Ford Maverick Complaints (2022)

149 consumer complaints on file.

#11611280August 27, 2024
POWER TRAIN
Both front cv axles failed at 55,000 miles causing shake while accelerating
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610303August 22, 2024
POWER TRAIN
Front CV axles causing Intense vibration through out front suspension/drivetrain
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606275August 3, 2024
TIRES
I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605064July 29, 2024
SERVICE BRAKES
The rear brakes and rotors have prematurely worn out at only 28k miles, while the front brakes are like new. There is no way for me or any local repair shop to put it into brake service mode. The official Ford procedure does not work. NHTSA issued SSM 51217 acknowledging the issue, but the only solution is only to take it to a Ford dealer to do a simple procedure such as changing rear brake pads. This solution is unacceptable and causes an undue burden upon the customer in time and money for a known manufacturing defect. My closest dealer is 1 hour away. It can not pass my state safety inspection without this being done. Ford should be issuing a recall to address this defect, not simply driving people to the dealer network for basic safety maintenance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597824June 30, 2024
UNKNOWN OR OTHER, STRUCTURE:BODY
In October 2023, we took our 2022 Ford Maverick to a local Ford dealership for a front airbag recall. However, after we picked up our Maverick and we got home we noticed a deep scratch across the top of the dash and the tool from the technician in the console. We contacted the dealership about this scratch. Our Maverick was taken to the dealership in January 2024 for this repair. Upon the completion of installing the dash, the technician scratched the outside of the driver’s side front door causing yet another delay. The Maverick was then taken to their body shop (on premises) to repair the scratch and repaint the door. Within a week of having our Maverick back, we started smelling a very foul odor in the truck. This smell made my throat and nose burn and was nauseating while riding in the truck even with the windows down. We went back to the dealership to meet with the owner about this odor. They removed the seats, carpet, and dash to locate the problem. They discovered a place at the bottom of the windshield that had not been sealed from the manufacturing production department. They discovered black mold in the insulation behind the dash near the firewall and under the carpet. They have discussed this with Ford Motor Company on how to handle this problem. Currently our Maverick is still on the lot at the local dealership, since the first week of April 2024. We have reservations about the mold/mildew odor as a health/breathing issue to continue driving this vehicle. Ford Motor Company has been attempting to come to some agreement of handling this situation but not addressing the odor in the vehicle. After some online research of the 2022/23 Ford Mavericks this seems to be a bigger issue across the nation. There are not any recalls to correct this problem for water intrusion into the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597340June 27, 2024
EXTERIOR LIGHTING, UNKNOWN OR OTHER
I’ve been noticing a frequent issue with my trailer not having the left blinker work per notification it gives. So I gave been checking the information screen for trailer lighting any time that I’m pulling a trailer just to make sure all of my lights are working. Today, the truck told me all lights were on and working with the trailer. Meanwhile, after getting pulled over and explaining the info the truck is giving and then unplugging and replugging the trailer from the truck to prove that the lights do in fact work I was finally dismissed from the traffic stop. So the truck was telling me that all lights are on and working on the trailer… meanwhile there wasn’t a single light on!!! The issue with the left turn signal light not blinking on a trailer is relative to the truck as well since it only does it on the truck and with a multitude of different trailers/magnetic trailer lights.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596839June 26, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2022 Ford Maverick. The contact stated while driving 35 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the message “Engine Power Reduced” was displayed. Additionally, the contact stated that the “BRAKE” warning light illuminated; however, due to the failure the computer system generated the failure code in error. The vehicle was taken to the dealer where it was diagnosed as a fractured well in the braking system. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was informed that the parts needed to be ordered to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. The VIN was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596012June 23, 2024
STRUCTURE:BODY
In early April 2023 I opened my driver’s side door and the inside of my 2022 Ford Maverick was wet from the headliner down to the carpets. There WAS condensation throughout the interior of the vehicle even though the Repair Order stated there was none. The inside of the vehicle was damp. All windows were closed tightly. The headliner, back seat, front seat, carpets, and all the interior was damp. I had a book on my back seat that was damp and the pages were curled. There was MOLD underneath the floor mats. I contacted a MOLD specialist who stated that it is impossible to effectively rid a vehicle of MOLD. He stated that MOLD spores are in every crevice of the truck and it WILL return. On April 6, 2023 I took the truck to The Ford Store where I purchased it. There was 1294 miles on the odometer. They could not find the leak. My vehicle was there for several weeks and the interior was completely torn down from the headliner to the carpets. The Service Department finally said that they located the leak area and repaired it. The dealer guaranteed in writing that the MOLD was gone. On June 23, 2024 (today) I was getting ready to take the truck back to The Ford Store for tomorrow’s appointment. They will be addressing the three recalls. I just noticed MOLD under the mats again. The MOLD is on the floor board and is crawling up the footwells under the rubber mats. There is also MOLD on some of the plastic material close to the floor boards. My health and the health of all passengers who have ridden in my vehicle for the last 14 months have been and continue to be at risk. I have been contacted by other Ford Maverick owners who have experienced the same issue. The Ford Maverick Truck Club has many posts about leaks and subsequent MOLD issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595099June 18, 2024
SEAT BELTS, AIR BAGS
On Thursday (June 13, 2024) my truck displayed a fault that states Rear Belt Monitor Fault Service Required, at the same time my air bag light came on. I proceeded to work and found a lot of people have had this issue with their Ford Mavericks but have all said it is actually their drivers seatbelt with the issue. My husband thought he would test it to see and while driving he took his seatbelt off, the airbag light and fault went away but also even driving at highway speeds it never told us the seatbelt was off. When he plugged the seatbelt back in my truck indicated that seatbelt 3 was actually plugged in and the fault and airbag light came back on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593808June 12, 2024
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
I was driving on the freeway driving eastbound on 152 and I switch to the fast lane to pass a vehicle and the throttle stopped working, the truck lost speed and the truck turned off, a message popped on the screen saying that I needed to put it in park. I put it in park put the hazards on and attempt to restart it and it would crank but wouldn’t start. I did this until the allowed amount of times reached its limit. I attempted to put the gear in neutral but the knob was stuck. The truck was at a slight angle as I was going uphill and couldn’t get it to move. I find the release lever to make it neutral and it didn’t work but now that lever got stuck all this is going on while the traffic is at is heaviest. The truck stalled until 2 hrs later when a tow truck came to pick it up. I got dropped off at a safe location and the truck turned on and would shift into gear but it sounded bad. Info screen says something about not being able to park and the key is stuck on the truck still.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591381May 29, 2024
POWER TRAIN
My vehicle sits at about 26k miles currently. I experienced extreme shaking coming from under the vehicle under acceleration. The issue happened while going up a hill with my whole family. I had to pull over to inspect the issue as it felt like a wheel was coming off. Upon visual inspection both CV Joints were leaking grease all over the undercarriage of my vehicle. A screeching grinding and clunking noise was heard as I continued to drive. This noise went away shortly after, however the shaking upon acceleration continued. It's important to note that I do not take my vehicle off road and is mostly driven on paved roads to and from work and has never been overloaded in anyway. After I took the vehicle to the Dealership, they confirmed that both half shafts were failing and were disintegrating. The passenger side bad enough that it had expelled most of the grease. Continued use would have led to complete failure and could've resulted in an accident. On a vehicle with under 26k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11587075May 5, 2024
POWER TRAIN, VEHICLE SPEED CONTROL, BACK OVER PREVENTION: WARNINGS
driving down I 90 at 65 mph, powertrain/ power malfunction light came on and power was reduced to 20 mph. Very dangerous . This happened at least 4 times until I was able to return home. shut truck off and would go until the warning light came back on. contacting dealer tomorrow
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585022April 24, 2024
ENGINE
The contact owns a 2022 Ford Maverick. The contact stated that for two years from the end of November to April, he observed a burning odor in the cabin of the vehicle, that caused him to have a headaches and stomach aches. The vehicle was taken to a dealer on multiple occasions where the failure was not able to be replicated. The vehicle was then taken to a different dealer where it was diagnosed that the blower motor resistor needed to be replaced. The vehicle was repaired but the failure persisted. The contact believed that the failure was associated with NHTSA Campaign Number: 23V380000 (Engine). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 3,975.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577275March 14, 2024
EXTERIOR LIGHTING:TURN SIGNAL, ENGINE, FIRERELATED
See attached document for complaint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573213February 21, 2024
STRUCTURE:BODY
My truck started collecting water in the front passenger side floor. Took it to the dealer and they couldn’t find the leak at first. Then they claim it was coming from the window seal on the back passenger window. I refused to have it repaired for 950$. 600 dollars in now with leaky rear window. This has already started a mold issue under the carpet. This needs to be addressed by the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571348February 11, 2024
SEAT BELTS, SEATS
What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568976January 31, 2024
UNKNOWN OR OTHER
Manufacturing defect on the cowl deflector seal causes water to leak into the cabin and pool up on the floor of the passenger side front seat. Significant amount of water. This will result in damage to the carpets, mold issues (health and safety concern) along with possible damage to the electronics that is passes through right under and behind the glove box. Also passes through the cabin air filter box. Many Maverick owners have reported this problem in various internet forums, and yet there has not been a recall. I had to pay the local dealer to reseal this area with silicone due to a faulty design. Ford would not cover the expense. The dealer wanted $900 to dry the carpet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567187January 23, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565143January 12, 2024
POWER TRAIN
Had front half shafts replaced under warranty at 12k miles. Currently at 22k miles and experiencing the same vibration/shudder at about 50mph. Vehicle is available for inspection upon request. Failure of a half shaft could leave the vehicle stranded or could cause loss of control. Problem was already confirmed by dealership and half shafts were replaced. Problem is presenting itself again 10k miles later. Problem is well known with other owners. No warning lamps.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563638January 4, 2024
ENGINE, FUEL/PROPULSION SYSTEM
I bought a 2022 Maverick on 12 JAN 2022. The car broke down on the highway six months after (23 JUL 2022). Ford service department claimed it was a fuel injector issue and by replacing the part, the truck should be as good as new. Fast forward to Sat 30 DEC 2023 and the truck breaks down on the highway again with the engine light flashing. Ford service department informed me that the engine has to be replaced because several parts are broken/shattered and they do not know how. I am inclined to believe that the issue was never fixed to begin with and Ford put my safety and the lives of the people I care about at risk. I was sold a lemon with major engine issues and I am terrified of driving the truck again. All the service reports are currently at the dealership; I can acquire copies when needed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick