Ford F-150 Complaints (2008)

369 consumer complaints on file.

#10896526August 17, 2016
STEERING
STEERING BECAME VERY HEAVY, ALMOST LIKE POWER STEERING WAS GONE. VERY HARD TO TURN AND CONTROL THE TRUCK WHILE MOVING. SUDDENLY LOOSENS UP AND WORKS AS NORMAL. DEALER SAYS IT IS THE STEERING SHAFT AND NOW REFUSES TO FIX IT. I SEE A LOT OF THE SAME COMPLAINTS HERE, WHY ISN'T FORD BEING HELD RESPONSIBLE? THIS IS VERY DANGEROUS AND LIFE-THREATENING. I'M GLAD IT HAPPENED TO ME AND NOT TO MY WIFE; I DON;T THINK SHE WOULD HAVE HAD THE STRENGTH TO CONTROL THE TRUCK AND COULD HAVE KILLED OR SEVERELY INJURED HERSELF OR OTHERS. THIS NEEDS TO BE ADDRESSED!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10894906August 10, 2016
ENGINE
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE COMING TO A STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10889006July 27, 2016
ENGINE
TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOST OIL PRESSURE AND STALLED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART AND RESUME DRIVING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE LOW OIL PRESSURE CAUSED THE ENGINE TO FAIL. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10883126July 6, 2016
STEERING
AS MY WIFE WAS TURNING A CORNER THE POWER STEERING FAILED ON HER. SHE CROSSED THE CENTER LINE AND NEARLY HIT VEHICLE THAT WAS WAITING AT A STOP SIGN. SHE HAD TO JERK ON THE STEERING WHEEL VERY HARD TO GET THE TRUCK BACK IN THE PROPER LANE. MECHANIC INDICATED THIS IS FAIRLY COMMON AND FORD DEALERS ARE KEEPING THE LOWER STEERING SHAFTS-U-JOINTS IN STOCK DUE TO OLDER ONES LOCKING UP. NO RECALLS HAVE BEEN ISSUED TO THIS POINT HOWEVER, I HAD IT REPLACED AT A COST OF $490.00.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875066June 19, 2016
STEERING
STEERING SHAFT MADE FROM INFERIOR MATERIAL CAUSING IT TO MALFUNCTION. VERY HARD TO TURN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873314June 8, 2016
STEERING
MY BROTHER IN LAW HAS A 2008 FORD F-150 AND SAID HIS STEERING SEIZED UP AND AFTER CHECKING FLUID, BELTS, ETC. IT APPEARED THE STEERING SHAFT U-JOINTS WERE BINDING. LAST WEEK MY 2008 F150 EXPERIENCED THE SAME PROBLEM. WHY HASN'T FORD BEEN LIABLE FOR THIS SAFETY ISSUE. AFTER CHECKING VARIOUS FORD SITES, THIS IS A MAJOR PROBLEM WITH F150'S.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10871582May 31, 2016
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2008 FORD F-150. UPON INSPECTION OF THE VEHICLE, THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE COULD BE CONSIDERED DESTROYED. THE TECHNICIAN STATED THAT THE FRAME DAMAGE WAS SO SEVERE THAT THE VEHICLE NEEDED A NEW FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10870062May 20, 2016
ENGINE
RADIATOR AND THERMOSTAT - I HAVE HAD TO REPLACE 4 RADIATORS IN MY FORD F250 TRUCK AND THE VEHICLE ONLY HAS 125,000 MILES. THIS IS A KNOWN DEFECT FROM FORD AND THEY HAVE DONE NOTHING TO PROTECT THEIR CUSTOMERS. I HAVE BEEN STRANDED 3 TIMES AS A RESULT OF THIS DEFECT WITH MY CHILDREN IN THE CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10864286May 10, 2016
ENGINE
I HAVE BEEN ADVISED BY THE LOCAL PHIL LONG FORD DEALERSHIP SERVICE DEPARTMENT THAT MY TRUCK NEEDS THE CAM PHASERS REPLACED TO FIX THE PROBLEMS I AM EXPERIENCING. I HAVE SEEN THAT THIS IS A "VERY" COMMON PROBLEM WITH THE 5.4 ENGINE AND FORD HAS RETIRED THIS ENGINE FROM THEIR VEHICLES DO TO THE FAILURES AND IT HAS BEEN KNOWN BY FORD SINCE THE 2003 MODELS AND YET THEY CONTINUED TO SELL A KNOWN FAULTY ENGINE. THEY SHOULD PAY TO HAVE THESE ENGINES REPAIRED AND NOT THE CONSUMERS. THIS IS IN COLORADO SPRINGS, CO AND THE PROBLEMS IS STILL INTERMITTENT AT THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10860100April 18, 2016
STEERING
I HAVE A 2008 FORD F150 I WAS MAKING A RIGHT TURN OFF OF A MAIN ROAD INTO A DRIVEWAY WHILE APPLYING SLIGHT BRAKING PRESSURE WHEN THE STEERING WHEEL COMPLETELY LOCKED UP AND BRAKING WAS STIFF AT THE PEDAL CAUSING A NEAR COLLISION INTO A TREE LINE. THE ENGINE REMAINED RUNNING NEVER DIED. I HAD TO SHUT OFF THE ENGINE AND RESTART TO REGAIN CONTROL OF THE STEERING. NO WARNING LIGHTS ARE ON. NO DASH INDICATORS OF ANY ERRORS. I HAVE CALLED THE DEALERSHIP AND THEY SAY THEY HAVE NEVER HEARD OF THIS ISSUE. ALL MAINTENANCE HAS BEEN METICULOUSLY UP TO DATE. I WILL BE TAKING MY TRUCK IN FOR DIAGNOSTIC IN THE MORNING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10854637April 10, 2016
ELECTRICAL SYSTEM, ENGINE
ON TUESDAY, APRIL 5, 2016, WHILE DRIVING 45 MILES PER HOUR, ON A 2 LANE, BACK COUNTRY, ROAD MY FORD F150, THAT HAD 114,376 MILES BEGAN TO CLANK AND RUMBLE UP UNDER THE HOOD. THE NOISE MADE THE VEHICLE VIBRATE AS THE NOISE GOT LOUDER SO I PULLED OFF OF THE ROAD AND POPPED THE HOOD. THERE WAS SMOKE, CLICKING AND CLANKING ON TOP OF THE RIGHT SIDE OF THE ENGINE SO I TURNED THE VEHICLE OFF. I CALLED MY INSURANCE AND ASKED TO BE TOWED TO A FORD DEALERSHIP 5 MILES AWAY. THE TRUCK WAS STILL DRIVE-ABLE BUT SMOKING AND CLANKING. THE NEXT MORNING I LEARNED #2 SPARK PLUG HAD LOOSE STRIPPING THREADS IN THE CYLINDER HEAD AND THE COIL CRACKED FROM THE PLUG BLOWING OUT. THE PLUG AND BOOTS HAD TO BE REPLACED. REPLACED THE #2 COIL AND THE DEALER HAD TO EXTRACT THE BROKEN SPARK PLUG CYLINDER #2. THE PARTS, SUPPLY, AND LABOR COST WAS $1292.24. I HAVE HAD LARGE V8 ENGINE, VEHICLES ALL OF MY LIFE WITH 200,000 MILES OR MORE ON THE ENGINE BUT NEVER ANY SPARK PLUG ISSUES WITH HIGH MILEAGE ON BOTH SPARK PLUG AND OTHER VEHICLE ENGINE PARTS. IF I HAD CONTINUED TO DRIVE MY TRUCK IT SURELY WOULD HAVE IGNITED CAUSING MORE DAMAGE OR INJURY. THE SPARK PLUG ISSUES WITH FORD NEED TO BE ADDRESSED. I PURCHASED THIS TRUCK IN DECEMBER 2013 WITH 81,160 AND HAD NO PROBLEMS FOR 2 YEARS, 4 MONTHS. AT NO TIME SHOULD SPARK PLUGS BLOW UP OR OUT UNLESS THEY ARE DEFECTIVE PARTS OR PLUGS NOT SUITABLE TO BE TRANSFIXED INTO THE CYLINDER OR ENGINE. DRIVER SAFETY IS AT RISK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10853906April 6, 2016
ELECTRICAL SYSTEM, ENGINE
ON APRIL 5, 2016, WHILE DRIVING MY 2008, F150, TRITON, 4.6, ABOUT 45 MPH, ON A TWO LANE, BACK COUNTRY ROAD, A SUDDEN RATTLING AND POPPING NOISE OCCURRED. I IMMEDIATELY PULLED OVER, POPPED THE HOOD, WHEREAS SMOKE AND THE RATTLING NOISE CONTINUED. I TURNED OFF THE ENGINE AND HAD THE VEHICLE TOWED TO THE FORD DEALERSHIP 5 MILES AWAY. I HAVE 113,600 MILES ON MY VEHICLE AND PURCHASED IT FROM A CARMAX DEALER IN DECEMBER 2013, WITH 81,160 MILES, HAVING EXPERIENCED (NO PROBLEMS THUS FAR). I WAS TOLD BY THE FORD DEALERSHIP THAT MY #3 SPARKPLUG HAD CAUSED THE MECHANICAL ISSUE AND ALL PLUGS NEEDED REPLACING. ADDITIONALLY REPLACEMENT OF RIGHT SIDE ENGINE ISSUES RESULTED FROM NOT HAVING DONE THE 100000 MILE TUNE UP (BULL). IT HAD BEEN TUNED UP PREVIOUS TO BEING SOLD. AFTER USING CHOICE WORDS TOWARDS THE DEALER AND ADVISING HIM OF MY OWNERSHIP OF 3, LARGER V8 ENGINES, NO SPARKPLUG EXPLOSIONS HAD EVER OCCURRED IN MY LIFE. ALL MY FORMER VEHICLES WITH THE EXCEPTION OF MY 2008 F150 HAD NEVER EXPERIENCE SUCH SPARKPLUG EXPLOSION ISSUES AND THESE VEHICLES REACHED CLOSE AND OVER 200,000 MILES. MY VEHICLE IS STILL UNDER WARRANTY BUT DOES NOT COVER THIS ISSUE, NOR WAS THE FORD MANUFACTURE HELPFUL IN ASSISTING WITH THIS MATTER. THE TOTAL COST FOR REPAIRS IS $1295.00, AND MY FIGHT WITH FORD HAS JUST BEGUN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10852600March 30, 2016
STEERING
INTERMEDIATE STEERING SHAFT CORRODED, CAUSING STIFF STEERING, HAZARDOUS TO DRIVE, PARTICULARLY WHEN MAKING TURNS, MANEUVERING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10852260March 29, 2016
WHEELS:RIM
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE DRIVER SIDE RIM FRACTURED. THE CONTACT LOST CONTROL OF THE VEHICLE WHILE DRIVING 70 MPH. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. IN ADDITION, THE REAR DRIVER AND PASSENGER SIDE RIMS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RIMS FRACTURED AND CAUSED THE BRAKES TO MALFUNCTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10852329March 29, 2016
FUEL/PROPULSION SYSTEM
VEHICLE UNEXPECTANTLY STALLED WHILE TRAVELING 30 MPH CAUSING PARTIAL LOSS OF CONTROL OF STEERING AND BRAKING ABILITY. I WAS ABLE TO PULL VEHICLE TO SIDE OF ROAD. FAILED TO RESTART VEHICLE INITIALLY. AFTER SEVERAL ATTEMPTS, VEHICLE RESTARTED. WAS ABLE TO DRIVE TO DEALER ONE BLOCK AWAY WITH SEVERAL STALLS, RESTARTS. CHECK ENGINE LIGHT WAS ON. LOCHEN FORD IN NEWBURG, WI DIAGNOSED A FAILED FUEL DRIVER MODULE. REPLACED AT A COST OF $350 ON 3/29/16. AFTER SEARCHING ONLINE, THIS IS NOT AN UNCOMMON FAILURE WITH THIS VEHICLE. FAILURE OF PART IS DUE TO ACCELERATED CORROSION OF PART ITSELF DUE TO POOR DESIGN AND MOUNTING. MODIFICATIONS HAVE SINCE BEEN MADE TO LESSEN THE CHANCE OF FAILURE. THIS IS CERTAINLY OF CONCERN SINCE STALLING OF THE ENGINE AT ALL SPEEDS IS A SAFETY ISSUE. I SUSPECT THOUSANDS, IF NOT MILLIONS OF THESE POPULAR TRUCKS ARE AFFECTED. THIS SHOULD BE RECALLED BY FORD, BUT TO MY KNOWLEDGE, HAS NOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10851078March 22, 2016
ENGINE
MY VEHICLE HAS A BAD MISS IN MOTOR, HAVE HAD ALL PLUGS/WIRES REPLACED TO NO AVAIL. DATA LINK STILL SAYS MISFIRE ON #3. HAVE TO DRIVE SLOW UP HILLS IF DRIVE AT NORMAL SPEED CHECK ENGINE LIGHTS UP. NO ONE SEEMS TO KNOW WHATS WRONG, EVEN MAJOR DEALERSHIPS. NEED HELP ON THIS, HAVE TALKED TO MULTIPLE PEOPLE THAT ARE HAVINT THE SAME ISSUE. I HAVE ALERTED FORD TO THIS AND THEY HAVE BEEN NO HELP AT ALL. THIS NEEDS TO BE A RECALL. IT HAPPENS MOSTLY WHEN DRIVING AT NORMAL SPEEDS GOING DOWN THE HIGHWAY. SOMETIMES IT MISSES SITTING STILL. IT IS A FX4 AS WELL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10846331March 13, 2016
UNKNOWN OR OTHER
WIFE IS AT THE NCHA EASTERN NATIONAL FINALS IN JACKSON, MS. THIS IS A BIG HORSE EVEN WHICH BRINGS IN A LOT OF FORD F350, 450, AND 550 TO THE SHOW. PEOPLE SPEND A LOT OF MONEY ON THESE VEHICLES OVER 60,000 DOLLARS. THIS VEHICLE BEING AS NICE AS IT IS, HAS A MAJOR DESIGN FLAW. THEY ARE TOO EASY TO BREAK INTO. HORSE SHOW IS FROM MARCH 7 - 19. AS OF MARCH 13, 2016 IN JACKSON, MS. THERE HAVE BEEN OVER 300 FORD F SERIES PICKUP TRUCKS BROKEN INTO BY WAY OF THE DOOR HANDLE ON THE DRIVE SIDE. THE THIEFS EITHER TAKE A SCREW DRIVE AND PRY THE PLASTIC DOOR HANDLE OFF AND HAVE ACCESS TO THE INSIDE THE DOOR AND UNLOCK. OR THEY DRILL RIGHT BELOW THE PLASTIC AND UPWARD TO HIT THE MECHANICAL DEVICE THAT UNLOCKS THE DOOR AND THEY ARE IN. LESS THAN A MINUTE FOR THEM TO GAIN ACCESS. THEY CAN DO THE SAME THING TO THE REAR DOOR BY PRYING THE PLASTIC OFF AND ACCESS THE INSIDE. FORD NEEDS TO REDESIGN THIS AND GET RID OF THE CHEAP PLASTIC DOOR HANDLES. NEED TO ISSUE A RECALL FOR ALL FORD F SERIES PICKUPS AND INSTALL JIMMIE JAMMERS SO THIEVES CANNOT ACCESS THE DEVICE TO UNLOCK THE DOOR. WITH THE JIMMIE JAMMER, YOU CAN NOT USE A FLATHEAD SCREW DRIVER IN THE KEYLOCK AND TURN IT TO FORCE IT TO UNLOCK. IN FACT, FORD JUST NEEDS TO GET RID OF THE KEYLOCK ALL TOGETHER. YOU HAVE TWO WAYS OF UNLOCKING THE DOORS. KEYPAD OR KEYFOB. WHY DO YOU NEED TO DOOR LOCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10846207March 11, 2016
ENGINE
SPARK PLUG BLEW OUT IN A CROWDED STORE PARKING LOT,' BRAKING THE COIL. A FIRE COULD HAVE RESULTED IF COIL HAD NOT BROKE. THE GAS FUMES WERE STRONG. I THOUGHT IT WAS GASKET PROBLEM AND CONTINUED TO DRIVE TO MY MECHANIC'S SHOP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10840199March 7, 2016
SERVICE BRAKES
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. WHEN THE BRAKE PEDAL WAS ENGAGED, THE ABS ACTIVATED AND CAUSED THE VEHICLE TO PULSATE AND THE CONTACT TO LOSE CONTROL. THE DEALER REPLACED THE FRONT ROTORS, BUT THE FAILURE RECURRED. THE CONTACT INSPECTED THE VEHICLE AND DRAINED THE FRONT BRAKES; HOWEVER, THE BRAKE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10838576February 26, 2016
ENGINE
FOR THE SECOND TIME IN LESS THAN 4 MONTHS THE #2 SPARK PLUG HAS BLOWN OUT OF THE CYLENDER HEAD. FORD HAS KNOWN ABUOT THIS PROBLEM FOR YEARS BUT WILL NOT FIX IT . THIS COULD CAUSE AN EXPLOSION & FIRE IN THE ENGINE COMPARTMENT AS THE PLUG & INJECTOR AR STILL WORKING PUMPING FUEL INTO AN OPEN HOLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150