Ford F-150 Complaints (2018)

2,327 consumer complaints on file.

#11761667September 2, 2026
POWER TRAIN
10R80 Transmission Delays when shifting and when it does engage its harsh shifts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761768September 2, 2026
ENGINE, POWER TRAIN
No oil in between changes check engine light came one
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761411September 1, 2026
ENGINE, POWER TRAIN
Direct failure of Cam phasers and confirmation. This led to erratic engine runtime leading to transmission shifting learned behaviors based on the bogus engine information. This causes erratic hardshifting into drive and most importantly dropping gears on the highway resulting in unsafe driving conditions at random. This includes both random downshifts at highway speed and a similar situation when accelerating the wrong gear is engaged both causing unsafe conditions for the driver and those surrounding. Upon phaser replacement the engine then ran correctly and transmission was reset both KAM tables and learned behavior to rectify the transmission safety challenges. This should at least be a TSB not just a mystery to owners and dealers alike.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761037August 31, 2026
ENGINE
I own a 2018 Ford F-150 3.5L EcoBoost with approximately 93,000 miles. I am experiencing a repeated cold start cam phaser rattle. This is a known issue addressed by Ford in several TSBs, including 19-2365, yet no recall has been issued. It has been "repaired" once at approximately 40,000 miles only to have the same issue reoccur at which time I was told that rattling at startup is "normal" and "since it doesn't persist it is not an issue". No IC gasoline engine should rattle on startup, and I believe this defect poses long-term reliability concerns and will lead to engine damage and failure during operation. Ford should be held responsible for a widespread design flaw affecting thousands of vehicles. I urge the NHTSA to investigate this recurring issue and hold Ford accountable for consumer safety and financial impact.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760925August 31, 2026
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that while accelerating from a stop light, the vehicle failed to properly accelerate and jerked and hesitated. The contact stated that the transmission upshifted from 1st to 3rd gear and then from 3rd to 7th gear. During the failure the WRENCH symbol was displayed. The vehicle was taken to the local dealer to be diagnosed, and it was determined that the transmission needed to be repaired, and the CDF drum need to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 96,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760931August 31, 2026
EXTERIOR LIGHTING, LANE DEPARTURE: BLIND SPOT DETECTION
The contact owns a 2018 Ford F-150. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V373000 (Exterior Lighting) and Customer Satisfaction Program: 25N17 (Rear View Camera Replacement If Required After Dealer Evaluation); however, the failure occurred after the repairs were performed. The contact stated that while driving at an undisclosed speed, the "Parking Brake Engaged" message displayed, and the blind spot sensor became inoperable. An unknown warning light was illuminated. Additionally, the TPMS was inoperable. The vehicle was taken back to the dealer, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759735August 26, 2026
POWER TRAIN, WHEELS
I own a 2018 Ford F-150 4WD with approximately 24,600 miles. While traveling approximately 70 MPH on the highway in 2H with cruise control operating, I suddenly heard an extremely loud metal-on-metal grinding/ratcheting noise from the driver's-side front wheel area. The noise caused immediate concern about a possible front wheel or drivetrain failure. I disengaged cruise control and the grinding stopped. Within approximately 50 miles on the same trip, the grinding occurred a second time while again traveling approximately 70 MPH in 2H without cruise engaged. Because of the severity of the noise, I pulled over on the side of the highway and inspected the vehicle. I found nothing visibly wrong and resumed driving. The condition has since occurred two additional times while accelerating from a stop in 2H. These incidents were less severe but involved the same metal-on-metal grinding/ratcheting from the driver's-side front wheel area. I have also noticed a brief air/vacuum-type "whoosh" immediately before the grinding occurs. My Ford service manager directed me to Ford TSB 24-2188, which addresses grinding/clicking/ratcheting from the front wheel area associated with partial engagement of the Integrated Wheel End (IWE). The truck is scheduled for diagnosis but has not yet been formally diagnosed. I contacted Ford Customer Satisfaction, case CXH-090-0329-26-V5R9-P-5. Ford declined assistance due to vehicle age despite the low mileage. I am reporting this because the condition has occurred four times, including twice unexpectedly at 70 MPH. I am concerned about the safety implications of a front wheel-end component potentially partially engaging at highway speed and believe this warrants NHTSA review.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759756August 26, 2026
STRUCTURE
The contact owns a 2018 Ford F-150. The contact stated that the lock mechanism to drop the spare tire was rusted and failed to function as intended. The contact stated that the failure failed to allow for the spare tire from being lowered. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. However, the dealer confirmed that the lock was rusted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759856August 26, 2026
SERVICE BRAKES
My 2018 Ford F-150 is experiencing a dangerous loss of braking power, a soft/spongy brake pedal, and brake fluid leaking from the master cylinder into the brake booster. These are the exact symptoms and component failures described in Ford Recall Campaign 25S37 (NHTSA Campaign 25V236). However, when checking my VIN, I am told my truck is excluded from the recall population. Because my vehicle is exhibiting the identical safety defect, the current recall window is too narrow and needs to be expanded to cover my vehicle before a serious collision occurs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759370August 25, 2026
ENGINE
Engine has cut off while driving on several occasions. An accident nearly occurred as a result on at least 2 occasions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759375August 25, 2026
AIR BAGS
The contact owns a 2018 Ford F-150. The contact stated that the steering wheel cover covering the driver’s side air bag was cracked. The dealer was contacted and stated that a special engineer was needed for the repair because the crack was located on air bag housing. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759569August 25, 2026
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I was required to complete the recall 24E12 on my 2018 ford F 150 2.7L eco boost XLT. Upon completion the check engine light comes on. I looked into this and this is an ongoing problem with the emissions recall . I scanned for a code and P0430 is coming up. (Catalyst System). I contacted the dealership and ford corporate and they will not help assist in resolving this issue. I explained my vehicle was working fine until the mandatory emissions recall was completed and that under the good will assistance I should be covered for Some compensation fixing this vehicle. I was denied any additional help. I as a loyal customer for many years don’t believe that it is my responsibility to pay a full bill for a new converter when it was their recall that caused the issue on an already perfectly fine vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759042August 24, 2026
POWER TRAIN
Truck will not shift into 7th gear, will down shift to 1st gear once it reaches 6th gear around 40mph. Causing the vehicle back tires to brake and skid and lose control of vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759143August 24, 2026
POWER TRAIN
While driving home from a work appointment in Rockwall, Texas, I entered an intersection with three lanes of uncontrolled cross traffic traveling approximately 35-45 mph. As I accelerated my Ford F-150 equipped with the 10R80 transmission, it started into the intersection and then began sporadically hunting for a gear. The truck suddenly lost nearly all acceleration and slowed to an almost complete stop while I was in the middle of the intersection. Vehicles were approaching me from the driver side, leaving me with almost no ability to get out of their path. I was extremely fortunate that I was not T-boned. This is the second time this truck has experienced a sudden and dangerous loss of acceleration, the first was with a 4th gear slip on an on-ramp. Neither incident was preceded by a warning light or other dashboard indication. I understand Ford has been aware of problems involving the CDF clutch drum in the 10R80 transmission and that the design was subsequently revised in later versions. My vehicles issues are textbook CDF Drum problems. Meanwhile, the known 10R80 problems have significantly reduced the vehicle's value, leaving me owing more than I can reasonably recover by selling it. This is not simply a reliability issue. A transmission that can unexpectedly eliminate a vehicle's ability to accelerate without warning is a serious safety hazard. Twice, this defect has put me in a situation where I could have been killed by cross traffic. I am asking NHTSA to investigate the 10R80 transmission, including the CDF drum/design issues, and determine whether these failures create an unreasonable safety risk and whether Ford has taken adequate corrective action.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758222August 20, 2026
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact owns a 2018 Ford F-150. The contact stated that while attempting to trade in the vehicle, there was a mileage discrepancy discovered. The vehicle was a private sale. The mileage at the time of the purchase was approximately 93,000 miles, which was displayed on the odometer; however, the trade-in dealer informed the contact that the vehicle history report listed the mileage at over 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758239August 20, 2026
ENGINE
I believe there’s an ongoing lawsuit against Ford regarding these truck models, specifically their gearboxes, which are failing and slipping gears. After the initial recall for the new software gearbox mapping, my gearbox has started slipping, causing issues during downshifting, acceleration, and upshifting. There are frequent loud bangs
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758290August 20, 2026
ENGINE AND ENGINE COOLING, POWER TRAIN, SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ford F-150. The contact stated that while driving 55 MPH on the highway, the vehicle lost motive power, and the brakes became inoperable. The drivetrain and wrench symbol were displayed. The ABS warning light was illuminated and DTC: U100 (Failure of Communication for Engine and Transmission) was displayed. The codes were cleared after restarting the vehicle. The vehicle was taken to the local dealer, where it was diagnosed with a communication error with the engine and transmission computer. The vehicle was repaired, but the failure reoccurred. The transmission upshifted from first gear to seventh. After a while, the vehicle resumed normal operations, but then the vehicle drove abnormally. The RPM increased to high, and the temperature gauge was at HOT. The vehicle was taken back to the dealer and was diagnosed with complete transmission failure. The vehicle had not been repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 62,513.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757451August 17, 2026
POWER TRAIN
My 10R80 transmission has failed at 79000 miles. This tranmission has been problematic during the life of this truck. Hard shifting, delayed shift, clutch flutter. Ford refused to honor my extended warranty that covers the power train beyond the 5/60000mile base warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757273August 16, 2026
POWER TRAIN, ENGINE
Truck starting missing gears when pulling onto highway. Rpms jumped high and truck wouldnt shift. Thankfully we made it across before the oncoming traffic or we would have been hit. Finally got it to go but it was missing gears causing it to drive sluggish. No prior engine lights warning me. When the incident happed I got a notification of a power train malfunction/ reduced power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756719August 13, 2026
POWER TRAIN
10R80 transmission will jerk and hard shift randomly at times. Also appears to get stuck in gear and/or downshift at inappropriate times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150