Ford Expedition Complaints (2018)

383 consumer complaints on file.

#11486768September 27, 2022
ENGINE, ELECTRICAL SYSTEM:STARTER ASSEMBLY
The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11486001September 23, 2022
UNKNOWN OR OTHER
Power running boards switched from automatic to off position while driving vehicle and without warning to driver. Due to height of vehicle (20" wheels) and failure to deploy, injury occurred while attempting to exit vehicle. Ford took over two weeks to determine problem and cost owner approximately $1400 to repair as vehicle was no longer under warranty. Vehicle had less than five thousand (5,000) miles.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11485102September 18, 2022
ENGINE
While coming to a stop, or already stopped with the Auto Start/Stop system engaged, the vehicle will completely shut down and the message "Auto StartStop Shift to P, then Restart Engine" pops up. After doing that the engine restarts normally. AGM battery was recently replaced and engine starting is strong. This has happened around 3-4 times in the last few weeks, and normally occurs when the engine is still cold in the first couple miles of driving (although temps have been very mild, in the 60's or 70's). I have tried contacting two Ford dealers in my area but both have been unresponsive. One said they can't even take appointments related to powertrain in the next several months and the other will not call me back after leaving repeated messages. Thankfully this has only occurred while stopped or coming to a stop in traffic, but could also happen while making a turn into oncoming traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484002September 12, 2022
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2018 Ford Expedition. The contact stated while driving 65 MPH and attempting to change lanes, he depressed the accelerator to overtake the other vehicles and the accelerator became stuck. The contact stated that the cruise control had been activated while attempting to make the lane change. The contact stated that he removed his foot from the accelerator pedal however, the vehicle remained accelerating to almost 100 MPH. The contact tapped the accelerator pedal to release the stuck pedal however, the accelerator pedal failed to respond. The contact placed his foot underneath the pedal and physically released the pedal. The contact stated that the accelerator pedal responded and the vehicle slowed. The contact stated that the check engine warning light was illuminated. The contact stated he checked the vehicle service app on his phone and stated that the app showed two catalytic converter warnings had been displayed. The contact had taken the vehicle to a local dealer where it was not yet diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was 65,647.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484078September 12, 2022
POWER TRAIN
my transmission shifted from first gear to second gear very hard causing the vehicle to lunge. My daughter is a new driver and it scared her so much that she stopped in traffic at a stop sign and I thought the vehicle was hit. my dash cam even recorded it as a possible collision (no one hit us just jerked that bad). I have only owned it for a month and when I took it to the dealer that I bought it from they said Ford knows they have a problem and it sucks. (dealerships words) I had no lamps or warnings come on at the time of the event. when I changed driving modes the vehicle went completely out of gear and would not go back into gear until I shut it down and started it back up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483814September 10, 2022
UNKNOWN OR OTHER
The rear evaporator has reportedly failed and is causing a leak to the refrigerant. We have read the TSB 21-2250 and the earlier Customer Satisfaction Program 18N01 which both point to what is reportedly a common issue for these systems. Safety concern is overall heat in vehicle. At the same time we are experiencing a leak of coolant, and the Ford dealership is recommending replacement of pump. The dealer is also recommending the replacement of rear evaporator and recharge of the refrigerant. The cooling fan was running full blast which was our warning of checking low coolant, there was no warning lights of any issues. As there have been multiple TSB type of issues, as a customer this seems like a known issue that Ford should be paying to have fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483699September 9, 2022
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
About 20 times now, while I am on the freeway, sometimes when I am coasting, and other times when I am trying to quickly accelerate, my car down shifts out of nowhere and loses power, again either when I am in the fast lane coasting, or trying to merge into traffic. It's like it is going to stall and when I step on the gas, it just revs and doesn't get into gear and go. I have almost been rear ended because I go from 70 to like 40 mph. When I was trying to merge into traffic, I got partially into the other lane and then it just wouldn't go. I could easily have been hit. One time when I was coasting and it did it, a warning came on, and then a check manual, but it went away too fast. I have taken it to the dealer and a repair shop multiple times and they can't replicate it. It could definitely cause an accident as my car suddenly slows down and it won't accelerate. I have to wait about 10-15 seconds until it reengages. It makes aloud clunking/dropping sound as if I ran over something and one time it sounded like a million pebbles were inside my engine and under my car. No diagnostic numbers are coming up and it's like no one knows what I am talking about. But multiple Fords are having this issue and they are not doing anything about it. I took it in during my warranty and now it's out of warranty and I'm going to have to pay for something that they should have repaired from the get go. This is dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483432September 8, 2022
POWER TRAIN
Random gear shifts lead to dangerous changes in speed during normal driving. Example-Driving in 8th gear transmission shifted to 2nd and then jumped back to 6th gear causing near loss of control. Other times transmission sticks in-between gear resulting in a loss of power during driving. Dealer and independent service center have reproduced problem. Replaced value body per Ford's recommendation which did not fix the problem. Vehicle has not been inspected by police, insurance representative or manufacturer. Powertrain warning light did come on but after these issues were affecting the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481700August 29, 2022
POWER TRAIN
Vehicle with 80k miles. Transmission stuck in 2nd gear resulted in safety issue when merging with traffic. When this occurs the engine revs and then the transmission jumps into 8th gear. Once in 8th gear it is very slow to accelerate. If there’s any reason I need to decelerate, the transmission remains in 8th gear and will not shift back to 1st gear even if at a complete stop. Have been stopped at a traffic light and had to place the vehicle back in park and shut the engine off so the transmission will reset back to 1st.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11480777August 23, 2022
ENGINE, POWER TRAIN
If I have to decelerate and then quickly accelerate the car will lose power and restart. This typically happens when I’m driving on the highway in heavy traffic. I originally thought there was problem with the transmission because it would downshift to 5th gear and clunk (feels like the tranny fell off). It would then try and put itself into park and then power down and restart. The only error code ever given is a parking paw error. This makes sense because transmissions aren’t supposed to go into park at 70mph. Lately the vehicle is sluggish and doesn’t respond as I try to accelerate which leads to the shut down restart while moving. I recently read about the class action lawsuit and recall regarding ford throttle bodies in F-150s. The incidents in those reports mirror what I’ve experienced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477128August 2, 2022
POWER TRAIN
Transmission seems to get stuck in 2nd and 8-9 gear when driving and I have lost all ability to accelerate at both slow and high speeds. I am able to see the gear it gets stuck in since there is a visual on what gear the vehicle is in on the dashboard. When it appears to be stuck in a gear, if you hit the gas it does not respond and you lose your speed. RPMs increase. After a delay which there is no acceleration, it then kicks into the next gear with a large jolt that shakes the whole vehicle pretty harshly. I have expressed to Ford Corporation my concerns on safety and no one was behind me during the times this has happened. If there was someone behind me I feel that I could have easily get hit from behind especially at the higher rates of speed. SUV is currently at the dealer since the first 2 service bulletins have not corrected the issue. I have been dealing with this for almost 3 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471690June 30, 2022
SUSPENSION
All four shocks leaking at 29000 miles. Replaced under warranty. Now at 35000 rear shocks starting to leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471912June 30, 2022
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Air conditioning unit has failed and after further investigation there is metal found in compressor which forces a full replacement of the AC unit. After further investigation (online forums and discussion with dealerships) this is not uncommon. The compressors are faulty and for a 5 year old car to find metal and replace air conditioning issues multiple times in past few years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471574June 29, 2022
FUEL/PROPULSION SYSTEM
Car doesn’t let me pump fuel at gas station and overfills even when the tank is empty. Gas leaks from the bottom of the car. Weird suction noise comes from the fuel filler neck. I was doing research and found that many people have this same problem with my car and there’s a recall for this but for the 2015-2016 models and not the 2017. It’s a recall on the evap system suction pump and code is 20Y6.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471576June 29, 2022
POWER TRAIN, ENGINE, VEHICLE SPEED CONTROL
Driving thru Atlanta traffic stop and go . One time I took off and all of a sudden vehicle jerk and didn’t go . NExt time it lunged forward . I notice the vehicle shutters between 20-30mph Tried to get a appointment with ford nothing available till august . Went to Panama City shopping the other day with my son he could not believe how bad the vehicle lunges sometimes and sometimes it stalls before take off . Makes me very nervous to drive am I gonna get stranded in heavy traffic ? Call ford they said needs PCM reprogrammed she tried to make appt to no avail . She knew what I was talking bout when I called her .said you need to get it in right of way .Well dealerships say they are months out what do I do now . Ford is a disgrace 80,000 for vehicle and I have had numerous issues
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468232June 8, 2022
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle to pull out of a parking lot, he heard an abnormal sound coming from the vehicle. There was no warning light illuminated. The contact was able to drive home safely. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the cam-phaser needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466680May 30, 2022
SUSPENSION
Left front strut leaked and back two struts provide very minimal dampening, which combined created a dangerous situation when banking on the interstate and hitting minimal bumps. When on the interstate at 65-70mph, if any bumps (e.g., bridge/overpass joints) are driven over the truck bounces wildly 5-8 times and the body twists, making it feel as though the truck is on the limit of controllability.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463783May 8, 2022
POWER TRAIN
During a routine trip on the highway, as I was trying to overtake a vehicle the SUV shifted from 10th gear to 1st and locked up the wheels. This left my vehicle unable to move for a few seconds while on the highway. I lost all throttle response, the vehicle lit up the wrench icon on the dash. The issue has been replicated at the ford dealership and there are currently 3 others in for repair for the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463319May 4, 2022
SERVICE BRAKES
During a recent oil change at 14299 miles (04/28/2022), I was told that the rear brake pads were dangerously low and had to be replaced immediately. I previously had an oil change and inspection by the same dealership on 11/17/2021 (10986 miles) and 6/22/2021 at 8685 miles and the brakes were checked ok with no mention of any wear whatsoever. When I asked the service manager what could have caused such a rapid deterioration of the brake pads, I was given a shoulder shake and was told that they didn’t find a problem like calipers sticking and things just happen. This car new with only a couple hundred miles on it when we bought it from the same dealer. My concern is that, at this low mileage, I could have gone longer before I brought it in for an oil change and inspection and, if the pads were that bad, we could have been in a very serious accident. The dealership non-concern about the seriousness of the defect/problem is very concerning. The service facility was QuickLane at Jones Ford, 5757 Rivers Avenue, North Charleston, SC. THE CONSUMER BELIEVED THE USE OF THE CRUISE CONTROL WAS THE CAUSE OF THE BRAKE PADS' RAPID DETERIORATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463242May 3, 2022
STRUCTURE:BODY
When getting things out of the Rear Cargo area the Lift Gate has come down unexpectedly and hit Me in the head. Several times the Rear Lift gate randomly opens when exiting or entering the car. Has hit my spouse and has come close to hitting other person walking in back of the vehicle. The Lift Gate came open barely missing the vehicle parked behind it. Would of damaged both vehicles Renegade Super C $300,000 and the Ford Expedition $85,000 along with possibly pinning and injuring the person behind the vehicle. Took the vehicle to a Ford Dealer and they ran diagnostic tests and looked for any faults and found nothing. We feel like we are driving a ticking time bomb and just missing a bullet each time we go to use the vehicle. Need immediate attention-
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition