Ford Explorer Complaints

917 consumer complaints on file.

#11659021May 5, 2025
SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
The contact owns a 2022 Ford Explorer. The contact stated that while driving at 20-25 MPH, the brakes were applied, and the brake pedal fell off. The brake pedal was not responding. The vehicle increased in speed to 43 MPH. The contact maneuvered around an unknown vehicle to avoid an accident, but the unknown vehicle turned and crashed into the passenger-side quarter panel. The vehicle traveled off a curb and landed in a ditch. The contact and two passengers occupying the second-row seats and one child passenger occupying the third row in a car seat sustained bruises and cuts and were transported to the hospital. The air bags did not deploy. There was no fire. A police report was filed. There was an abnormal beeping sound detected. There were no warning lights illuminated. The vehicle was towed to a body shop. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, who opened a claim and declined to assist. The failure mileage was approximately 57,865.
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0
#11658367May 2, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR
The contact owns a 2025 Ford Explorer. The contact stated that while at an intersection at a stop light attempting to make a turn at 5 MPH, the brake pedal was hard when depressed, and the vehicle continued to move. As a result, the vehicle crashed into the rear of another vehicle. The air bags did not deploy. The front camera was not operational. There were no warning lights illuminated. There were no reported injuries, fire, or police reports filed. The contact was able to continue to drive. The vehicle was taken to the local dealer, who test-drove the vehicle and was unable to determine the failure. The vehicle was not diagnosed or repaired. The contact called another dealer, J. O. Williams Motors419 E Broadway Ave, Gladewater, TX 75647, and reported the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who referred him to another local dealer. The failure mileage was approximately 4,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11658301May 1, 2025
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION
Error codes such as blind spots detection with traffic and a couple other codes that is stored in view status area in oasis
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657281April 28, 2025
UNKNOWN OR OTHER, VISIBILITY/WIPER
Moon roof cover is sagging and interfering with visibility with the rear view mirror. There have been many incidents of the sagging occurring online in for forums. There have been no warning notices for this issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656758April 25, 2025
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
My vehicle is having the blue screen & message to contact my dealer when in reverse. I understand there is a recall for this. I contacted ford to see why I haven't received a notice & am being told that it only affects certain vehicles yet I'm having the exact issue. It is a safety hazard due to low visibility behind the vehicle when in reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656720April 25, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Every morning when I go to leave in my 2022 Ford Explorer when it's cold or not. I go to start the vehicle and it automatically says that their is a malfunction in the brake system that it requires service right away. That advance track and a whole bunch of safety systems had failed. The instrument cluster is lit up like a Christmas tree. Then when you do put the Explorer into reverse, your foot almost hits the floor board and automatically starts rolling backward until you slam on the brake hoping it will stop. Then when it flashes stating that the Electronic parking brake is still engaged when it clearly isn't. Then you basically have no brakes until the vehicle "warms up", once you reach normal operating temperature on the Ford explorer you can park and shut off the car release the automatic parking brake then reengage the parking brake and it feels like it's missing the catch mechanism when your foot it on the brake l. Like it tries to engage but then doesn't. Then you open the door then close it, lock the car and wait 2-6 minutes for all the gauges to turn off then you unlock the car open the door press the start button without the brake to confirm no error codes pop back on and if they door you have to reengage the auto brake system off and on. Then rinse and repeat, then when it "fixes" itself no lights turn on and your brake returns to normal. About 50% of the time. Half the time when you first try to drive away the brakes give out and the same errors reoccur. Its extremely unsafe I've had this car for a year and half I brought this issue to multiple Ford dealerships and they say it would be 3 weeks before they could even look at it. I don't have that kind of time. I work and I have a [XXX] daughter and fiance to worry about. This needs to be remedied ASAP. I am planning on taking it to another dealer and the police department to find out what I can do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656664April 24, 2025
FUEL/PROPULSION SYSTEM
Charcoal canister and vapor purge valve failure. Broke down twice after putting gas in my car right at the pump. One time in not the greatest neighborhood that I have to drive through to get to work. Putting myself at risk by sitting at a gas pump with a car that sounds like it wants to start but keeps just choking. After fueling a few times prior I noticed the idle of the car getting very low and reported it to the dealer. They replaced both cats. Problem didn’t go away. Got an emissions warning when I tried to start the car at the gas station after fueling. Car has 70,000 miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656495April 24, 2025
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
The contact owns a 2022 Ford Explorer. The contact stated that while driving 35 MPH, the hood suddenly opened and struck the windshield, causing the windshield to crack. The contact stated that the month prior to the failure, the hood had been opened for a routine oil change. There were no warning lights illuminated. There were no reported injuries. The vehicle was taken to a body shop. The local dealer was contacted and referred the contact to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656187April 22, 2025
UNKNOWN OR OTHER
Engine compartment hood latch. thankfully, I was at a red light when the incident occurred. While stopped at the light, i heard a loud "cluck" sound. My daughter asked if we were hit, I looked around we were not. I looked at the dashboard and noticed that the "Hood ajar" was illuminated. The hood spontaneously just opened on its own. It has not been inspected at this time, I had an appointment at Ford for an oil change on 4/22/25 and I told them about the incident. I then had to ask them to look at it. they said they couldn't, that I would have to have an seperate appointment for that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656111April 22, 2025
STEERING
Driver assist warning light comes on and I lose power steering on my ford. I took the vehicle in last month for repair. Dealer said it was a software issue. Rest the software. This did not fix issue. I was driving on highway at 65 miles when steering assist message popped up and I lost my power steering. This a major safety issue. I checked on line and other drivers had reported the same issue. Please advise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655271April 17, 2025
POWER TRAIN
This vehicle has an electronic shifting transmission and when shifting from drive to reverse, the system lags significantly (1-3) seconds before engaging reverse. This has been an issue causing several close calls. In addition to not being able to back up efficiently and being left hanging in limbo while waiting for the transmission to engage, the vehicle also continues to roll forward causing near collisions. Happens while maneuvering the vehicle in situations where a three point turn is necessary or when trying to quickly go from drive to reverse in an attempt to avoid another traffic unit or on coming hazard. Has been brought to Ford for them to check and they advised after a test drive that the vehicle shifts smoothly. The smoothness of the shifting was not the concern. It was the lag between drive to reverse. I believe it needs a software reprogram for the transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654765April 15, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, SERVICE BRAKES
I bought the car in December and I was only able to take it out on the road in January, when it started to have problems with the software and brake system. I brought it to the dealer's workshop where I bought it, but they haven't solved anything and they say that the faults the car presents are normal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654443April 14, 2025
STEERING, LANE DEPARTURE: ASSIST
What component or system failed or malfunctioned, and is it available for inspection upon request? The steering system failed completely while the vehicle was in motion. It is currently at the Ford service center in Cocoa, Florida, and is available for inspection upon request. How was your safety or the safety of others put at risk? My wife and our two children (ages [XXX] and [XXX] ) were nearly killed due to this catastrophic steering failure. While traveling at approximately 70 MPH on [XXX] near West Melbourne, Florida (between exits XXX and XXX) in the far right lane, the vehicle suddenly and without warning jerked aggressively to the left, crossing into the center lane, nearly causing a high-speed collision with a semi-truck. The truck driver was able to swerve just in time to avoid an accident. At that point, the vehicle became extremely difficult to steer. It continued to pull to the left, and it required all of my wife's strength to get it off the highway and safely stopped on the shoulder. The safety of multiple drivers on the interstate was compromised due to this failure. Has the problem been reproduced or confirmed by a dealer or independent service center? We are currently awaiting confirmation. The vehicle is in the possession of the Ford service center in Cocoa, Florida, and they are attempting to diagnose the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle is currently with Ford. We were told they are trying to recreate the issue by driving it in a field behind the dealership, but as of now, they have not taken the vehicle back out on the road or highway for testing. The Florida Highway Patrol was called at the time of the incident, but they did not dispatch a trooper since there was no crash or contact with another vehicle. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. There were no INFORMATION REDACTED PURSUANT TO THE FREEDOM OF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654353April 13, 2025
STRUCTURE:BODY
The chrome on the window switch on the passenger side is peeling and cut my finger while using it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654149April 11, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653910April 10, 2025
VISIBILITY/WIPER, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The backup camera and related system on the 2022 Ford Explorer ST has malfunctioned and failed to show any images. I'd had the vehicle to the dealer on 3 occasions, whereby I've just learned the issue was improperly diagnosed by another dealer as a faulty camera, but the real problem of a faulty processor was diagnosed and therefore not replaced. This issue puts me, other vehicles and pedestrians in particular risk as there is not rear camera image being projected. The problem has been confirmed by two dealers, diagnosed and now indication is to repair it. This is clearly part of the broader issues Ford is having with rear camera back-up systems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653703April 9, 2025
VISIBILITY/WIPER
Sunroof headliner sagging. Can't see out back window
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653073April 6, 2025
VEHICLE SPEED CONTROL
2021 Ford Exploer the RPM SHOOTS UP AND DOES NOT GO DOWN. I HAVE TO PULL OVER AND SHUT VEHICLE OFF TO RESET.. This has been replaced in 2023 and I am having problems with same issue. VEHICLE WILL NOT PICK UP SPEED UPON Accelerating and when it finally picks up the transmission with jerk really hard. This happens 2x a week. At times I have to pull over because there is no speed when pressing on the gas and need to shut off my car to reset it. When pressing on the gas pedal it Will sped up and take off with light Touch from gas pedal .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652806April 4, 2025
ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM, ENGINE
The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was turned off, the contact was notified by the Ford App that the check engine warning light was illuminated and the message “Fuel Door Open" was displayed. The contact stated that the vehicle previously had a transmission software update due to the vehicle hesitating to accelerate while driving. Additionally, the speedometer intermittently failed to function as needed. The vehicle was taken to the dealer, who determined that there was water intrusion into the body control module fuse panel. The contact was informed that the battery and body control module fuse panel needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 61,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652734April 4, 2025
STRUCTURE:BODY
The A piller molding on BOTH sides of the windshield has been blown off. When blown off it cracked the windshield. This resulting in a hazard to drivers around but also the fuel economy of the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer