Ford F-150 Complaints (2021)

1,308 consumer complaints on file.

#11563103January 2, 2024
VISIBILITY:WINDSHIELD WIPER/WASHER
The contact owns a 2021 Ford F-150. The contact stated that while driving in the rain at an undisclosed speed, the windshield wipers became inoperable. The vehicle was taken to the dealer, where it was determined that the windshield wipers motor needed to be replaced. The dealer informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 22V842000 (Visibility) because the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563033January 2, 2024
PARKING BRAKE
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V509000 (Parking Brake) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562615December 29, 2023
EXTERIOR LIGHTING
It started with the loss of Sirius, then intermittently maps, and now the radio is gone and my display on my dash goes black and restarts. I will be driving down the road (interstate) and all of my dash disappears. No speedometer at all. The APIM is out and Ford has no APIM's available. I took it to local Ford and they confirmed the APIM was out. It controls the whole truck and weird things have happened. Locks, seating changing, steering wheel changes. There is a case opened with Ford but apparently no timeline on fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562339December 28, 2023
POWER TRAIN, STEERING, UNKNOWN OR OTHER
3.6.2021 - Ford F150 purchased at Battlefield Ford (Ourisman Ford), Manassus VA / registered in CT 7.27.21 – inspected by Torrington Ford, Torrington CT for rubbing sound front left side, nothing found / 6,325 miles 2.10.22 – inspected for same issue / nothing found / 16,000 miles 7.27.22 – inspected for same issue / nothing found / 24,000 miles 12.24.2022 – “Catastrophic failure” of front differential / 34,369 miles. On Christmas Eve 2022 myself, husband and son were driving to family in NY when the truck very quickly started to make a severe grinding sound, became unable to steer, loss of control, and started to produce smoke & fire under the hood. We immediately stopped and got out unharmed. Fire was dripping out of the bottom of the truck and smoke/fire under the hood. We were lucky. Firetrucks came but were unable to do anything. The truck's wheels completely seized up - the tow truck had to skid it onto the flatbed. Repaired at Simmons-Rockwell Ford, Hallstead, PA. Complete new front differential and damaged parts in proximity to the failure (pinion gear, axle shaft, etc). 12.16.2023 – Again hearing a sound in front left side while driving; bring to the shop for inspection. Shop confirms front differential is failing again, per Torrington Ford, (where all maintenance and repairs were completed, except for the first failed front differential in PA). Advise not to drive for safety reasons. 52,922 miles. With both front differential failures - no warning lights or messages. Symptoms - a slight rubbing/grinding noise in the front left side of vehicle; “rough” sound while driving. 1st front differential – inspected at 6,000 miles, 16,000 miles, and 24,000 miles. Failed at 34,369 miles. 2nd front differential – inspected at 52,922 miles, failing differential, advised not to drive. Dec 2023 – Buy-back claim filed with Ford Motor Co. Denied - "outside of the 18-month warranty period for VA Lemon Law". Clearly, safety is not a guiding tenet for Ford Motor Co.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11562076December 27, 2023
VISIBILITY
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V842000 (Visibility) and the vehicle was repaired; however, prior to the repair, the windshield wipers operated erratically, damaging the wiper blades and left a 2-inch streak across the windshield, causing an issue with visibility while driving. The vehicle was diagnosed but was not repaired due to the cost. The manufacturer was made aware of the failure. The contact stated that the wiper blades were not included in the NHTSA Campaign Number: 22V842000 (Visibility) repair. The failure mileage was 54,556.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560839December 19, 2023
POWER TRAIN
Passenger side rear axle retainer bolt sheared off. My vehicle was manufactured 20 days after the existing recall. Repair was done under warranty but obviously should be included as part of the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560668December 18, 2023
POWER TRAIN
When moving the shift lever from Drive to Reverse, and physically feeling the two detents from Drive, through Neutral, and into Reverse, intermittently the shift lever will still indicate Neural and the vehicle will stay in Neutral even after two physical detents have been felt (i.e. the truck should indicate and be in Reverse after two physical detents). The truck and shift lever will stay in Neutral even after I remove my hand from the shift lever. The truck will only engage reverse after physically pressing the shift lever further forward within the physical Reverse detent area. There were no warnings on the dash and no trouble codes present within the system. The vehicle is available for inspection, and a video is available, however it is intermittently operating in this manner. When performing a 3-point turn on a roadway, this has led me to believe that my vehicle was engaged in Reverse, but it was in fact not, but in Neutral. This has introduced significant delay in what would otherwise be a safe maneuver and has put me and my occupants safety at risk. The local Ford dealership has updated the shift software, but it has continued to operate this same way intermittently. I have demonstrated this to the dealership service advisor and shown a video to the shop foreman, however the dealership is unwilling to replace the shifter because there is no trouble code. The vehicle has not been inspected by anyone other than the local Ford dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560305December 15, 2023
SUSPENSION
The contact owns a 2021 Ford F-150. The contact stated while the vehicle was at the dealer for tire rotation services, the dealer informed his wife that the rear passenger's side axle bolt was fractured and was stuck inside the hub of the wheel. The dealer determined that the rear passenger's side axle needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11559389December 10, 2023
ENGINE, UNKNOWN OR OTHER
--Exhaust leak, at left first band clamp downstream from catalyst --Safety is of immediate concern due to exhaust leak directly under driver seat --Local Ford dealership service dept did not fix leak --Exhaust leak was inspected and reported to local Ford dealer service dept- NOT fixed On 20 November 2023, I purchased a 2021 Ford F-150 XL, VIN: [XXX] , from Crain Ford of Jacksonville, Arkansas, 1800 School Drive, Jacksonville, Arkansas 72076. Phone 501-436-4981. After driving the vehicle for a day, I noticed a fluid leak on my garage floor under the vehicle’s engine area. On 21 November 2023, I took the vehicle to the dealership, which I bought the truck from, Crain Ford or Jacksonville, AR. They inspected the underside and found no leaks and suggested I just keep an eye out for any fluid leaks. The next week I kept watching for leaks, and each day I saw what appeared to be a fluid leak of some type or fluid on the floor of my garage. On 27 November 2023, I took the vehicle back t o the same dealership, Crain Ford, and I showed them a video of the leak I discovered. The video can be viewed at: [XXX] As the video shows, upon cold startup of the vehicle, you can see water leaking from the band clamp on the exhaust system just below the left catalyst. I fully understand that the fluid is water and is a byproduct of the combustion system and is normal. That is NOT the problem, the problem is, if water can leak out at the band clamp on the exhaust system, as shown, then so can deadly exhaust fumes right under the driver area. I showed the video to the Ford service dept foreman and he had a technician check the exhaust and assured me that the band clamps were at factory spec torque and they could smell or observe no leaks. I took the vehicle home. The next morning, there is still a deadly exhaust leak occurring at the band clamp on the exhaust pipe as I can see water dripping out, just as the first video showed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11558897December 7, 2023
WHEELS
Broken Right Rear Axle bolt, F150 with ~37500 mileage, Max tow Package, Already identified by FORD customer "satisfaction" Program 22B34
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11558296December 4, 2023
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
When a trailer is connected the right side trailer brake light fails to operate; the lights on the truck work properly. When the trailer has been recently disconnected warnings on the dash appear saying "Blind spot and cross traffic alert deactivated trailer attached". I also get trailer left and right turn lamps fault check lamps warnings and the turn signal indicators flash at double speed. These things always clear up after a couple of days until a trailer has been connected and disconnected again. I have two different trailers and they both do the same thing. Just for the record, the right turn signal and hazard flashers on the trailer work correctly. My dealer has observed everything that I stated above but claims he is unable to get parts to fix it. The cross traffic alert malfunction and the non operative trailer brake light would appear to be safety issues. So far, no one has been involved except my dealer's service department. If I don't hook up a trailer everything has and does work correctly. I took this truck in to the dealer a couple of years ago due to the dashboard warnings but did not take my trailer with me at that time; they were unable to fix it. I was unaware at that point that I had no right trailer brake light; this is not easy to see unless someone is following me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557734November 30, 2023
WHEELS, POWER TRAIN, SERVICE BRAKES
On November 29, 2023 I took my 2021 F150 to Larry Miller Ford for servicing and repairs related to Recalls 22S71 and 23S35. When the tech was rotating the wheels he discovered that the axle shaft bolts were sheered off on both the left and right rear wheels. The service manager called to tell me that this was a serious safety issue and that only the brake rotors were preventing the wheels from falling off the truck. The service manager told me there was a "Customer Satisfaction Program 22B34" issued by Ford, but no Ford Recall relating to the problem. Larry Miller Ford has replaced both axles and axle bolts. I am waiting to find out if there is damage to the rotors, calipers or brake pads, a concern since the sheered off bolts were rattling around within that area since breaking off apparently between service visits. I strongly believe Ford should be required to issue a recall on this problem. I never received a notification on CSP 22B34. Had it not been for my tire rotation, the wheels could have fallen off at highway speed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557408November 29, 2023
POWER TRAIN
On 11-28-2023 I took my truck in for an oil change and new tires. When the wheels were removed the passenger side rear axle bolt fell out. It had been sheared off and I don't know how long I had driven it like that. The last time the wheels were off was when I had an oil change and tire rotation at the same dealership in July 2023, they did not alert me to a problem at that time. The dealer said it was unsafe to drive and I should leave it there to await parts and service. My truck is a 2021 F-150 Ecoboost with the Max Tow Package. It has 54,520 miles on it. The dealer service department has not looked at it to determine if it is an eligible warranty repair or not at this time but it is scheduled to be inspected today. There were no warning lamps or messages given related to this problem at any time. My own research online indicates that hundreds of other 2021 and later F150 owners with the Max Tow Package have had the same problem of axle bolts breaking. No accidents or injuries have been reported that I know of but there has been lots of inconvenience because owners are told the trucks are unsafe to drive. The dealers are saying that the axles must be changed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557139November 27, 2023
UNKNOWN OR OTHER, EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
Radio started blasting a boom/ static sound from the rear speakers and subwoofer; extremely loud and has occurred multiple times. It had previously made a similiar sound occasionally at start up which when under warranty was always diagnosed as unable to duplicate but is now occuring while driving and I am out of warranty. Very startling and distracting when it occurs. Has occured multiple times and lasts upto an hour before I gave up an parked my vehicle. Have a special needs minimally verbal disabled child who is very sensitive to noise (rear speakers are always turned off via fade to front) who was very impacted by this loud explosion of chaos/ noise when it occured with him in the car. Ford response: since out of warranty can pay for diagnostic and repairs. Don't expect NHTSA to care as they weren't concerned with my complaint regarding complete loss of brakes (incomplete or bad programming) with this truck but maybe this will let others know they arent alone if they have this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557141November 27, 2023
VEHICLE SPEED CONTROL
When making 90° turns such as an immediate right turn or a left turn across one lane, gas pedal becomes completly unresponsive halfway through the turn for approx 3 seconds. Occurs about 1% of the time but drastic when it occurs. Almost multiple accidents have occured with oncoming traffic almost t-boning me when making left turns or being rear ended on right turns: people don't anticipate a vehicle stalling and slowing down when entering traffic and people have swerved into other lanes or the shoulder to avoid a collision. When this occurs, it is like the vehicle goes brain dead, the gas pedal can be pushed to any threshold including floored with no change to speed; rpms dont even increase. Vehicle has been through Ford troubleshooting multiple times and at one point early on, had a Ford engineering/ specialist working remotely with the dealership. Findings from this specialist: two upcoming ota updates will be released that will resolve this concern. One of the updates was in regards to the trailer brake module and the other something else as equally ridiculous as not pertaining to my issue. OTA updates came and issue never went away. Years later, multiple appointments with techs saying unable to duplicate. Dealer now saying they have no record of working with a specialist even though I have the service records from them stating this and electronic communications from Ford regarding this. The issue is not resolved and still occurring. Vehicle now out of warranty so likely will never be repaired. Not faithful in thinking NHTSA will care, they didn't care when this vehicle had complete brake failure at 7k miles which was later found to be due to incomplete or bad programming, but maybe this will help others know they are not alone if experiencing this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556625November 24, 2023
UNKNOWN OR OTHER
Console lid with integrated work table. Will not stay open and will slam shut because the springs are not strong enough to hold lid open. This has been present since the vehicle was purchased new. Several members of my family including me have had the lid slam on my fingers. The lid is heavy and it hurts. Local ford dealer said that the console in all the F150 do it and there is no fix from ford. I’m concerned that a grand child may open the lid and it slam down on their fingers and cause serious injury. Ive read multiply f150 complaints about this issue, and even a possible fix. the truck is still under warranty . Ive been dealing with issue from a month after the purchase. It’s a virtual mouse or rat trap to who ever opens the lid! I know this is not your typical safety issue, but it is a safety issue! Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556596November 23, 2023
STEERING
The power steering assist lamp went on and the vehicle steering became very hard to steer while driving my wife was driving and could have gotten in a bad accident the ford motor company has made recalls for this same issue in other vehicles and i believe that my vehicle should be in that recall as well i have a 2021 f150 xlt 2.7 liter engine and i want my vehicle to be inspected and repaired because the for motor company has put faulty parts in this vehicle as well it is only 2 years old i shouldnt be having this issue.please launch an investigation to have this vehicle added to the list that needs a recall on power steering assist fault power steering.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556286November 21, 2023
SUSPENSION, POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
The bolt the holds the rear axle/hub on the 9.75 HD rear-end sheared off. This is an ongoing issue with their rear-end.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556230November 21, 2023
POWER TRAIN, ENGINE
The contact owns a 2021 Ford F-150. The contact stated while stopped the vehicle was at a stop light, the vehicle displayed a message reading "Service Advanced Auto Track," requiring the vehicle to be shifted into park and restarted. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The engine kill switch warning light was illuminated. The vehicle was taken to three individual dealers, who were all unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 31,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555390November 16, 2023
POWER TRAIN
I heard a scratchy rattling sound around 35-36k miles at very low speeds. Eventually narrowed it down to the passenger rear wheel area. I took off the wheel to inspect the area and the head of the axle bolt fell out. It looked to have been yielded from over torquing or something. But I was shocked! I have no idea the actual period of failure. If I hadn’t rolled my windows down for the nice weather, I probably wouldn’t have heard it. I checked and there has been no recall or anything sent to me that this is a problem. I tow a camper with the family and if the axle failed while doing so, it could of killed us. Very unhappy that Ford has not recalled this. There are many others on a Facebook group that have had the same issue. It needs to be Remedied.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150