Ford F-250 Complaints (2022)

111 consumer complaints on file.

#11700061November 18, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698339November 8, 2025
POWER TRAIN
October 2024 (while out of state vacation): The transmission violently downshifted upon moderate acceleration such that truck lurched with a loud bang, went into limp safe mode in traffic, with no rear warning because brakes were not applied. I was able to shut the vehicle off and restart, and able to engage the transmission, though engagement remained harsh. No Check Engine Lights were illuminated. Upon return home, I got the truck to local dealer service center. They had the truck for a week and said they could not determine a cause or problem...no scanner codes recorded? Their tech could not duplicate. From October 2024 until June 2025, this same behavior occurred 2-4 times, all without CELs. June 2025: Truck taken to local dealership with symptom list, only now occurring more frequently. At my insistence, I asked the dealer to involve Ford Engineering, to diagnose, and to compel Ford to honor the active full warranty still in place. This unresolved issue began October 2024. The dealer had the truck for over a month, and said he could not proceed further in diagnosing unless Ford authorized warranty payment for labor and parts. No progress was made, and it was told to me I HAVE TO CONTACT FORD and push, because the dealer is an independent shop, not Ford proper. I took the truck away and drove, to allow possible worsening, or some other code to be recorded or CELs to show. October 2025: Truck violentlt downshifted without acceleration or deceleration from 35 mph to almost )mph, skidding and fishtailing, going into limp mode, and I was almost rear ended by following traffic...since brakes were not activated to cause this. Truck went immediately into limp mode, and would not now engage PARK. I turned it off, restarted, and transmission would hardly go into DRIVE. I limped home, and vowed I will not drive it again until repaired! No CELs illuminated. The truck was towed to the dealer at my cost, and has been there over 2.5 weeks as of 11/8/25. Ford denies help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698259November 7, 2025
SUSPENSION
The contact owns a 2022 Ford F-250. The contact stated that while driving at an undisclosed speed, the steering wheel inadvertently drifted to the left. There were no warning lights illuminated. The contact stated that upon inspecting the vehicle, the contact became aware that there was severe wear on the front passenger’s side outer tire. The vehicle was taken to the dealer where it was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 41,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697954November 6, 2025
ELECTRICAL SYSTEM
The door lock actuator has failed on the front driver side door. It does not work with the key fob or the door lock switch.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697866November 6, 2025
VISIBILITY/WIPER
Rear window exploded when defroster button pushed after 30 seconds
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695981October 28, 2025
STEERING
thank you for a response the issue is the vehicle is making a cluck noise when turning i took it to a ford dealer mind you i paid 2 thousand dollars for an extended warranty from ford they put the truck on a lift and said there was nothing wrong i instructed them to drive it and they did agree there was a clunck noise and dismissed it as an axle shift with a co worker moving the steering wheel i heard the clucling and noticed the joint at the pitman arm moving up and down what is the point and when does ford decide that it is bad as a commercial vehicle inspector for the state of ma. there should be no play in joints this truck steering could fail as with other ones out on the roads because ford and its dealers are dismissing complaint and its not fair or resonable that they should even question steering issues please for the safety of all look into ther ford steering center link failures and hold them accontable to take care of these issues thank you sincerly [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695891October 27, 2025
STEERING
noise while turning noticible up/down play in center link
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694514October 20, 2025
BACK OVER PREVENTION, FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-250. The contact’s spouse stated that while attempting to reverse, the back-over prevention system became inoperable. The spouse reported that the rearview camera image was blank, and none of the rear sensors provided any notification or warning, resulting in the vehicle reversing into a tree. The contact received notifications of NHTSA Campaign Number 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to complete the recall repairs were not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 49,700.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11694232October 18, 2025
ENGINE
The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l engine. The check engine light illuminated after i noticed the ticking noise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694080October 17, 2025
VEHICLE SPEED CONTROL
Intermittent delay in throttle response. Sometimes the delay is nonexistent or nearly imperceptible, other times the delay can be 2 seconds or more. Is very dangerous when trying to merge with flowing traffic. Occurs most often with the steering wheels turned and accelerating from stop, but has happened while driving straight at freeway speeds. Turning off traction control seems to mitigate but not entirely eliminate the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691617October 6, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2022 Ford F-250. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then lunged forward. The contact stated there was no warning light illuminated. The contact stated that the failure had occurred while driving at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the vehicle was functioning normally. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact reported that in December 2024, the engine had failed and needed to be replaced. The contact recently received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and related the failure to the recall. The failure mileage was approximately 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688523September 19, 2025
UNKNOWN OR OTHER
Roof trim on passenger side broke and blew off while driving. Vehicles behind could be overreacting and cause accident. I contacted Ford and they were not concerened or take a report.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686331September 10, 2025
ENGINE, STEERING, SERVICE BRAKES
The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686220September 10, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684925September 4, 2025
FUEL SYSTEM, GASOLINE
I just picked up my Ford F-250 (2022) from Allstar Ford in Prairieville, La. It will have been 3 weeks since I had my truck towed to this dealer! On Tuesday [XXX] my truck stalled in heavy traffic and was able to glide off [XXX] in Baton Rouge and same to a dead stop at the end intersection. I blocked traffic for 30 minutes until truck started and was able to get out of traffic! My Ford pass App text a message to me that my fuel pump module had failed. Dealer could not diagnose a failure and after 3 weeks I finally went and picked it up. They did offer to replace the fuel pump for $1700.00 as my 100,000 warranty could not be applied because dealer diagnostics could not recognize the fault??? Truck has 72,000 mile on it!! So now I am driving around in a vehicle that could stall at any time, without any notice. Now what do I do?? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684676September 3, 2025
SUSPENSION, STEERING
Bumps in the road caused steering wheel to shake violently (Death Wobble) until truck was stopped in the middle of a 4-lane expressway. Truck is now at the dealer for inspection of frontend steering components. If there was heavier traffic, there would have been an accident. no warning signs present, only bumps in the road which the truck was not able to dampen or control.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680162August 12, 2025
STEERING
Death Wobble. Steering wheel shook violently twice in one 25 mile trip. Once at 73 MPH and once at 65 MPH. Almost caused a crash due to being on a curve in the road when it occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680088August 12, 2025
FUEL SYSTEM, DIESEL
The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678677August 6, 2025
UNKNOWN OR OTHER
Rear view camera does not always display, either black screen with distorted view lines or complete blue screen. Vehicle is not on current camera recall list
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677273July 30, 2025
ENGINE, POWER TRAIN
The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250