Ford Ranger Complaints

278 consumer complaints on file.

#11654964April 16, 2025
VISIBILITY/WIPER
2024 Ranger Raptor built in December of 2024 with 1,750 miles on it. The rubber trim around the sliding rear window appears to have melted from the in glass defroster overheating. It is now duct taped to keep water from leaking into the cab.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653397April 8, 2025
ELECTRICAL SYSTEM, POWER TRAIN
1. The vehicle will sometimes randomly switch between drive modes with no influence from the driver. I believe it could be a faulty drive mode sensor and the vehicle is available to be inspected. 2. Having the vehicle switch drive modes at random could cause an increase in danger while driving. Going from Normal to Baja or other modes while at highway speeds is very concerning, considering it changes from 2-wheel to 4-wheel drive. 3. No. 4. No, the vehicle will be taken to a Ford dealership soon for the current window recall. 5. No prior warnings. The first couple of times, I thought I may have bumped it, but on multiple occasions I have realized it did it by itself with no influence from the operator. 6. For the additional details below: I put in the most recent incident, but it has occurred multiple times over the past year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653091April 7, 2025
SUSPENSION
Right rear leaf spring was found to be broken on vehicle 2ith 70,000 miles by Ford technician during oil change. I was informed that it was not a recalled defect, repair part was on back order and was not advised as to the safety of driving the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652847April 4, 2025
POWER TRAIN
The contact owns a 2024 Ford Ranger. The contact stated that while attempting to leave a parking lot while on an incline, the transmission was shifted into drive(D); however, the vehicle began to slowly reverse. The contact quickly proceeded to depress the brake pedal and shift back to park(P). There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that there was no failure found with the vehicle. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V164000 (POWER TRAIN); as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651300March 28, 2025
POWER TRAIN
The contact owns a 2023 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle inadvertently decelerated to 40 MPH, and the vehicle then shifted into 4WD-Low independently. As a result of the failure, the vehicle dramatically decelerated and skidded to a complete stop. The 4WD warning light was illuminated. The vehicle was taken to the dealer, who observed water damage to the fuse box which caused electrical failures. The contact was informed that the fuse box needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650060March 24, 2025
UNKNOWN OR OTHER
Approximately 32,000 miles. During that. I've had approximately 10 occasions where I've lost throttle power. It's happened while in turns and inclines. You lose all throttle response for 3 to 5 seconds. Been close to very dangerous a few times because of people behind me when I lost throttle and power. Other issue In both 2024 rangers we own. On curvy roads. The steering wheel starts sticking it will not reset back to center. This is one going into turns to the left and trying to go back to center. You have to use a lot of pressure to get it back to center like it's binding. Again this is happening in both our 2024 rangers starting around 7,000 mi on both. Only one has experienced the loss of power so far. I'm seeing a lot of complaints from other owners of the exact same lost power on forums
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648889March 17, 2025
SERVICE BRAKES
Air vent under steering wheel does not provide proper clearance for brake applications. Foot gets tangled/caught on vent. Had a few close calls during emergency situations. Problem gets worse with thicker sole shoes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648759March 17, 2025
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
It started moth my vehicle losing power and chugging , dealership diagnosed as transmission (10 speed ). After all of the Ford appointed tasks to fix said problem, valves were replaced , did not work then entire transmission was replaced . After 7 times in the shop and many missed work hours . Maybe 2 weeks later truck starts bucking as I enter the highway , was close to getting rear ended . Brought vehicle to dealership 2 weeks later diagnosed with the turbo going out in it . And then Friday 3/14 driving home from work the check engine light comes on. Says emission issues ? Also says need to service engine soon . Dealership says it is fine to drive they will call me when they can figure it out ? My vehicle ha less than 25k miles these issues started when I had 17k on it Started 8/5/24
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648697March 17, 2025
AIR BAGS
There used to be no sufficient clearance between the drivers knee airbag and the brake pedal. I wear steel toe boots for work and my foot just barely fits between the brake pedal and the airbag box. Several times it’s gotten hung up and I had trouble getting to the brake. In a panic situation the could be disastrous. I’ve checked in other model trucks and there is plenty of clearance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648482March 15, 2025
STEERING, LANE DEPARTURE: ASSIST, ELECTRICAL SYSTEM
I flew down to Anchorage Alaska this brand new 024 FORD RANGER XL on [XXX] sight unseen and no test drive from KENDALL FORD Dealership. After buying the truck I started it, engaged 4 wheel drive and slippery/ icy setting. On the way back to Fairbanks the steering was hard to turn and got progressively harder the faster I drove and the colder it became. About half way home it became exhausting to steer requiring a lot of force to turn the steering wheel that actually resisted with real force being turned. I didn’t know the lane keeping would turn on with the cruise control but it did and resisted me even more. The roads became black ice and it was freezing rain. The phone charge port lost power, the dash blanked out, there was no radio and the rear power port I had switched to lost power and my phone died. I was driving about 30 to 40 mph on the 2 lane undivided snow covered black ice covered highway. In a curve in the road where the highway maintenance snow plows had stopped plowing I believe the truck mistook the snow line for the painted line and unexpectedly and surprisingly actually turned the steering wheel towards the double solid dividing centerline and I turned back into my lane. This slight movement caused the truck to totally slide out of control and cross the double solid dividing centerline and the truck went into opposite highway oncoming lane! Luckily there was no traffic coming the other way or it could have been a horrible accident. I hit the brakes and the truck actually stopped good, and then I got back into my lane and pulled over at the first chance. My phone was dead so I had no flashlight because I flew down I carried nothing but my coat. I tried to inspect the steering but it was all dark and below zero so I continued on towards Fairbanks another hundred miles to the North. The truck also had a bunch of other problems like refusing to start that can leave a person to freeze to death quickly in the Arctic below zero temperatures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11647966March 12, 2025
STRUCTURE:BODY
[XXX] [XXX] [XXX] [XXX] 3/12/2025 National Highway Traffic Safety Administration 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Complaint Regarding 2024 Ford Ranger Raptor VIN [XXX] Dear NHTSA Team, I am writing to formally report a safety issue with my 2024 Ford Ranger Raptor, VIN [XXX] . After purchasing this vehicle, I encountered a significant problem that I believe poses safety concerns. Recently, I learned that Ford has developed a solution for this issue, as detailed in the following press release: WSAV Press Release. However, Ford is unwilling to cover the necessary repairs under warranty, despite the fact that this solution became available shortly after my purchase. I believe that this situation requires your attention, as it not only impacts my vehicle but may affect other owners of the same model. I urge the NHTSA to investigate this matter to ensure that safety standards are upheld and that consumers are treated fairly. Thank you for your attention to this important issue. I look forward to your response. Link #1: [XXX] #2: [XXX] Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644977February 26, 2025
POWER TRAIN, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, BACK OVER PREVENTION: WARNINGS
2021 Ford Ranger Transmission slipping during driving . causes vehicle to jerk during shifting in gear 3, 4, 7, which causes the vehicle to jerk also during down shifting it shifts very hard. i looked online and apparently ford will not issue a recall because they will lose money on all the repairs they must do. if they changed the rings in the 2022 transmission they are aware of the issue obviously but refuse to address the problem. for us 2021 owners we are fucked. 9000$ repair for us.
Crash:
Yes
Fire:
Yes
Injuries:
0
Deaths:
0
#11644616February 24, 2025
POWER TRAIN
When stopped or turning from a stop I will lose acceleration for 3-4 seconds at such time I will almost over accelerate when it does catch which I almost will lose control especially in icy weather. I have no codes have taken to dealership for repairs 4 times they can't find any issues. The issues appeared day 1 asked them to look at it they said it was fine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644040February 21, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
Not sure if this is the correct channel, but here goes my concern. The safety incident has not yet occurred, but the manufacturer has stated it could/may occur if a certain fix is not performed, but are unwilling to issue a recall for said fix, or even produce the parts they say are necessary to implement the fix. I own a 2024 Ford Ranger Raptor that Ford has demonstrated has a design flaw in their bed (for vehicles produced before mid Sept, 2024) in that it cannot carry more than 88 lbs on the bed rails without the potential for failure. I need to install a topper to protect and secure cargo in the bed which will exceed the 88 lb failure number they state. The fix they say must be implemented is to install 2 Ford supplied load box reinforcement brackets (called J-braces), yet I've been trying to order/obtain said braces for almost 5 months now without success. Ford seems to have given up on producing them as they've been "out of stock" since I purchased my vehicle, and Ford has cancelled my order for them twice now, when I try to submit an order. If the bed fails due to weight above 88 lbs put on the rails while driving, depending on what a failure looks like, it could cause collisions with the affected vehicle, or with other traffic in the vicinity. Ford has been completely unresponsive in issuing a recall so far regarding this known design flaw, yet they redesigned the suspect area mid year to fix the issue on vehicles produced after mid-Sept and going forward. Yet they are leaving purchasers of vehicles prior to this time, in a precarious position as they have potential safety concerns that Ford is unwilling to address, or even provide a solution for.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639523January 30, 2025
POWER TRAIN
Everyone that I have talked to that owns a 2021 Ford Ranger have transmission issues including me. Clunking/ jumping/ and very harsh shifting..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638904January 27, 2025
POWER TRAIN
in normal drive mode the transmission downs shifts thru the gears and skips from 3 to 1. becuase of that skip it feels like you got rear ended by another car. if your not prepared for it you could let off the brakes which could cuase you to hit the person in front. in sport mode it downshifts thru all the 10 gears properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11637974January 23, 2025
POWER TRAIN
Transmission failed at 65000 miles on a one owner vehicle. Conveniently just after the warranty expired. Cost to fix transmission $9000.00. Those transmissions are faulty and many people are experiencing problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11637069January 20, 2025
POWER TRAIN
While driving the vehicle started to act like it could not find a its gears in the transmission and made a loud clunk then stopped moving attempted to put it in reverse and it sook a minute before it shifted and made another loud clunk then lost both forward and reverse. Currently at ford getting a new transmission. Vehicle stopped moving while driving and hard to get off the road, No warning lights came on in the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635975January 14, 2025
WHEELS
It wearing tires on the inside quicker the it should. The dealer aligned and said it was with in specs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635292January 10, 2025
UNKNOWN OR OTHER
The wrap material on the front driver side and passenger inside door handles is separating and is very sharp. I noticed it a couple of days ago when I went to get out of the vehicle and I reached to open the door, and it sliced open my finger. I told my passenger what had happened, and he checked the passenger side inside door handle, and he said that his was the same way.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0

← Back to Ford Ranger