Ford Bronco Complaints (2022)

367 consumer complaints on file.

#11554328November 9, 2023
POWER TRAIN
Ford is experiencing a problem under normal driving conditions on multi year Broncos (21' to current) that have very limited miles - with regards to the front pinion seal leaking badly (noticed during a routine oil change) and it appears to be IMHO a design flaw that not only impacts the seal but also the front differential, internal parts and possibly the axle. Any disruption to the drive train has the potential beyond just rendering the vehicle inoperable,..while driving in 2 or 4WD conditions, the impacts could be widespread. IMHO, Ford needs to look at the design and redesign and test. This has also happened multiple times on the same vehicle (from Bronco6G forum reports). In addition to the recall - Ford should immediately publish a TSB on this as wel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11552190October 27, 2023
POWER TRAIN
The contact owns a 2022 Ford Bronco. The contact stated that while stopped, the contact noticed that the vehicle would not move after it had gotten towed. the wrench and service engine warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the failure was due to the transmission independently engaging and the transmission had overheated fluid, the transfer case had failed as well. The vehicle had been replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11551355October 23, 2023
VEHICLE SPEED CONTROL:CRUISE CONTROL, SERVICE BRAKES, HYDRAULIC
The contact owns a 2022 Ford Bronco. The contact stated that with the cruise control activated, the brake pedal failed to respond as needed with the "Check Brake System" message displayed on the instrument panel. The contact was forced to disengage the cruise control or depress the brake pedal to the floorboard. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549695October 12, 2023
ENGINE
Once the vehicle hit around 3000 miles it started making a loud clicking noise while the vehicle was running parked or driving . The noise continued to get louder. When I called New Brighton Ford where i purchased the vehicle brand new on 4/25/23 at the end of June I was told to make a service appt. The soonest they could see the vehicle was 4 weeks later. Because of the continued noise I called on about July 12 2023 they agreed they would look at it upon looking at the vehicle. It was found that the engine was in engine failure. They kept the vehicle for six weeks and had to replace to the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549426October 11, 2023
ENGINE
2022 Ford Bronco loss power while driving moderate speed (35 - 55 MPH) and would not immediately restart after the first attempt. After finally restarting it would continue to stall. The car was towed to the dealership where after four weeks of investigating they found the catalytic converter to be melted. The car has now been sitting at the dealership for 7 weeks with an "indefinite lead time" on replacement parts. My Bronco only has 14,000 miles on it and no determination on what caused the catalytic converter to melt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548402October 5, 2023
BACK OVER PREVENTION
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 22V825000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while reversing, the back over prevention system was inoperable. The dealer was made aware of the failure but confirmed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed by dealer and the manufacturer informed that her vehicle had an 8'inch screen and the software update did not apply to her vehicle. The failure mileage was approximately 14,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548241October 4, 2023
SERVICE BRAKES, ENGINE, ELECTRICAL SYSTEM
BRAKE PEDAL KICKS BACK ON OUR FOOT WHEN STOPPED BRAKES DONT WORK GOOD LOST BRAKE FLUID MUST PUMP BRAKES TO COME TO A STOP OR SLOW DOWN ON GOING FOR A YEAR NOW DEALER DROVE FOR ONLY NINE MILES THEY SAID ITS OK STILL HAVE THE PROBLEM - ENGINE HAS LOST POWER WHEN HOT - WHEN IT IS COLD ON START UP THE MOTOR RUNS ROUGH AND LACKS POWER DEALER HAS NOT LOOKED AT THE ENGINE PROBLEM YET -TURN SIGNALS WILL TURN WHEN TURNING RIGHT WHEN IT IS CANCELED IT WILL TURN THE LEFT TURN SIGNAL ON SAME THING GOING TO THE LEFT IT TURN THE RIGHT ON ON -ALL PROBLEMS ARE STILL ON GOING AS OF 10-4-2023
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548199October 4, 2023
BACK OVER PREVENTION
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 22V825000 (Back Over Prevention) however, the software update to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact's daughter had been in reverse (R) and reversing in a parking lot at approximately 2 MPH, she crashed into another parked vehicle with her rear bumper. The contact's vehicle had minimal damage on the rear bumper. The other vehicle had damage to the passenger side taillight and to the rear passenger panel which had been dented by the contact's bumper. The police were called, the other vehicle was not occupied at the time of the crash, and a report had been written. The contact's daughter stated that the camera was not functional at the time of the crash. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000. Parts distribution disconnect.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11547892October 3, 2023
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
multiple lights on dash turned on also check engine light' loss of power and jerking of vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11544762September 15, 2023
UNKNOWN OR OTHER
The hard top convertible is leaking in multiple areas. Primary location is behind the second-row drive side between trunk area and back seat. Other area is between the two front seats in the center. The gaskets have been replaced one time already and its back at local Ford dealership a second time for same problem. Dates for repairs include 8/9/23 and 9/11/23.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11544249September 13, 2023
STRUCTURE:BODY
4 door hardtop roof leaks. It is available. There is nowhere, including Ford website, to report non-safety defects.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540477August 24, 2023
SEAT BELTS
Rear Middle Seatbelt extremely difficult to access. It is a different seatbelt than rear passenger and rear driver so seatbelt extenders are not available or do not work. Seatbelt sits to low for access for passengers, especially children in car seats.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539538August 19, 2023
ELECTRICAL SYSTEM
Owner's ford bronco 2022 continues to exhibit unsafe behavior: where after entering 4L, reversing and then moving forward (manual transmission), the rear camera will not disable until the vehicle is shut off. Despite active recall sent from Ford (in post card) as well as present on NHTSA on this vehicle (ford bronco 2022) after reaching the dealership in person, calling ford headquarters. Ford motor company mentions there is no active recall, software is updated, and there is nothing they are able to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11536141August 2, 2023
UNKNOWN OR OTHER
The whole truck shut off, dashboard, stereo, engine, while driving and in gear. Had to drift over safely to a stop to restart the engine. The safety of my children and myself were in danger due to this catastrophic failure. No warning lights, no previous problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11533263July 19, 2023
STRUCTURE
The contact owns a 2022 Ford Bronco. The contact stated while driving 65-70 MPH, the contact stated that the soft top of the roof made abnormal popping sounds, causing uncomfortable ear pressure. The contact rolled down the windows for the popping sound to cease. The vehicle was taken to the dealer, but no assistance was provided. The manufacture was contacted, and no assistance was provided. The failure mileage was 67.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530924July 7, 2023
SEAT BELTS
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 23V358000 (Seat Belts) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530746July 6, 2023
SEAT BELTS
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 23V358000 (Seat Belts) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529929July 1, 2023
UNKNOWN OR OTHER, ELECTRICAL SYSTEM, BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The soft top on the 2022 four door Bronco does not properly latch. I know earlier years and some 2022s were recalled for this but mine has not been recalled and it needs to be addressed. Also the back up camera and 360 cameras do not work
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529774June 30, 2023
VISIBILITY/WIPER
While wipers are in full-time mode, they will occasionally switch to intermittent mode even though rain continues to accumulate on the windshield. This forces me to take my left hand off the steering wheel to 'reset' the wiper system while driving with limited windshield visibility. Taking my hand off the wheel during a downpour is unsafe and should be the last thing I need to be concerned about. My vehicle is available for inspection. Dealership replicated the fault on similar Broncos and said it was 'normal operations'. They claim that the wipers go into intermittent mode so the wipers motor doesn't overheat. However, there is plenty of rain on the windshield when I've experienced the transition to intermittent mode. No warning lamps, messages lit up during this failure. I have a video available that documents this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529613June 29, 2023
STEERING
The contact owns a 2022 Ford Bronco. The contact stated while driving 10 MPH, the vehicle violently pulled to the left and crashed into a guard rail. Additionally, the contact stated that the vehicle made abnormal sounds. No warning lights were illuminated. The contact stated that on the Mobile App, she was notified that the power steering assist had failed, along with other unknown messages. The vehicle was towed to a tow yard and was then towed to a body shop. A Police report was filed. The contact had not sustained any injuries. The vehicle was not diagnosed. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 7,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco