December 1, 2015•Document ID: 10190381Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- 10-06-05-002B
- Date Added:
- April 20, 2021
- Manufacturer:
- CHEVROLET
SummaryCLEAN EXHAUST FILTER SEE OWNERS MANUAL NOW or CLEANING EXHAUST FILTER KEEP DRIVING UNTIL MESSAGE IS CLEARED Displayed on DIC, DTC P2463 May Be Set
Associated Products (39)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 19 moreAssociated Documents - December 1, 2015•Document ID: 10190380Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- 10-06-04-013C
- Date Added:
- April 20, 2021
- Manufacturer:
- GMC
SummaryInformation on Diesel Exhaust Fluid (DEF) Filling Instructions, Frozen Tank Status and General Information In operating temperatures of 15°F (−9°C) or less, customers may comment on an Exhaust Fluid Range message displaying on the DIC even though the DEF fluid has been filled. When the DEF is frozen, the level sensor cannot determine the fluid level in the tank. If this occurs the logic of the PCM will assume a default fluid level. The logic will use the calculated range based on DEF dosing history and the assumed fluid level. If there is a high learned dosing rate and the fluid has not thawed to where the pins of the level sensor can function, there is a possibility the Exhaust Fluid Range message can set with the range from approximately 1609 km (1000 mi) to less than 482 km (300 mi), even though the tank is known to have fluid or be full. This is an operating characteristic of the system. However to increase or eliminate the range message, once the range drops below 482 km (300 mi), the DEF tank should be refilled. This should allow refill detection to occur and turn off the range indicator. The operator must be sure not to overfill the DEF tank using the instructions provided in this bulletin or in the owners manual. When in frozen tank status, refill detections are not allowed until the warning strategy reaches the point at which the distance remaining is less than 482 km (300 mi). The refill detection is dependent on the DEF thawing enough that the level sensor pins can be read. A fully frozen tank can take almost an hour to detect a refill, after the vehicle is started. This condition should not be confused with the situation described in PIP4864: Low Or Speed Limited Diesel Exhaust Fluid Message (DEF) Will Not Reset.
Associated Products (27)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 7 moreAssociated Documents - December 1, 2015•Document ID: 10190379Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE); EQUIPMENT
- Mfr Comm. #:
- 08-06-04-003D
- Date Added:
- April 20, 2021
- Manufacturer:
- CHEVROLET
SummaryNew Tool Availability EN-48974 EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax® Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber
Associated Products (52)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 32 moreAssociated Documents - December 1, 2015•Document ID: 10201124Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:COOLING SYSTEM; STRUCTURE:BODY:HOOD; POWER TRAIN
- Mfr Comm. #:
- PI1164B
- Date Added:
- September 7, 2021
- Manufacturer:
- GMC
SummaryReduced Engine Power with Service engine message displayed and DTC P2263 Set
Associated Products (12)Associated Documents - December 1, 2015•Document ID: 10201113Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES:DOORS:LOCK; STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR
- Mfr Comm. #:
- 15-NA-076
- Date Added:
- September 7, 2021
- Manufacturer:
- CHEVROLET
SummarySide Sliding Door Handle Broken or Inability to Lock Door with Key from Outside Vehicle
Associated Products (2)Associated Documents - December 1, 2015•Document ID: 10201104Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 12-06-04-002E
- Date Added:
- September 7, 2021
- Manufacturer:
- CHEVROLET
SummaryInformation on Exhaust fluid range, exhaust fluid quality poor, service exhaust fluid system or service emission system driver information Center Messages
Associated Products (28)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 8 moreAssociated Documents - December 1, 2015•Document ID: 10201103Service Bulletin/Repair InstructionsEQUIPMENT; ENGINE
- Mfr Comm. #:
- 10-06-05-002B
- Date Added:
- September 7, 2021
- Manufacturer:
- CHEVROLET
SummaryClean Exhaust Filter see owners manual now or cleaning exhaust filter keep driving until message is cleared displayed on DIC, DTC P2463 May be set
Associated Products (40)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 20 moreAssociated Documents - December 1, 2015•Document ID: 10201100Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING; ENGINE
- Mfr Comm. #:
- 08-06-04-003D
- Date Added:
- September 7, 2021
- Manufacturer:
- GMC
SummaryNew Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber
Associated Products (52)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 32 moreAssociated Documents - December 1, 2015•Document ID: 10201099Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 07-08-49-020J
- Date Added:
- September 7, 2021
- Manufacturer:
- CHEVROLET
SummaryIPC Odometer Programming Method Quick Reference Guide
Associated Products (45)2016 Buick Cascada2016 Buick Enclave2016 Buick Encore2016 Buick Envision2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac Escalade2016 Cadillac Escalade ESV2016 Cadillac SRX2016 Cadillac XT52016 Cadillac XTS2016 Chevrolet 35002016 Chevrolet 45002016 Chevrolet Aveo2016 Chevrolet Camaro+ 25 moreAssociated Documents - December 1, 2015•Document ID: 10201098Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN; ENGINE
- Mfr Comm. #:
- 06-00-89-031D
- Date Added:
- September 7, 2021
- Manufacturer:
- SATURN
SummaryOEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Associated Products (701)2016 Buick Cascada2016 Buick Enclave2016 Buick Encore2016 Buick Envision2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac Escalade2016 Cadillac Escalade ESV2016 Cadillac SRX2016 Cadillac XT52016 Cadillac XTS2016 Chevrolet 35002016 Chevrolet 45002016 Chevrolet Aveo2016 Chevrolet Camaro+ 681 moreAssociated Documents - December 1, 2015•Document ID: 10201097Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE
- Mfr Comm. #:
- 02-06-01-022P
- Date Added:
- September 7, 2021
- Manufacturer:
- CHEVROLET
SummaryInformation on Diesel Engine Ticking Noise
Associated Products (53)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra2011 Chevrolet Express+ 33 moreAssociated Documents - December 1, 2015•Document ID: 10246600Service Bulletin/Repair InstructionsAIR BAGS
- Mfr Comm. #:
- 120604002E
- Date Added:
- December 11, 2023
- Manufacturer:
- GMC
SummaryInformation on Exhaust Fluid Range, Exhaust Fluid Quality Poor, Service Exhaust Fluid System or Service Emission System Driver Information Center Messages
Associated Products (28)2016 Chevrolet Express2016 Chevrolet Silverado2016 GMC Savana2016 GMC Sierra2015 Chevrolet Express2015 Chevrolet Silverado2015 GMC Savana2015 GMC Sierra2014 Chevrolet Express2014 Chevrolet Silverado2014 GMC Savana2014 GMC Sierra2013 Chevrolet Express2013 Chevrolet Silverado2013 GMC Savana2013 GMC Sierra2012 Chevrolet Express2012 Chevrolet Silverado2012 GMC Savana2012 GMC Sierra+ 8 moreAssociated Documents - November 30, 2015•Document ID: 10137258Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 15-NA-069
- Date Added:
- May 21, 2018
- Manufacturer:
- CHEVROLET
SummaryThis informational bulletin provides information for technicians on the reuse of fasteners and the proper reading of torque specifications.
Associated Products (355)2016 Buick Cascada2016 Buick Enclave2016 Buick Encore2016 Buick Envision2016 Buick LaCrosse2016 Buick Regal2016 Buick Verano2016 Cadillac ATS2016 Cadillac CT62016 Cadillac CTS2016 Cadillac ELR2016 Cadillac Escalade2016 Cadillac Escalade ESV2016 Cadillac SRX2016 Cadillac XTS2016 Chevrolet 35002016 Chevrolet Camaro2016 Chevrolet Caprice2016 Chevrolet City Express2016 Chevrolet Colorado+ 335 moreAssociated Documents