Ford F-250 Complaints (2002)

401 consumer complaints on file.

#10970059April 3, 2017
ENGINE
TL* THE CONTACT OWNS A 2002 FORD F-250. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART ON THE SECOND ATTEMPT; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V553000 (ENGINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10969530March 30, 2017
SEAT BELTS
THE SEAT BELTS COME UNBUCKLED WHEN DRIVING. THIS HAPPENS TO THE DRIVE'S SIDE MORE OFTEN THAN PASSENGER SIDE. THE BELT COME UNDONE ON HIGHWAY, IN TOWN, JUST STARTING OUT OR AFTER AN HOUR THERE ISN'T A WARNING BEFORE IT HAPPENS.THE SPEED OF THE TRUCK ALSO DOESN'T MAKE A DIFFERENCE. BUT IT IS HAPPENING MORE FREQUENT NOW. IT STARTED ABOUT 3 YEARS AGO BUT IT IS GETTING WORST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954995February 16, 2017
STEERING
DRIVING DOWN INTERSTATE, HEARD A LOUD POP. LOST ALL STEERING ABILITY. STEERING BOX SHAFT SHEARED IN HALF. I WAS PULLING A 18' EMPTY TRAILER AT THE TIME. TRUCK BLOCKED BOTH WESTBOUND LANES ALMOST CAUSING LIFE THREATENING INJURIES. BOTH COUNTY SHERIFF AND VA STATE POLICE CAME TO SCENE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10949722February 6, 2017
ENGINE
TL* THE CONTACT OWNS A 2002 FORD F-250. WHILE DRIVING AT ANY SPEED AND AS SOON AS THE ENGINE BECAME HOT, A BURNING OIL ODOR WAS PRESENT INSIDE THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER DIAGNOSED THAT THERE WAS A DEFECTIVE HEAD GASKET THAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10945677January 17, 2017
ENGINE
TRUCK DIES WHILE DRIVING WITHOUT ANY WARNING, CAN-NOT FIND THE PROBLEM AND FORD WILL NOT ACKNOWLEDGE THAT THERE IS AN ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10936032December 18, 2016
STEERING
MY VEHICLE WAS BEING DRIVEN OUT MY DRIVEWAY WHILE MAKING A RIGHT TURN THE STEERING WHEEL LOCKED UP. THEN TO THE LEFT THE SAME. WHILE SITTING STILL I COULD TURN THE STEERING WHEEL ALL THE WAY TO THE LEFT NONE STOP. FLUID IS FULL. WHILE DRIVING STRAIGHT STEERS FINE UNTIL I TURN A LITTLE TO RIGHT OR LEFT THEN IT GETS TIGHT. I NOTICED FROM 2002 TO 2006 THEIR WERE STEERING PROBLEMS UNSOLVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924148November 3, 2016
SEAT BELTS
MY DRIVERS SIDE SEATBELT HAS STARTED TO RANDOMLY UNBUCKLE. THERE ISN'T ANYTHING TOUCHING IT, PRESSING IT OR OTHERWISE INTERFERING WITH THE OPERATION. I FIRMLY PRESS THE BUCKLE INTO THE RECEPTACLE, PULL ON IT TO ENSURE IT IS LATCHED AND RANDOMLY IT WILL COME UNDONE. THE DEALERSHIP SAID THERE ISN'T A RECALL OR WARRANTY TO COVER IT SO I HAD TO PURCHASE A NEW RECEPTACLE. THIS HAS HAPPENED GOING AS SLOW AS 5MPH AND AS FAST AS 50MPH AND IS QUITE STARTLING AS THE SEATBELT INSTANTLY STARTS TO REWIND. I DON'T FEEL COMFORTABLE DRIVING MY TRUCK KNOWING THE SEATBELT MIGHT NOT HOLD IF AN ACCIDENT WERE TO HAPPEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908205September 20, 2016
ELECTRICAL SYSTEM
ISSUE WITH DOME LIGHT, DOOR JAMB LIGHT ON, AUTO HEADLIGHTS - ALL NOT WORKING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908288September 20, 2016
SUSPENSION:FRONT:WHEEL BEARING
TL* THE CONTACT OWNS A 2002 FORD F-250. WHILE DRIVING 65 MPH, THE FRONT DRIVER'S SIDE WHEEL BEARING CAUGHT FIRE. THE CONTACT PULLED OVER AND EXTINGUISHED THE FIRE. IT WAS DETERMINED THAT THE HUB BEARING CAUGHT FIRE, WHICH ALSO SET THE REST OF THE TIRE ON FIRE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10875458June 20, 2016
UNKNOWN OR OTHER
FORD F250 4X4 6.8L V10 SPIT OUT NUMBER10 SPARKPLUG AT 65 MPH FOR THE SECOND TIME NOW TWO MONTHS AFTER REPAIR. PAID $60 FOR REPAIR KIT PLUS $65 FOR ANOTHER NEW COIL AS IT GETS DAMAGED EACH TIME THIS HAPPENS. NO FIRE THIS TIME AS I WAS ABLE TO STOP AND REMOVE THE COIL BEFORE GETTING OFF HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10874039June 13, 2016
ENGINE
MY 2002 FORD F250 SUPER DUTY 5.4 GASOLINE ENGINE HAD A SPARK PLUG BLOW OUT AT AROUND 165,000 MILES. I HAD PULLED OVER TO TAKE A CALL TURNED OFF THE ENGINE, WHEN I STARTED IT BACK UP IT WAS MAKING A LOUD POPPING SOUND, MY MACHANIC SHOP WAS NEXT DOOR TO WHERE I WAS SO I WAS LUCKY THAT I DID NOT HAVE TO DRIVE IT ANYWHERE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872830June 6, 2016
UNKNOWN OR OTHER
VEHICLE WAS PARKED, KEY OFF , NOT ATTENDED, CAUGHT FIRE, BURNED VEHICLE AND SURROUNDING EQUIPMENT AND BUILDINGS TO THE GROUND, BUT EVERYONE DENIES THAT THE CRUISE CANCEL SWITCH CAUSED IT EVEN THOUGH THE SYMPTOMS FIT.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10861904April 27, 2016
UNKNOWN OR OTHER
AFTER DRIVING ABOUT 30 MILES AND RETURNING HOME, THE TRUCK CAUGHT FIRE WHILE SITTING IN THE DRIVEWAY - ABOUT 20 MINUTES AFTER ENGINE WAS TURNED OFF. BY THE TIME SMOKE WAS SEEN, FLAMES WERE COMING FROM UNDER THE HOOD AND THE RIGHT FRONT TIRE WAS BURNING. THE FIRE DEPARTMENT PUT OUT THE FIRE BUT THE TRUCK WAS COMPLETELY DESTROYED. THE FLAMES SPREAD TO AN ADJACENT VEHICLE AND IT TOO WAS DESTROYED.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10859967April 17, 2016
ENGINE
AT 102000 MILES ENGINE EJECTED #8 SPARK PLUG WHILE DRIVING, TAKING THREADS WITH IT. LOCAL MECHANIC REPAIRED USING INSERT. AT 125000 MILES ENGINE EJECTED #3 SPARK PLUG IN SAME MANNER. SAME MECHANIC INSPECTED #8 WHILE REPAIRING #3 AND FOUND INSERT NOT HOLDING, PLUS TWO OTHER PLUGS BACKING OUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10824326February 4, 2016
SEAT BELTS
DRIVERS SEAT BELT KEEPS COMING UNLATCHED FOR NO REASON WHILE DRIVING. NOTHING IS STUCK INSIDE. I LATCH IT AND TUG HARD TO MAKE SURE FULLY LATCHED. THEN AFTER A FEW MINUTES OF DRIVING, IT RELEASES FOR NO REASON. MY BEST FRIENDS 2006 F250 ALSO HAS THE SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10818553January 6, 2016
STRUCTURE:BODY, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
AUTO HEADLAMPS AND TAIL LAMPS DON'T WORK. DOOR AJAR LIGHT STAYS ON. DOME LIGHT DOES NOT COME ON WHEN DOOR OPEN. FUEL GAGE STUCK ON FULL. IS IT THE VSM?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10810751December 16, 2015
ENGINE
TL* THE CONTACT OWNS A 2002 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, A LOUD ABNORMAL SOUND EMITTED FROM THE ENGINE COMPARTMENT. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE SPARK PLUG HAD EXPLODED OUT OF THE CYLINDER HEAD. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10790733November 16, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2002 FORD F-250. WHILE DRIVING 30 MPH AND MAKING A TURN, THE SWITCH FOR THE TURN SIGNAL INDICATOR SWITCH FAILED TO DEACTIVATE AND CAUSED A FUSE TO BLOW. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10788615November 5, 2015
TIRES
TL* THE CONTACT OWNS A 2002 FORD F-250 EQUIPPED WITH NITTO DURA GRAPPLER HIGHWAY TERRAIN TIRES, SIZE: LT265/75/R16 (NA). WHILE DRIVING 60 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE IT WAS CONFIRMED THAT THE TIRE NEEDED TO BE REPLACED. THE TIRE WAS NOT REPLACED. THE TIRE WAS A REPLACEMENT TIRE. THE MANUFACTURER WAS NOT NOTIFIED OF FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 89,000 AND THE TIRE FAILURE MILEAGE WAS 22,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10778962October 1, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2002 FORD F-250. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER SIDE WHEEL WELL WAS RUSTED SEVERELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO CONFIRMED THE RUST ISSUE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250