Ford Bronco Complaints (2025)

56 consumer complaints on file.

#11709688January 8, 2026
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
While driving, after a missed downshift that causes engine bogging, the vehicle experiences a loss of engine power. The engine remains running but will not produce usable torque and will not rev above approximately 800 RPM, despite clutch disengagement and selecting the correct gear. Holding the clutch fully depressed does not immediately restore power; instead, after approximately 4 seconds, the engine stalls or cycles/resets, after which normal operation resumes. The condition persists until the vehicle nearly stops, the engine stalls, or the ignition is cycled. This has occurred in traffic and adverse weather conditions and is repeatable.”
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707925December 30, 2025
EXTERIOR LIGHTING
Description of Incident: > While driving in freezing drizzle/sleet conditions in northern Minnesota, the factory-installed LED headlights on my 2025 Ford Bronco became obscured by ice buildup within 15 minutes of driving. The Safety Issue: > the LED headlights do not produce sufficient heat to melt frozen precipitation. This resulted in a degradation of forward visibility during nighttime driving, creating a safety hazard. I was forced to pull over repeatedly on a high-speed roadway to manually scrape ice from the lenses. Request: > I am reporting this as a design defect for vehicles sold in northern climates. The lack of a heating element or de-icing mechanism in the standard LED equipment makes the vehicle unsafe for nighttime driving during freezing weather with high humidity conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703800December 8, 2025
ELECTRICAL SYSTEM, STEERING, VEHICLE SPEED CONTROL
Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, an 18-wheeler in the lane beside me was merging to his right. The sudden loss of my IPC screen meant I could not see my speedometer, warning indicators, safety messages, or any visibility cues needed to safely judge traffic speed and spacing. This created an immediate hazardous situation and made it extremely difficult to manage both my own speed and the surrounding traffic patterns. As I recognized the danger, I attempted to brake and avoid a collision. During this moment, my steering wheel began to shake slightly—possibly due to the lane-keeping or lane-safety system responding. Despite my efforts to correct and avoid impact, the 18-wheeler collided with my vehicle. At the time of the crash, I had no visibility of any dashboard warnings, alerts, vehicle speed, or safety notifications due to the IPC failure. My insurance representative has inspected my vehicle and deemed it a total loss.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11702675December 3, 2025
EXTERIOR LIGHTING
Driving in sub-freezing temperatures with snow/rain falling and slush on the road, the headlights iced over with thick slush and ice and reduced visibility to dangerous levels requiring me to pull off the road and chip off the ice putting myself in a dangerous situation being on the side of the road during a storm.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699271November 13, 2025
POWER TRAIN
The slave Cylinder failed causing the clutch to not fully disengage burning out the clutch at only 783 miles on the vehicle. Ford headquarters claims driver misuse, dealership disagrees at such low mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694461October 20, 2025
UNKNOWN OR OTHER
When I purchased my vehicle I noticed the round rod that contains the backup camera, which is mounted on the spare tire bracket to be all scratched and scruffed up. The dealership (Hawk Ford, Carol Stream) agreed to replace this. Their are scratches inside where the camera sits around the threading and the rod it self is all banged up. I showed the dealer ship this and they replaced the mounting bracket, not the rod so when I got my car back I contacted them right away and sent before and after pictures. Manager went into lot and said all of the other ones he checked had the same issue. He was going to contact Ford to see if they were aware and how to go about this concern affecting my vehicle and all others on their lot. It should be new with no physical defects, but it appears used. When you buy a new car, you expect everything to be new and look new but this does not.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692761October 11, 2025
ELECTRICAL SYSTEM, SEAT BELTS, VEHICLE SPEED CONTROL
The display panel for the speedometer and gas would not work or display anything.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691762October 7, 2025
ELECTRICAL SYSTEM
Description of the Problem: The issue involves the speakers and radio system in my 2025 Ford Bronco. The audio system intermittently cuts out completely, resulting in a total loss of sound. This includes music, phone calls via Bluetooth, and most importantly, navigation voice instructions. The component (the vehicle’s speaker/radio system) is still installed in the vehicle and available for inspection upon request. Safety Risk: This malfunction poses a safety risk while driving. When using navigation, if the sound cuts out unexpectedly, I am forced to look down at my device for directions, which distracts me from the road and increases the risk of an accident. In modern vehicles where navigation and hands-free systems are standard for safe driving, losing audio output directly impacts driver safety. Reproduction and Confirmation: The problem has been reproduced and confirmed by my local Ford dealership on two separate visits. The service department acknowledged that they are aware of the issue affecting multiple vehicles but stated that there is currently no available fix from Ford. Inspection: The vehicle has been inspected by the Ford dealership twice. They ran diagnostics and confirmed the issue originates from the speaker/radio system, but no replacement or repair has been offered at this time. The manufacturer (Ford) has not provided a technical service bulletin or recall to address it. Warning Signs or Messages: There were no warning lamps, error messages, or prior symptoms before the failure. The sound loss occurs randomly while driving, without any visible indicator or pattern. The first occurrence was shortly after purchasing the vehicle in September 2025, and the issue has continued intermittently since.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685755September 8, 2025
FUEL/PROPULSION SYSTEM, ENGINE, VEHICLE SPEED CONTROL
I was driving the vehicle on high mountain pass roads in Colorado. Anytime I would approach approximately 11,400 feet of elevation. The vehicle would instantly lose all power with no warning lights of any kind. All gauges were in the normal operating range. Vehicle would barely move 2 mph. Created a very unsafe condition on narrow steep dirt roads in the mountains. As soon as I turned around and descended approximately 100 feet in elevation the power came back instantly and vehicle operated normally. This happened on three occasions. The roads we were on were narrow, off-road vehicle mountain roads, and it created an extremely dangerous situation. I contacted Ford and they have not heard of this issue and there are no recalls associated with it. I spoke to a Ford bronco ambassador, who was also on the trail system with a lot of other off-road vehicles, including Broncos and they had never heard of this happening . This vehicle is Six months old. Ford says there are no codes set on my computer and since they cannot duplicate this where I live in Phoenix because there are no roads high enough I don’t know where to turn.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685095September 4, 2025
AIR BAGS
New vehicle sold to me by Paul Miller Ford Mazda, 975 East New Circle Rd., Lexington, KY 40505 with an open, uncured, undisclosed recall regarding vent flap on passenger airbag.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681145August 17, 2025
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION
Repeated cross traffic alert and blind spot alert fault message.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679470August 8, 2025
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
2025 Bronco Sport Safety Recalls* Replace instrument panel cluster Recall incomplete Block heater element replacement Recall incomplete Cylinder head replacement Recall incomplete Cylinder head inspectionreplacement Recall incomplete DO NOT DRIVE! RECOMMENDED TO REPORT NATIONAL ALERT FOR OWNERS OF THIS VEHICLE TYPE. INVESTOR REPORTING FOR BROADCAST RECALL ALERT!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673148July 13, 2025
UNKNOWN OR OTHER
Vehicle was parked in driveway and put into park. After getting out of vehicle and walking into house we noticed the car started to roll forward and by the time we could react the car was picking up speed and rolled into a tree at the end of our driveway. A few days prior while driving 40 mph near our house the car inadvertently went into neutral without notice and without switching the gear shifter and we had to put the shifter back into drive while moving.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11666498June 12, 2025
UNKNOWN OR OTHER
ABS light going off when parked in reverse on an inclined hill with the left side of vehicle on a higher level than right. Pre collision showing as unavailable as well as Service AdvancTrac and Park brake Limited function Service Required all displayed on odometer screen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666494June 12, 2025
UNKNOWN OR OTHER
Child safety locks on back left door do not lock allowing back seat passengers to open door freely and endangering everyone in vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655457April 18, 2025
ELECTRICAL SYSTEM
When starting my commute to work and when returning home, the instrument panel and gauges display would not turn on. After power/engine restart and open/close driver door, I drove off and about 10 minutes into drive the instrument panel and gauges display started working. On the way to work I pulled over and took a photo. On the way home I sat in parking lot at work and videoed trying to get display to work. Vehicle security system was installed the day *after* the display failure, 04/18/2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco