Ford F-250 Complaints (2012)

323 consumer complaints on file.

#11403898March 19, 2021
STEERING, SUSPENSION, WHEELS
THE DEATH WOBBLE MY F-250 TRUCK HAS BEEN HAVING A DEATH WOBBLE SINCE I BOUGHT IT ,I FIRST TOOK IT IN TO FORD SERVICE DEPARTMENT WITH 10,212 VEHICLE MILES ON THE TRUCK BECAUSE OF THE DEATH WOBBLE , AND HAVE TAKEN THE TRUCK SEVERAL TIMES FOR THE DEATH WOBBLE SINCE THEN . FORD MOTOR COMPANY HAS NEVER FIXED THIS PROBLEM , THEY ONLY MAKE MINOR CHANGES "BANDAID" TO THE TRUCK AND IT IS STILL NOT FIXED , THEY KEEP PUTTING ME OFF AND SAY THERE IS NO SOLUTION TO THIS PROBLEM. I HAVE SEVERAL PAGES OF SERVICE REPAIRS FORD HAS PERFORMED BUT THEY HAVE NEVER FIXED THE DEATH WOBBLE . MY FORD F-250 STILL HAS LOW MILEAGE BUT IS NOT SAFE TO DRIVE. MY FAMILY AND I HAVE CAME VERY CLOSE TO A ROLL OVER AT 70 MPH ON THE INTERSTATE FROM WHEN WE HIT A BUMP IN THE ROAD. EVERY TIME THE TRUCK ROLLS OVER A BUMP AT ANY SPEED ABOVE 20 MPH IT GOES INTO A WOBBLE AND BECOMES VERY HAZARDOUS AND SCARY. WE BOUGHT THIS F-250 KING RANCH TO DRIVE AND ENJOY ON VACATIONS AND OTHER FAMILY TRIPS , BUT AT THIS TIME MY FAMILY AND I DON'T FEEL SAFE RIDING IN IT, NOR HAVING IT ON THE ROAD WAYS IN FEAR OF IT BEING A DANGER TO US AND OTHER DRIVERS OR PEDESTRIANS. THIS F-250 GOES INTO A DEATH WOBBLE WHEN ENCOUNTERING A BUMP IN THE ROAD , ON PUBLIC COUNTY ROADS, CITY STREETS , STATE HIGHWAYS AND ESPECIALLY INTERSTATES AT HIGHWAY SPEEDS. I HAVE CONTACTED OUR LOCAL DEALER SEVERAL TIMES ON THIS ISSUE WHILE THE VEHICLE WAS UNDER WARRANTY. I HAVE CONTACTED FORD MOTOR CORPORATION ON THIS ISSUES AS WELL. YET NEITHER ONE OF THESE ENTITIES OF FORD MOTOR COMPANY HAVE ASSUME RESPONSIBILITY . REGARDS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11403942March 19, 2021
STEERING, SUSPENSION, WHEELS
MY LOCAL TIRE MAN DESCRIBED THIS AS A " DEATH WOBBLE" AND THAT IS AA GOOD DESCRIPTION. AS I DRIVE USUALLY AT 55 MPH THE TRUCK SUDDENLY STARTS TO SHAKE, NO PRIOR WARNING, SO HARD IT IS HARD TO HOLD ONTO THE STEERING WHEEL. O FAR I HAVE BEEN ABLE TO PULL OFF TO THE SIDE OF THE ROAD AND SLOW TO A STOP WITHOUT A WRECK. I CAN THEN PROCEED AS IF NOTHING HAS OCCURRED. THIS SEEMS TO BE GETTING MORE FREQUENT. AND MAKES ME NERVOUS WHEN I DRIVE.. I HAVE LEARNED FROM MY TIRE MAN THERE ARE OTHER OWNERS IN MY ARE HAVING THIS SAME PROBLEM WITH THEIR FORD TRUCKS. WE HAVE HAD FORDS SINCE THE '70'S AND NEVER HAD THIS PROBLEM WITH ANY OTHER ONE. I UNDERSTAND THERE IS A PART OR SOMETHING THAT CAN BE DONE TO FIX THIS PROBLEM; HOWEVER IT COSTS $400-$500 AND I THINK THIS IS SOMETHING THAT FORD SHOULD FIX, NOT THE OWNER, WHEN IT SEEMS TO BE A FORD PROBLEM.WHETHER IN DESIGN OR WHATEVER. I EVEN HAD A FORD SERVICEMAN TELL ME THAT THIS IS A PROBLEM SOMETIMES WITH FORD . THIS IS A FRIGHTENING THING AND I ABOUT HAD A HEART ATTACK THE FIRST TIME IT HAPPENED.. LUCKILY I WAS ALONE AND DIDN'T FRIGHTEN ANYONE ELSE. THIS HAS HAPPENED NUMEROUS TIMES FIRST IN 2014 . I WILL PUT THE LAST TIME IN THE SPACE BELOW AND I DID HAVE A FRIEND WITH ME THAT TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11402763March 13, 2021
STEERING, SUSPENSION, WHEELS
WHILE DRIVING AT APPROXIMATELY 75MPH ON AN INTERSTATE; AFTER HITTING A BUMP OR EXPANSION JOINT THE FRONT END WOBBLES UNCONTROLLABLY UNTIL THE SPEED IS REDUCED BY ABOUT HALF. I HAD A TRUSTED MECHANIC LOOK AT MY TRUCK AND HE SAID ALL FRONT END PARTS WERE IN GOOD CONDITION AND TIGHT. HE TALKED TO A DEALER WHO RECOMMENDED REPLACING THE STEERING DAMPER AS A CURE FOR THE "DEATH WOBBLE" ISSUE. I HAD THAT REPLACED AROUND THE FIRST OF FEBRUARY 2021. I HAD NOT DRIVEN THE TRUCK ON AN INTERSTATE AT SPEED SINCE THE REPLACEMENT UNTIL TUESDAY, MARCH 9, 2021. THE WOBBLE HAPPENED THREE SEPARATE TIMES WITHIN A SPAN OF TEN MINUTES SCARING THE DAYLIGHTS OUT OF ME AND NEARLY CAUSING TWO WRECKS. THE TRUCK IS HAZARDOUS TO DRIVE TO NOT ONLY MYSELF, BUT TO OTHER VEHICLES IN MY VICINITY WHILE ON THE ROAD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11402637March 12, 2021
STEERING, SUSPENSION
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED HE WAS ABLE TO DRIVE THE VEHICLE TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS INFORMED THE FRONT STEERING DAMPER WAS NEEDING TO BE REPLACED. THE VEHICLE HAD BEEN REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397580February 23, 2021
STEERING
STEERING WHEEL SHAKES AND THE FRONT TIRES WOBBLE , AFTER HITTING A BUMP, NOT ALL THE TIME . CHANGE EVERYTHING UNDER THE FRONT END AND STILL THE SAME THING. DEATH WOBBLE ABOVE 55 MPH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397380February 22, 2021
STEERING, SUSPENSION
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE STARTED SHAKING ABNORMALLY. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER FAIRWAY FORD OF AUGUSTA INC (4333 WASHINGTON RD, EVANS, GA 30809, (706) 854-9200) WHERE THE VEHICLE WAS REPAIRED. THE CONTACT WAS UNSURE OF WHAT PARTS WERE REPLACED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000. *BF THE CONSUMER STATED THAT THE VEHICLE IS CONTINUOUSLY SHAKING EVEN WITH THE VEHICLE BEING REPAIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11394899February 5, 2021
ENGINE, POWER TRAIN
THE 6.2 ENGINE HAS BROKEN VALVE SPRINGS 3 TIMES NOW. FIRST TWO TIMES WAS ABLE TO JUST REPLACE THE BROKEN VALVE SPRING. THE 3RD TIME IT BROKE A VALVE SPRING IT DROPPED THE VALVE IN THE MOTOR AND PUT HOLE RIGHT THROUGH THE BLOCK AND SEIZED THE MOTOR ALMOST CAUSING ME TO WRECK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389922January 25, 2021
STEERING, SUSPENSION
WE HAVE HAD NUMEROUS INSTANCES OF "DEATH WOBBLE" STARTING AT A 75,000 MILES. ALL SUSPENSION IS STOCK, TIRES ARE STOCK. I HAD BROUGHT THE TRUCK TO THE DEALERSHIP 4-5 TIMES (UNDER WARRANTY) AND GOT THE TRACK BAR REPLACED, TRACK BALL BUSHING, AND BALL JOINT, STEERING DAMPER, INCREASE IN CASTER AND EVEN BOUGHT NEW STOCK TIRES TO PROVE OUT THE PROBLEM. I HAVE 125,000 MILES ON THE TRUCK NOW AFTER FIGHTING THIS ISSUE FOR YEARS AND HAVE REPLACED ALL ROD ENDS, TRACK BAR, BUSHINGS, STEERING DAMPER, ETC AND THE DEATH WOBBLE STILL PERSISTS. THIS IS CLEARLY A DESIGN ISSUE AND MAKES THE TRUCK DANGEROUS TO DRIVE. THE ISSUE OCCURS PRIMARILY AT HIGHWAY SPEEDS, WHILE MAKING A VERY SLIGHT LEFT TURN WHEN A SMALL BUMP IS DRIVEN OVER SUCH AS AN EXPANSION JOINT. THE SEVERE VIBRATION THAT SHAKES THE FRONT SUSPENSION VIOLENTLY BACK AND FORTH DOES NOT SUBSIDE UNTIL THE TRUCK IS UNDER ~20 MPH (NOT A SAFE CONDITION TO BE IN WHEN ON THE HIGHWAY). DURING THIS PERIOD YOU CAN NOT HOLD THE STEERING WHEEL UNDER CONTROL, CAN NOT CONTROL THE DIRECTION OF THE VEHICLE OR STOP QUICKLY IF REQUIRED. THIS 'DEATH WOBBLE' HAS OCCURRED APPROXIMATELY 20 TIME WITH THE LATEST OCCURRENCE HAPPENING TODAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389460January 22, 2021
STEERING, SUSPENSION, WHEELS
WHILE DRIVING DOWN THE INTERSTATE AT 60MPH THE TRUCK STARTED VIOLENTLY SHAKING. THE STEERING WHEEL WAS SHAKING UNCONTROLLABLY. IT WAS A VERY SCARY SCENARIO. UPON RESEARCHING THIS IS A KNOWN PROBLEM THAT FORD HASN'T ADDRESSED. SINCE THEN IT HAS HAPPENED MULTIPLE TIMES AND HAVE DUBBED IT UNSAFE TO OPERATE AT 60MPH. I AM NOT THE FIRST OWNER OF THIS VEHICLE AND AM NOT SURE IF THIS OCCURED BEFORE 131,000 MILES OR NOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387243January 8, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
INTERIOR LIGHTS DO NOT COME ON WHEN DOOR IS OPENED, ONLY CAN BE MANUALLY TURNED ON. THE CARGO LIGHTS AND HIGH BRAKE LIKE NO LONGER WORK AS WELL WHICH IS A SAFETY ISSUE WITH THE CENTER HIGH BRAKE LIGHT. TURNS OUT A LOT OF 2012 F250 OWNERS ARE COMPLAINING OF THE SAME ISSUE AND IT'S CAUSED BY THE BCM. BODY CONTROL MODULE. IT APPEARS THAT A DESIGN FLAW LETS WATER DRIP ON THE MODULE WHICH EVENTUALLY MAKES IT NO LONGER OPERATE AS EXPLAINED BY SEVERAL REPAIR SHOPS I'VE CONTACTED. THE 2011 F250 HAS A RECALL FOR THIS SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387248January 8, 2021
STEERING, SUSPENSION
TRAVELING AT FREEWAY SPEEDS WHEN THE TRUCK HITS A BUMP OR ISSUE IN/ON THE ROAD THE FRONT WHEELS START TO SHAKE VIOLENTLY AND I AM BARELY ABLE TO CONTROL THE TRUCK UNTIL IT SLOWS TO AROUND 10 MPH, I HAVE NOW REPLACED ALL THE STEERING COMPONENTS AND IT HAS GOTTEN WORSE AND I HAVE ALMOST ROLLED MY TRUCK. WHEN I HAVE CONTACTED FORD DEALERS THEY ALL TELL ME THAT THEY HAVE NEVER HEARD OF THIS ISSUE BUT FOR $6,000 TO $10,000 THEY CAN REPLACE ALL THE SUSPENSION PARTS AND THAT SHOULD FIX THE UNUSUAL PROBLEM THAT ONLY I AM HAVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11384188December 19, 2020
AIR BAGS
MY 15 YEAR OLD DAUGHTER WAS DRIVING MY TRUCK WHEN SOMEONE SLAMMED ON BRAKES IN FRONT OF US TO TURN, WITH NO TURN SIGNAL. WE HIT THIS PERSONS VEHICLE IN A 55 MPH ZONE AT 55 MPH AND THEN HIT THE DITCH. NONE OF OUR AIRBAGS DEPLOYED. WITH THE DAMAGE THAT OCCURED, I WOULD THINK A SENSOR WOULD HAVE TRIGGERED. THIS NEEDS TO BE BROUGHT TO THE ATTENTION OF FORD MOTOR COMPANY.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11384017December 18, 2020
STEERING, SUSPENSION, UNKNOWN OR OTHER
FIRS STARTED VIBRATING BEYOND MY CONTROL WHEN I HIT A SMALL BUMP WHILE TRAVELLING APPROXIMATELY 50MPH, HAD WORN BUSHING AND OTHER REPLACEMENTS AND CONTINUES TO OCCUR PERIODICALLY. THE SHAKING IS SO SEVERE THAT THE TRUCK CANNOT BE STEERED AND ONLY STOPS WHEN I GET BELOW 20MPH. IT HAS NOW OCCURRED AT SPEEDS FROM 35 TO 70MPH AND THE TRUCK IS UNSAFE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383663December 16, 2020
SERVICE BRAKES
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING, HE HAD TO SLAM ON THE BRAKES TO AVOID CRASHING INTO A VEHICLE THAT HAD TURNED IN FRONT OF HIM. THE BRAKE PEDAL WENT SOFT WHILE PRESSED DOWN. THE VEHICLE WAS TAKEN TO RON TIRAPELLI FORD (4355 W. JEFFERSON ST, SHOREWOOD, IL 60404, (815) 725-3033). THE DEALER CHECKED THE BRAKES AND RECOMMENDED THAT THE BRAKE PADS BE CHANGED AND THE BRAKE LINES BE BLED TO REMOVE AIR IN THE SYSTEM. THE CONTACT PICKED UP THE VEHICLE AND TESTED THE BRAKE PEDAL AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE CONTACT HAD THE MANAGER STEP ON THE BRAKE PEDAL AND IT WENT DOWN TO THE FLOOR. THE DEALER MADE AN APPOINTMENT THE NEXT DAY AND PROVIDED COMPLETE SERVICE CHECK. THE FAILURE RECURRED AGAIN WHILE DRIVING 45 MPH. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11382889December 10, 2020
SUSPENSION
AT HIGHWAY SPEEDS WHEN GOING AROUND A CURVE THE VEHICLE BEGAN SHAKING VIOLENTLY. FORD DEALER REPLACED THE DAMPER ASSEMBLY, FRONT SUSPENSION ARM BUSHING, INSTALLED 1 DEGREE ADJUSTERS, REPLACED THE TRACK BAR BUSHING, AND DID A FRONT END ALIGNMENT. TEN MONTHS LATER I EXPERIENCED A SIMILAR VIOLENT SHAKING WHEN GOING OVER BUMPS AT 75 MPH. THIS HAPPENED 3 TIMES IN A 2 DAY PERIOD. THE SHAKING WOULD ONLY SUBSIDE AFTER SLOWING DOWN TO LESS THAN 15 MPH. MANY OTHER F250 OWNERS HAVE EXPERIENCED THE SAME PROBLEM. THE SHAKING IS SO VIOLENT IS COULD EASILY CAUSE LOSS OF CONTROL AND AN ACCIDENT. THIS VEHICLE IS UNSAFE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11377755December 3, 2020
STEERING
FOR THE SECOND TIME WHILE TRAVELING ON MAJOR HIGHWAYS MY TRUCK STARTED SHAKING VIOLENTLY TO THE POINT I COULD BARELY MAINTAIN A HOLD ON THE STEERING WHEEL. I HAVE HAD MY TIRES CHECKED AND THEY IN GOOD SHAPE AND BALANCED. THE FRONT BALL JOINTS ARE DEEMED FINE. AFTER A VISIT TO THE DEALER THEY SAY THEY CAN FIND NO PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11375683November 21, 2020
STEERING, SUSPENSION, UNKNOWN OR OTHER
WHILE DRIVE MY 2012 FORD F-250 AT SPEEDS OF 65+, THE STEERING WHEEL START TO SHAKE VIOLENTLY AFTER DRIVING OVER A BUMP IN THE ROAD. I HAVE RESEARCHED THIS AND FOUND IT IS COMMONLY KNOWN AS A DEATH WOBBLE. THE VIDEOS FOUND ON YOUTUBE REPLICATE IT CORRECTLY. I'M NOT SURE WHAT OTHER DAMAGE IT MAY HAVE CAUSED TO MY TRUCK. IT HAS BEEN HAPPENING SINCE I BOUGHT THE TRUCK. I'VE BOUGHT AN ADJUSTABLE TRACK BAR AND TRIED MANY DIFFERENT TIRES COMBINATIONS. I HAVE NOT FOUND A SOLUTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11374115November 11, 2020
STEERING
ABOVE ABOUT 40MPH, VERY STRONG SHAKING IN STEERING THAT IS UNABLE TO BE CONTROLLED UNLESS I SLOW DOWN. VEHICLE VERY DIFFICULT TO CONTROL. THIS HAS BEEN REFERRED TO AS "DEATH WOBBLE" ON THESE TRUCKS AND I HAVE BEEN EXPERIENCING IT FOR YEARS. I FINALLY DECIDED TO FILE A COMPLAINT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11372405October 30, 2020
STEERING
WHEN DRIVING ON I95 (INTESTATE) AT A NOMINAL 65-70 MPH SPONTANEOUSLY, THE TRUCK STARTS SHAKING AND AS TIME PROGRESSES IT GETS SO BAD IT MAKES THE TRUCK VERY DIFFICULT TO CONTROL. DURING THE EVENT THE FIRST REACTION IS TO HOLD THE TRUCK IN A LANE WHILE BRAKING. THAT EXACERBATES THE VIOLENCE OF THE SHAKING UNTIL BELOW 30 MPH. THIS HAS GOTTEN PROGRESSIVELY WORST OVER A WEEKS TIME. MOST RECENTLY IT ALMOST CAUSED A COLLISION WITH A LARGE TRUCK. THIS HAPPENED WHEN THE TRUCK WAS NEW AND THE DEALER REPAIRED SOMETHING AT NO COST UNDER WARRANTY. NOW I MUST PAY FOR A REPAIR FOR SOMETHING I BELIEVE IS A SIGNIFICANT DESIGN PROBLEM AND SAFETY HAZARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364896October 18, 2020
STEERING, SUSPENSION
MY 2012 F250 STARTED HAVING A DEATH WOBBLE IN JULY OF 2020. I HAD A FORD DEALERSHIP IN SNYDER TX REPLACE MY STEERING DAMPENER IN AUG OF 2020. THE PROBLEM JUST STARTED AGAIN OCTOBER 13. THE TRUCK ONLY HAS 140000 MILES ON IT. THE DEALERSHIP IN SNYDER TX SAID THAT THE FRONT END COMPONENTS ARE IN GREAT SHAPE AND SAID THAT THE DAMPENER SHOULD FIX THE PROBLEM. IT HAS NOT. THIS WOBBLE HAPPENS AT HWY SPEEDS . I HAVE TO BREAK HARD TO TRY AND SLOW IT DOWN AS SOON AS POSSIBLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250