Ford · Model Report
Showing safety data for the 2003 model year only.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
TL* THE CONTACT OWNS A 2003 FORD F-550 SD. WHILE DRIVING UNKNOWN SPEEDS, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK DISINTEGRATED. THE FLOAT FILTER AND FILTER WERE CLOGGED. THE CONTACT CALLED A LOCAL DEALER (VISION FORD, 1500 S WHITE SANDS BLVD, ALAMOGORDO, NM 88310) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 107,550.
No injuries · No fire · No crash
WATTER SEPERATOR VALVE DUMPED FUEL ON THE TURBO CAUSING A FIRE.
I HAVE EXPERIENCED NUMEROUS ENGINE FAILURES, OF WHICH I HAVE THE RECEIPTS, ON MY F500 FORD WITH THE 6.0 DIESEL ENGINE, AT A COST TO ME OF OVER $7,000. AT THE TIME OF THE FAILURES, THE ENGINE WAS ONLY OUT OF WARRANTY FOR A SHORT PERIOD OF TIME. BECAUSE A DIESEL SHOULD LAST FOR A RELATIVELY LONG PERIOD OF TIME AND SHOULD NOT HAVE THESE TYPES OF PROBLEMS, I ASKED FORD TO COVER THE BILL. IN SHORT, FORD WOULD NOT GIVE ME THE TIME OF DAY OR ADMIT TO ANYTHING. I AM VERY CONCERNED AS I DON' T MAKE THE KIND OF MONEY IT TAKES TO CONTINUALLY INVEST IN AN ENGINE THAT SHOULD STILL RUN FINE. I HAVE ALSO DISCUSSED THIS WITH OTHERS THAT OWN THE SAME ENGINE AND HAVE FOUND THAT THE TYPE OF PROBLEMS THAT I'VE HAD ARE QUITE COMMON WITH THE 6.0 ENGINE. I HAVE ALL THE RECEIPTS AND EXPECT FORD TO TAKE RESPONSIBILITY FOR WHAT IS CLEARLY A POORLY BUILT ENGINE. I'M ALSO HAVING TROUBLE WITH THE AIR CONDITIONER FOR YEARS AND HAVE BEEN UNABLE TO FIND THE PROBLEM. I AWAIT YOUR REPLY AND CAN SEND YOU A COPY OF THE BILLS AND MY CORRESPONDENCE WITH FORD.
No injuries · No fire · No crash
NORCOLD CORP. ISSUED SAFETY RECALL # 10E-049 ON/ABOUT OCTOBER 21, 2010 FOR REFRIGERATOR UNITS IN RECREATIONAL VEHICLES FOR A POTENTIAL "FIRE" IN THE COOLING UNIT(S). A CERTIFIED RV DEALER CONFIRMED FIRE DAMAGE TO UNIT OWNED AND OPERATED BY COMPLAINANT . NORCOLD CORP. HAS REFUSED TO HONOR SAFETY RECALL(S) AND REPAIR SAID DAMAGED UNITS. THE FIRE WAS CONTAINED TO THE REFRIGERATOR UNIT ONLY HOWEVER ITS A TOTAL LOST. THERE ARE MILLIONS OF SIMILAR DEFECTIVE REFRIGERATOR UNITS BEING USED ON THE NATIONAL'S HIGHWAYS BY UNSUSPECTING RV OWNERS POSING A SERIOUS SAFETY AND HAZARDOUS POTENTIAL FOR A CATASTROPHIC EVENT THAT WILL ENDANGER THE TRAVELING PUBLIC. *TR
TL*THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH, THE VEHICLE STALLED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FUEL TANK INNER LINING WAS DE-LAMINATING AND BEING DRAWN INTO THE FUEL SYSTEM. AS A TEMPORARY REMEDY, THE CONTACT DECIDED TO DE-LAMINATE THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
No injuries · No fire · No crash