Ford Bronco Complaints (2025)

56 consumer complaints on file.

#11739412May 21, 2026
VISIBILITY/WIPER
I am filing a safety complaint regarding repeated windshield cracking on my new 2025 Ford Bronco. I purchased the vehicle approximately 2 months ago. Since purchase, the vehicle has experienced 3 separate windshield cracks under normal commuting use only. The vehicle has not been used off-road or in extreme driving conditions. The most concerning issue is that after the windshield was replaced, the replacement windshield developed another crack within approximately 24 hours of installation. The dealership has repeatedly classified the damage as “normal road debris” or “rock impact,” but I am concerned this may involve a structural, installation, or manufacturing defect rather than ordinary wear and tear. My concerns are based on the following: Multiple windshield failures in a very short period of ownership Failure occurring on a brand-new replacement windshield within 24 hours Normal commuting use only Concern for stress-related cracking, improper installation, body/frame flex, or windshield mounting issues Potential safety hazard involving driver visibility and windshield integrity I am requesting investigation into possible manufacturing, installation, or structural defects involving windshield cracking or windshield mounting systems on the 2025 Ford Bronco. I am also aware of other Ford Bronco owner complaints involving repeated windshield cracking and windshield-related issues. This issue creates ongoing safety concerns due to impaired visibility and repeated glass failure in a nearly new vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739096May 20, 2026
ENGINE
On [XXX] at [XXX] PM I was driving westbound on [XXX] at [XXX] while traveling through the intersection, my vehicle started shaking, lost acceleration, and nearly caused me to have a collision. My vehicles check engine light began flashing, and I was able to safely exit the highway. On May 20, 2026, Crouse Ford diagnosed a “cylinder #6”, however attributed the event as “an anomaly”, and no corrective action was taken despite the seriousness of the safety concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738844May 19, 2026
STRUCTURE:BODY
This is in reference to Safety Campaign 26S32. My fiancé owns a 2025 Ford Bronco 5 door and her roof has the same exact issue that is described in this safety campaign. Before the vehicle had 5000 miles on it the roof had already begun to show cracks, honeycombing and is beginning to show signs of delamination. The vehicle is going to our local dealer in a week to hopefully have the roof replaced under warranty but I doubt that permanently fixes the issue. Fords comment that they have resolved the issue is patently false. I will gladly send photos of the cracks as soon as possible but this safety campaign, in my opinion, should be extended to all of Broncos from 2021 to current.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738527May 18, 2026
POWER TRAIN
The contact owns a 2025 Ford Bronco. The contact stated while attempting to start the vehicle depressing the brake pedal, heard a clunking noise and on for second the vehicle attempts to move while in park. The contact mention he could hear clunking sound coming from the front of the vehicle. A dealer was contacted. The vehicle was taken a dealer to be diagnosed, however the diagnoses was unknown. The vehicle was not repaired. The contact was relating the failure to NHTSA Campaign Number:25V164000 (Power Train), however the VIN was not included in the recall The manufacturer was not notified on the failure, and they informed him to take the vehicle to dealer. failure mileage was 2,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734395April 28, 2026
POWER TRAIN
After only 880 miles, the clutch and cylinder have failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732854April 21, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS
Sunday April 19 2026, in a drive thru while stopped, the following alerts popped up with their corresponding dash lights: Check Brake System Park Brake limited service function Pre-collision assist not available Service Advance Track Brake pedal lost vacuum / pressure and became hard. Brake would not engage and needed to use electric park brake to stop vehicle. Got out of the drive thru and into an empty parking lot. I tried accelerating and then stopping but vehicle would not stop while pressing the brake. Used e brake again to stop. I turned vehicle off and back on. All errors did not pop up again and there were no lights on the dash. While driving home less then a mile from original incident location, the same errors and brake failure occurred while going 30+ miles per hour. Same issue with a hard brake pedal occurred. This time, if brake pedal was depressed far enough, the e brake would engage but only the rear wheels would lock up and vehicle would skid/slide in order to slow down. I have video recordings of these incidents. Brake system failed as vehicle lost ability to brake at low and high speeds. The loss of brakes could result in a car crash and deaths. The vehicle has been towed to a ford dealer and they are in possession of the vehicle. They are currently investigating the issue. The vehicle has not been inspected by manufacturer or authority agency. There were no warning lamps, messages, or symptoms prior to the brake system failing. The brakes worked normally and then suddenly failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731881April 17, 2026
UNKNOWN OR OTHER
Crain Ford in Jacksonville Arkansas (72076) sold me this vehicle while it was under a national stop-sale with an active recall and expected me to make payments on the loan while they held the vehicle for several months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730482April 10, 2026
SUSPENSION
Description: My 2025 Ford Bronco suffered a catastrophic failure of both rear shock absorver external reservoirs, consistent with Recall 25S01 (NHTSA 25V025). The reservoirs detached intirely while driving out-of-state, forcing an 800-mile transit with 5 passengers on an unstable suspension. Issue: Upon presenting the vehicle to Interstate Ford, the dealer and a Ford Representative issued a formal denial of warranty coverage. They cited Claim Type 14, Condition Code 39 ("Missing Part"). Why it's a Safet Risk: Ford is using the severity of the defect - the fact that the part sepearated - as a reason to deny the repair, even though Recall 25S01 explicitly warns that the defect causes "seperation fo the external reservoir." This is a refusal to remedy a known safety defect that has already caused a hazardous driving condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729064April 3, 2026
BACK OVER PREVENTION
The contact owns a 2025 Ford Bronco. The contact was made aware by the Turo App that the VIN was associated with NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727443March 27, 2026
ELECTRICAL SYSTEM
This vehicle had an open safety recall at the time the dealership sold it to me. The recall existed before the sale and the dealership knew or should have known about it. The dealer submitted loan paperwork and accepted funding but never delivered the vehicle to me. I was not informed of the open recall before signing. This is a safety and compliance issue involving a dealer selling a vehicle with an unrepaired recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725648March 19, 2026
AIR BAGS
On oct. 26, 2025, I was in a bad car accident. I was coming home and came to a stop on Spring Street.In Marion. MA before entering Rte 6 . I looked both ways and the rte was clear. I looked again both ways and still was clear, so I moved my 2025 Bronco Badlands onto the Rte 6 and within seconds I was hit very hard on the front left quarter. My SUV spun around at least 270º and I was immediately taken to the ER nearby (Tobey Hospital) for Brain and neck Studies. No airbags deployed. I have photos of the vehicle showing my damage. The driver of the other car must have been speeding as the hit was huge. I was the sole person in my car. The Marion PD Officer who was in charge of this accident changed the story to say "I looked both ways, saw a car coming and I moved forward" into Rte 6 to get home around the corner. I had injuries all over my body and brain with concussion/mild TBI. There were no witnesses and the building near the scene of the MVA had a professional camera over their front door. They would not let me see the video. They did let the other driver see the video The angle of this cam was changed from straight across the street looking at the scene directly. I had no way of knowing what happened and I have spent about a half a year getting therapy at three different physical therapy sites/hospital. I asked the Police to see if I could ask the State Police if they would do a Collision Analysis and Reconstruction so I could know what happened as I was labeled At Fault which I understood if the other driver was driving normally and safely. I was told that if no one is seriously hurt or dead then they would do it. I lost my memory and am still getting visual changes and severe headaches. The series of Radiologic images show that I had lots of Damage. I am a XXX Physician and I know I was hit by surprise and never saw the other car because of the angles of the road. I told photos and have images of the scene and of my car and the other car
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11725055March 17, 2026
ENGINE AND ENGINE COOLING
The contact owned a 2025 Ford Bronco. The contact stated while driving 30 MPH, another driver pulled closer to the vehicle and honked to get the contact's attention. The contact stated that upon rolling down the window, the contact noticed flames coming from the front driver's side wheel well. There was no warning light illuminated. The contact was able to pull over to the side and exited the vehicle. The contact stated that the vehicle completely burned from the front end to the front seats. The contact stated that the fire originated from the driver's side of the engine compartment. The front driver's side of the vehicle sustained more fire damage than the passenger's side of the vehicle. The fire was extinguished by the fire department. A fire department report and a police report were filed. There was no reported injury. The vehicle was towed to a tow yard. The vehicle was a total loss. The dealer and the manufacturer were not contacted. The failure mileage was approximately 13,500.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11724861March 17, 2026
BACK OVER PREVENTION
The contact owns a 2025 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723822March 12, 2026
BACK OVER PREVENTION
The contact owns a 2025 Ford Bronco. The contact was made aware of NHTSA Campaign Number: 26V124000 (BACK OVER PREVENTION) after contacting the manufacturer. The contact had recently purchased the vehicle and was not informed about the recall. The contact became aware afterwards that the part was not yet available. The local dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722984March 9, 2026
UNKNOWN OR OTHER
I am sending this to anonymously report a critical compliance issue at Stivers Ford in Birmingham, Alabama. They are actively selling brand-new vehicles with active safety recalls. Dealership employees have openly admitted to taking brand-new, never-titled vehicles and delivering them to end consumers. They are doing this even though recall 26S09 is still active and it has absolutely no remedy available right now. This is a HUGE safety problem. The Proof: • Stock B9380, VIN [XXX] • Stock B9259, VIN [XXX] These two units are just the tip of the iceberg. I am confident that a deeper look will uncover many more cases across all of their dealerships. We need to look into this and make sure they stop delivering unsafe vehicles immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719134February 19, 2026
SERVICE BRAKES
I have experienced three total brake failures in my 2025 Ford Bronco. During the most recent incident on 2-18-2026 the brake pedal traveled completely to the floorboard, requiring extreme force and multiple pumps to stop the vehicle. This appears to be the exact failure described in Ford Recall 25S77 (NHTSA Campaign 25V488) regarding the Electronic Brake Booster (EBB) module. The vehicle was presented to Suntrup Ford twice previously for this issue, but the defect was not corrected. I am reporting a life-threatening safety failure. After February 18th 2026 brake failure I had bronco towed to Suntrup Ford in Kirkwood Missouri and that's where it will stay. I am too frightened to drive it again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719009February 19, 2026
SERVICE BRAKES, STEERING, ENGINE
on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11716568February 8, 2026
STRUCTURE:BODY
Structural crack in molded in color roof compromising the integrity of vehicle roof.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714693January 31, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. Brake function returned and I drove it to a Ford service center about 1 mile away. They were not able to reproduce the problem or find any DTCs. I did get notifications of some of the faults to my Ford app on my phone. I am uploading the redacted RO and screenshots of the Ford notifications. Losing braking obviously put myself and my passenger pregnant wife at risk. Thankfully I was moving at lower speeds on a flat section of road and not taking a highway exit at the time of failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711063January 15, 2026
ELECTRICAL SYSTEM, ENGINE, VEHICLE SPEED CONTROL
While slowly backing into our home garage, the vehicle accelerated brakes were not working and smashed into the side of the house, put the car in drive to move it. It accelerated forward over correcting and drove into our power box and came to a halt. No brakes were working and the wheels/steering locked up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco