Ford Bronco Complaints (2022)

367 consumer complaints on file.

#11659022May 5, 2025
UNKNOWN OR OTHER
Random cracks to my hard top with no damage
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658924May 5, 2025
VISIBILITY:WINDSHIELD WIPER/WASHER
The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 40 MPH in the rain and attempting to clean the windshield, the windshield washer fluid failed to operate as intended, and the windshield wipers became inoperable while driving approximately two weeks later. Additionally, the contact stated that she had noticed a fluid leak on the rear passenger's side interior door. The vehicle was taken to New Canaan Auto Body Inc., where it was diagnosed that the windshield wiper motor had failed, and the windshield washer fluid was leaking on the rear passenger's side interior door. The contact stated that additional diagnostic testing was being performed. The vehicle was not yet repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658327May 1, 2025
STEERING
When parking or turning at stop lights periodically my steering wheel will lock up and become extremely hard to turn. I get stuck in the middle of an intersection or a parking lot not being able to turn my wheel. I have had the dealership look at it however they could not recreate the issue. The only warning I can feel is the steering starts to tighten up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656844April 25, 2025
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
I am on my 3rd Fuel Pump, it is currently at the Ford Dealership. My wife was accelerating through an intersection, making a left turn, when the engine shuddered, stalled and quite running. Luckily her momentum was able to get her through the intersection and avoid oncoming traffic. The Dealer has installed the 3rd faulty pump with the previous pump only lasting 3 months. Upon research this is a widespread manufacturing issues with the 2.7 ecoboost. I firmly believe this engine/fuel pump should be recalled due to the frequent malfunctions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655164April 17, 2025
STRUCTURE:BODY
The D-pillar clips are flimsy and break easily resulting in a soft top back panel that is no longer water proof and could fall apart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654951April 16, 2025
SUSPENSION
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (SUSPENSION); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654496April 14, 2025
SUSPENSION
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that while driving 30 MPH, the vehicle bounced and veered to the right. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the rear shocks had failed and needed to be replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 23,500. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652915April 5, 2025
EXTERIOR LIGHTING
Driving in wet sticky snow the unheated LED headlamps collect snow quickly and provide almost zero projection of light forward. When driving in areas without overhead lighting at night this becomes a serious safety concern and may lead to a serious accident when drivers cannot see any possible obstructions in the roadway or accurately see the edge of the road surface. Have been unable to demonstrate this flaw to any dealers due to snow being unpredictable and dealerships being closed at night. I do have dash cam video showing the issue that can be provided for review, video uploaded to youtube here [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652151April 1, 2025
SUSPENSION
The vehicle is a 2022 Ford Bronco Badlands 2 door. It is under NHTSA recall 25V025, with no fix expected until later this year. The ride quality is bouncy, with some wobbling when going over bumps. Ford claims the vehicle is still okay to drive; however i am not comfortable with having to deal with the ride quality for the next several months
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652129April 1, 2025
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
On 03/31/25 at approx. 12:45 AM our 2022 Ford Wild Trak was engulfed in fire while parked on our driveway. There were no occupants, and it had last been operated on 3/30/25 at approximately 1030 PM. During its last operation there was nothing abnormal to indicate the potential of a engine fire (no warning lights, messages, unusual smell or odors, performance issues, smoke, or fire). Upon observing the Ford Bronco Wild Trak for the first time the engine compartment was fully engulfed, and it was clear the fire had started in the engine compartment. The flames from the Ford Bronco Wild Trak eventually spread to a second vehicle destroying it down to the frame and causing enough damage to a third vehicle rendering it a total loss. All three vehicles were within 4 feet of our residence and the flames were hot enough it melted the garage door window frames. The Ford Bronco Wild Trak is frequently parked in our garage, and it been we would have lost our home and the lives of all four family member would have been put at risk. Researching Ford Bronco Wild Trak engine fires, we discovered that Ford Bronco Sports and Ford Escapes both have recalls due to faulty fuel injectors resulting in engine fires. The fuel injectors in Ford Bronco Wild Trak’s are similar to the fuel injectors in both the Ford Bronco Sports and Escapes. Due to the similarity between the Ford Bronco Sports and Escapes with the Wild Trak fuel Injectors we are asking for the NTSBA to initiate an investigation into Ford Bronco Wild Trak engine fires. The Ford Bronco Wild Trak can be retained for inspection if requested quickly as it is scheduled to be picked up by our insurance company and then disposed.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11649549March 20, 2025
SUSPENSION
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645588February 28, 2025
STEERING
The contact owns a 2022 Ford Bronco. While the contact’s daughter was driving at various speeds, the power steering malfunctioned, causing the steering wheel to become difficult to turn in either direction. The vehicle was taken to the local mechanic who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645511February 28, 2025
SUSPENSION
The contact owns a 2022 Ford Bronco. The contact stated that there was grease leaking from the driver's side axle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V025000 (Suspension). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer, Kearny Mesa Ford (7303 Clairemont Mesa Blvd, San Diego, CA 92111); who determined that the fluid was Armor All. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that there was no recall coverage on the VIN and referred the contact to the NHTSA Hotline. The failure mileage was approximately 1,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644537February 24, 2025
FUEL/PROPULSION SYSTEM
While idling, the engine died. I attempted to restart several times with no luck. Battery was working, but engine would not start. Towed to Ford dealership and had to have the fuel pump replaced. Car had around 10k miles and recently went through an inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643858February 20, 2025
POWER TRAIN
My 2022 Manual transmission has been making a scraping sound when cold since I bought it. I've had 2 dealerships not do anything about it and I feel for paying $65,000 for a vehicle, it shouldn't be making this noise and it could be a safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643425February 18, 2025
SEATS
All metal components of the seat have rusted and corroded. The seat is no longer safe and its structural integrity is compromised. This is on the Black Diamond trim package where the interior of the car is marketed and sold as weatherproof with sealed electronic components, marine grade vinyl upholstered seats and drain plugs installed in the floor board to empty water from the floor boards Ford Motor Co has denied the bumper to bumper warranty on these seat components stating that the seat was exposed to moisture This is the ford bronco that is pictured in advertisements and marketing materials with no roof or doors installed, and has supplements and guide materials provided with the owners manual that outlines practices to drive through water / rivers My truck has never been through any standing water
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643416February 18, 2025
SEAT BELTS
The seat belt stem on the buckle receiver has corroded and snapped. This is on the Black Diamond trim package with marine grade upholstered seats, weatherproof electrical switches and buttons in the interior and drain plugs on the floor boards from factory. The metal stem of the seat belt receiver is bolted to the body of the truck, encased in rubber and has corroded and snapped in half. Ford motor co. has denied the bumper to bumper warranty on this part, stating that moisture exposure is evident . This is the vehicle that is marketed and intended to be hosed out with water to clean after off-roading . This is the same Bronco model that is pictured in advertisements with no doors or roofs installed visiting beaches, driving through rivers and climbing mountains It is obvious that the seat belt components have not been treated or coated with any enamel or coatings. From factory all seatbelt components are bare clean steel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643225February 17, 2025
SUSPENSION
Hazardous Recall Issue Not Being Addressed Short Term With Permanent Safety Solution Many Months Away Creating Liability For Me, Destroying My Property and Putting Myself and Other Motorist In Jeopardy. For the past month fluid from my Ford Bronco has been leaking leaving stains on newly paved driveway. We just received the following recall... REAR SHOCK ABSORBERS MAY EXPERIENCE CORROSION BETWEEN THE EXTERNAL RESERVOIR MOUNTING FLANGE AND THE DAMPER BODY, RESULTING IN POSSIBLE SEPARATION OF THE EXTERNAL RESERVOIR. CUSTOMERS MAY EXPERIENCE... LEAKING FLUID NEAR THE REAR WHEELS PRIOR TO THE DETACHMENT OF AN EXTERNAL RESERVOIR. Safety Risk IF A REAR SHOCK ABSORBER EXTERNAL RESERVOIR SEPARATES FROM THE VEHICLE, IT CAN CREATE A POTENTIAL ROAD HAZARD FOR OTHER ROAD USERS, INCREASING THE RISK OF A CRASH. Even though the notice says the recall resolution is not expected for over 6 months, I was willing to pay the deductible for my Ford Warranty to get the safety issue fixed, even if I never get reimbursed for Ford's vehicle issue. Since this is a safety issue and are fearful of the the reservoir tank separating since our vehicle is already loosing significant fluid from the reservoir. I brought my vehicle into the local Ford dealership and they confirmed the issue with my car is the same regarding the Recall notice. Even with the warranty, Ford has rejected the claim to replace the shock absorbers. So now I just have to wait while it destroys my driveway and hope a detachment doesn't occur and jeopardize either myself or others driving around me. For reference I'm including my warranty claim # that was rejected with Ford - [XXX]. Happy to provide VIN (instructions say not personal info here). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642325February 12, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact stated that while driving at approximately 30 MPH the vehicle lost motive power. The vehicle was steered to the side of the road. The vehicle failed to start immediately. The contact stated that after the vehicle was started, the vehicle started shuddering. The vehicle was towed to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 14,654.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642266February 12, 2025
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2022 Ford Bronco. The contact stated that while driving at undisclosed speeds, the “Powertrain Malfunction - Reduced Power Fault” message was displayed and flickered on and off. The contact that the battery was losing the charge. The contact stated that the battery was at 70% charge. The contact related the failure to NHTSA Campaign Number: 24V683000 (Power Train, Electrical System). The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 36,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco