Ford C-Max Complaints (2017)

25 consumer complaints on file.

#11712723January 22, 2026
UNKNOWN OR OTHER
On 1/16/2026, while operating my 2017 Ford C-Max Hybrid in the Bay Area, the vehicle displayed a low tire pressure warning. Shortly thereafter, the vehicle experienced a rapid mechanical or electrical failure that required me to safely pull over and exit the vehicle. Upon exiting, I observed smoke followed by open flames originating from the vehicle. Emergency services were contacted immediately, and the fire department responded and extinguished the fire. The vehicle sustained catastrophic damage and was declared a total loss. The vehicle was towed to a storage facility following the incident. No injuries were sustained. The vehicle had not undergone any recent mechanical repairs or modifications beyond routine maintenance, including an oil change approximately two weeks prior to the incident and a state smog inspection approximately one week prior. The vehicle had been operating normally prior to the warning and failure. All physical documentation stored within the vehicle, including the title, registration, and passport, was destroyed in the fire. Photographic and video documentation of the incident and damage, along with contemporaneous incident records, are available upon request.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11680455August 13, 2025
STEERING
The contact owns a 2017 Ford C-Max Hybrid. The contact stated that while driving at an undisclosed speed, the steering wheel detached from the steering column. The contact stated that the steering wheel had loosened. The vehicle was taken to the dealer, where it was diagnosed with a detached steering wheel bolt. The contact was informed that the steering wheel bolt needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 43,896.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676305July 25, 2025
TIRES
At night I noticed the indicator light came on for tire pressure drove to the next gas station to check it was flat tire I looked every where for the spare tire no luck.called dealer told me where to look. Then he checked something and said it came with a air pump under the passenger seat. I read the symbol of Instructions very confused and limited no use of car for days with ordering tire waiting for delivery and so on....
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604691July 26, 2024
POWER TRAIN
The contact owns a 2017 Ford C-MAX Hybrid. The contact stated that the vehicle failed to shift as intended and made an abnormal humming sound while driving. There was no warning light illuminated. The vehicle was taken to the dealer, where the transmission was replaced; however, the failure recurred. The contact stated while while driving at various speeds, and while coming to a complete stop, the vehicle made an abnormal humming sound. The vehicle was taken back to the dealer, where it was diagnosed that the transmission needed to be replaced; however, the vehicle was out of warranty. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604390July 24, 2024
STEERING
Steering wheel became loose. Within a week I took it into a Ford dealer who confirmed this was a serious safety concern. They worked on the problem a day later. Steering wheel bolt was damaged and would not retain torque. The steering wheel bolt was replaced by dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592716June 5, 2024
UNKNOWN OR OTHER, WHEELS:LUGS/NUTS/BOLTS/STUDS
Swollen lugnuts
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585231April 25, 2024
ENGINE, VEHICLE SPEED CONTROL
Car accelerated by itself in Drive. I'd to either apply brake or put the car in Neutral to stop it. When shifted back to D, it auto accelerated. After I got home, shut it off and after 10 min. it started working normally.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568220January 27, 2024
VISIBILITY/WIPER, ELECTRICAL SYSTEM
Rear back-up camera does not display on dashboard console screen when air temperature is cold, i.e. below about 45º, and will only turn back on when the car has sufficiently warmed up after driving some distance. This has been happening for at least two years. When the camera is not working, there is a blind spot directly behind the car. The rear of the car proximity warning signal still works, but the screen remains black. I brought this problem to the attention of the dealership service manager, who told me he could not find anything obviously wrong.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567542January 24, 2024
STEERING
The contact owns a 2017 Ford C-MAX Hybrid. The contact stated while starting the vehicle in cold temperatures, the steering wheel was locked. The contact stated that the steering wheel operated as needed after the vehicle had warmed up. Additionally, the contact stated while driving 30 MPH, the vehicle lost power steering functionality. The message "Power Steering Assist Fault" was displayed. The contact stated that he used his physical strength to steer the steering wheel, and he drove to his nearby residence. The contact stated that the failure persisted. The vehicle was taken to an independent mechanic, where it was diagnosed that the power steering rack needed to be replaced. The vehicle was then taken to the dealer, where the same assessment was made. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 50,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547291September 29, 2023
WHEELS
Lug nuts are deforming. Costco techs require 3 sockets to obtain proper torque. Two piece construction is problematic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515556April 5, 2023
ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:12V/24V/48V BATTERY, HYBRID PROPULSION SYSTEM
The contact owned a 2017 Ford C-Max Energi. The contact stated while starting the vehicle in the parking lot of her residence, there was a strong burning odor and several unknown warning lights illuminated. Additionally, the steering wheel and the brakes were inoperable, and the vehicle lost motive power. The vehicle was towed to the dealer, where it was diagnosed that the hybrid battery system had burned and needed to be replaced; however, the dealer informed the contact that there was no guarantee that the vehicle would become operable after the repair. Additionally, the contact stated that there was an unknown Federal mandate for an Extended Warranty that stated that the Ford manufacturer would cover the battery system repair for 8 years/100,000 miles; however, the dealer declined to honor the Extended Warranty. The insurance company considered the vehicle a total loss. The vehicle was totaled. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 77,250.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498618December 22, 2022
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL:THROTTLE
The vehicle accelerate on its own accord, despite no foot or pressure to the accelerator, even going uphill and including after braking. For example, ona flat road, I stepped on the brakes and began to decelerate, I released the brake and the vehicle immediately began to accelerate forward at a high speed. I had to slam the brakes to prevent further movement. This is one of many instances, the most common of which is acceleration upwards of 10-15mph after the accelerator is released. It appears as if the accelerator remains pressed forward, I can feel the accelerator move back into place significantly later than when I remove my foot. I fear for my life and safety, and that of others. The vehicle is available upon request. I have not gone to a dealer or service center. The vehicle has not been inspected, but I have read similar reports online. There were no warning lamps or messages, but the issues began October 2022, and have increased in frequency since.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11490331October 21, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2017 Ford C-Max Energi. The contact stated while driving 3 MPH, the vehicle started to stall and failed to accelerate while depressing the accelerator pedal. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer and was informed that gasoline was leaking onto the wires and spark plugs. The contact was informed that the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11479223August 14, 2022
WHEELS:LUGS/NUTS/BOLTS/STUDS
Ford Dealer Service recommends I replace lug nuts. I have 35th miles. That they are expanding and Ford cannot assure they or other repair shops will be able to remove lug nuts for repairs or replacements such as brakes, tires, etc. I read many complaints online about this problem, that the lug nut can break causing other lug nuts to break under pressure, that cause tire to fall off. They do not replace under warranty and do not discount parts. I call upon NHTSA to have Ford recall these affected cars for replacement lug nuts. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475652July 25, 2022
UNKNOWN OR OTHER
I own a 2017 Ford C-Max and share it with my husband. It is our only car so the past few weeks have been tough. Since I received my recall (22S43) in the mail, my car has been struggling to start. I believe this is due to the recall as the car is not in the correct gear to start the engine (even though I’ve been putting it in park & engaging the emergency parking brake). Yesterday, on our way home from the grocery store, our car gave us the “stop safely now” display; luckily we were close to home but it was still pretty scary. The engine had shut off. Also, I missed a doctors appointment last week because my car wouldn’t start. I almost missed my appointment for the RMV as well. Not only that but I had to cancel my trip to Lake George because the car feels unsafe to drive. I did not get a refund so the financial burden Ford is causing me for their negligence is frustrating to say the least. I bought the car a year and a half ago (Jan 2021). I have called Ford in Beverly, Framingham, Westborough, and Marlborough. None of the service departments could help me. They said that they won’t have the parts until the 4th quarter of this year. I’m not sure what to do at this point but would appreciate your help. My VIN is [XXX]. I am currently only using the car for “necessary” trips, though half of the time the car won’t start. Thanks, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472806July 7, 2022
POWER TRAIN
The contact owns a 2017 Ford C-Max. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the failure was experienced intermittently. Parts distribution disconnect. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420399June 10, 2021
UNKNOWN OR OTHER
Government vehicle was parked and unoccupied when caught fire. Damaged another government vehicle parked next to it. Both total losses. State Fire Marshal was at the scene stated that it appeared the fire started around the engine compartment.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11413387April 22, 2021
ELECTRICAL SYSTEM
VEHICLE FINISHED CHARGING, AND THEN WAS UNPLUGGED. VEHICLE'S WARNING SYSTEM SAYS VEHICLE WAS STILL PLUGGED IN AND AND WOULDN'T MOVE. VEHICLE WAS TOWED INTO DEALERSHIP AND DIAGNOSED CHARGING PORT NEEDED TO BE REPLACED. CHARGING PORT IS UNATTAINABLE AND VEHICLE SITS AT DEALERSHIP WITH NO LIGHT AT THE END OF THE TUNNEL. CHARGING PORT UNATTAINABLE, TELLS ME FORD HAS A SERIOUS PROBLEM WITH THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11402854March 14, 2021
UNKNOWN OR OTHER
THE CAR WAS IN REVERSE. MY INTENTION WAS CLEARLY TO BACK OUT OF A PARKING STALL. HOWEVER I HIT THE BRAKE, PUT THE CAR IN PARK, ATTEMPTED TO GET OUT OF THE VEHICLE BUT THE CAR KEPT GOING BACK, AT AN ACCELERATED RATE. IT WAS AS IF IT WAS GOING FULL SPEED, IN REVERSE. I COULDN'T STOP IT IN TIME BEFORE HITTING A SIDEWALK AND STAIR CASE BEHIND ME; AS WELL AS SIDE SWIPING A PARKED CAR IN THE STALL TO THE LEFT OF ME. MY DRIVER DOOR WAS DESTROYED BECAUSE IT WAS OPENED. THE AIRBAGS DID NOT DEPLOY.*DT
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11318708March 19, 2020
VEHICLE SPEED CONTROL
UNCOMMANDED ACCELERATION. THE CAR ACCELERATED TO ABOVE HIGHWAY SPEED, AND REQUIRED CONTINUAL BREAKING TO MAINTAIN CONTROL. WHEN HOME AND IN PARK, ENGINE CONTINUED TO REV TO MAX. SHUT CAR DOWN, AND WHEN RESTARTED IT RETURNED TO NORMAL OPERATION. NO OBSTRUCTION OF GAS PEDAL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford C-Max