Ford Bronco Sport Complaints (2021)

677 consumer complaints on file.

#11640950February 5, 2025
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
Immediately after the driver started the car, many notifications popped up on the dashboard including: cross traffic system fault, service vehicle soon, full accessory power active, hill start assist not available, service AdvanceTrac, Engine Coolant Over Temperature, and Cross Traffic System Fault. The gauge showed fuel empty and other dashboard indicators were illuminated such as engine, battery, oil, seatbelt, airbag, faulty blindspot monitoring, and traction control. Driver took pictures of these notifications and indicators for documentation. Driver turned off the car and discovered recall # 25S02 for the vehicle. Owner recognized the notification explosion from similar experience on May 5, 2024 in reference to recall # 24V267000. In May 2024, the notification system showed all of the above alerts before the vehicle shut off and lost power. At this time, the vehicle was traveling at 60 mph on the interstate. Driver was fortunately able to exit and get to a parking lot before losing steering control. Vehicle would not restart, even with a jump. The vehicle was towed to dealer, however, dealer would not honor the issued recall as it was "not yet active". The dealer replaced the battery and alternator (deemed to caused by faulty battery included in recall) at expense to the driver. Driver was not reimbursed. The manufacturer was notified for May 2024 incident and again after February 4, 2025 incident. Vehicle was towed on 2/5/25 to dealer for service. Despite the active recall, there is "no current remedy" for the problem. Driver is expected to pay all costs (i.e., tow, service parts, rental car) to HOPEFULLY be reimbursed by the manufacturer once the recall solution is released. The fact that the same issue occurred with a second recall under a year is a huge inconvenience and safety risk. Current recall states, "vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640933February 5, 2025
POWER TRAIN, ELECTRICAL SYSTEM, ENGINE
Driver was driving on the interstate. The car flashed several electrical system failure issues and notified that the alternator no longer functioned and that the system would then pull from the battery. The battery light came on and then flashed several warnings along with sounds. Driver was luckily able to exit the interstate and make it to a parking lot off before vehicle lost all power. Once parked and turned off, the accessories like radio and dashboard screen and lights were still functioning. The car would not start until we jumped it. Afterwards the car would not switch gears and then again flashed the electric system was experiencing failure. This and along with some whirring sounds from under the hood (what I could hear from driver seat), gave me enough reason to stop trying altogether to avoid further issues. After turning the car off, the dashboard flashed errors saying that features like electric braking, lane assist, and others were not available. Car was towed to dealership. Owners notified Ford dealership of recall # 24V267000 for the vehicle on 5/5/24. Dealership said it was not yet active recall (although issued by Ford on 4/11/2024), refused to pay for new battery and alternator needed (caused by the defunct battery- part of the recall). Owner paid out of pocket and was not reimbursed for replacement parts covered by the recall. The vehicle shutting off abruptly while driving at a high speed could have caused injuries or deaths.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640501February 3, 2025
ELECTRICAL SYSTEM:12V/24V/48V BATTERY, ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford Bronco Sport. The contact stated while stopped at a traffic light, the vehicle lost electrical power and stalled. The contact stated that several unknown warning lights illuminated before the screen went black. The vehicle was towed to the dealer, where it was diagnosed and determined that the battery had failed. The contact was informed that the battery did not support the function of the vehicle and needed to be replaced. The battery was replaced. The contact stated that on another occasion, while driving at undisclosed speeds, the heating system failed. The contact stated that the passenger’s side vents were not blowing hot air. The vehicle was taken to the dealer, where it was diagnosed that the water pump and gaskets had failed and needed to be replaced. The vehicle was repaired. The failure mileage was approximately 43,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640494February 3, 2025
POWER TRAIN, ENGINE, UNKNOWN OR OTHER
I bought a 2021 Bronco Sport Brand new and ever since the car has been a problem. The rear axle wasn’t getting enough lubricants so it was grinding and I didn’t know what it was at the time but I took it to a Ford dealership and was told after spending 200$ on diagnostic testing that absolutely nothing was wrong with the vehicle. The vehicle kept doing the same thing grinding noises so I took it in again and got the same results now mind you this is way before my power train was up. The car felt so unstable and unsafe it got to the point where I had to just leave it at the dealership until Ford could help me with some financial assistance. While at the dealership Ford told the mechanic to check the transmission and upon checking the transmission the mechanic found a problem. The total of repairs came up to over 10k for a vehicle that doesn’t even have 65k miles on it. I was sold a brand new lemon. This was my first new car purchase and it has literally been the worst experience in my life. The brakes were recalled the fuel injection system now the battery which I’ve already spent 500$ on a new one last year has guess what? Been recalled as of 1/17/2025. So after thousands of dollars in rental car and Uber rides which I have yet to be reimbursed for my vehicle is still at the Ford dealership has been there for over 3 months out of 10k in repairs Ford offered to pay only 4,100. What a rip off buying this junk was. I really thought Ford would do the right thing and take care of its customers but I was wrong dead wrong. Biggest mistake of my like.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640480February 3, 2025
ELECTRICAL SYSTEM
The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at various speeds, the navigation screen intermittently went blank. The contact stated that a "System off to Save Battery Please turn ignition off or start engine," message was displayed on the navigation screen. The contact stated that over time, the instrument panel also went blank and other electrical features also failed to operate as needed. The vehicle was taken to several dealers and an independent mechanic to replace the battery; however, the failure returned after each visit. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 28,660. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640423February 3, 2025
ELECTRICAL SYSTEM, POWER TRAIN
The contact owns a 2021 Ford Bronco Sport. The contact stated while the vehicle was parked, the transmission failed to shift to park. The battery warning light was illuminated, and the "Charging System Service Now" message was displayed on the instrument panel. The contact researched and was made aware of NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); however, the VIN was not included. The vehicle was taken to an independent mechanic to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 122,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640318February 3, 2025
ELECTRICAL SYSTEM
The contact owns a 2021 Ford Bronco Sport. The contact stated that after a year of driving the vehicle, the battery was drained upon an attempt to start the vehicle. The contact was forced to jumpstart the battery to drive the vehicle. The contact took the vehicle to a dealer and paid out-of-pocket to replace the battery. The contact stated that almost two weeks later, the battery failure returned and the was taken back to the same dealer. The contact was provided a loaner vehicle while the dealer inspected the battery. The vehicle was returned several days later because the dealer found no defect with the battery. The contact recently stated that upon starting the vehicle, the failure returned. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available; the contact was then referred to the NHTSA Hotline to report the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure was 21,626. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639671January 30, 2025
ELECTRICAL SYSTEM
August 2024 had multiple instances where the Bronco Sport would stall out while driving, had to maneuver to the side of the road, turn the vehicle completely off, and try multiple times to restart the vehicle. Jack Demmer Ford sent a technician to our house to flash the Powertrain Control Module and Body Control Module. We saw the Part 573 Safety Recall Report 24V-267, where these modules were undercharging the battery, causing the stalling of the vehicle. The vehicle stalled out two more times after the update and has continued to run thereafter. On [XXX], Bronco Sport was struck from behind on the driver's side rear tire, car came to rest against the back axle. There was damage to the axle, rear quarter panel, tail light, and aligned rear tailgate. The vehicle battery was disconnected 12-15 times during the work, we would get messages on the app that "Remote features disabled to preserve battery" as they worked on the vehicle. The vehicle was finally ready on [XXX], for pickup. Drove the car approximately 22 miles and parked in the garage. The following morning we went to start the Bronco and there was a loud bang when we pushed the start button, and all electrical features were dead. We had to vacate the vehicle, all the power features were dead, unload, and take another vehicle for travel. When we returned on [XXX], I popped open the hood and discovered battery damage. Battery acid leaked out into a 5-foot puddle on the garage floor, power steering reservoir drained also. [XXX] had Jack Demmer Ford tow the vehicle back to their facility, they charged for inspection and denied any responsibility for battery failure. Had to have the battery replaced so they could fix the rear damage that was not done correctly the first time. This caused another claim to be filed with insurance. Now Ford is recalling Bronco's due to battery concerns. Continuous undercharging of lead battery causes sulfation, shortening battery life. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639359January 29, 2025
ENGINE, FUEL/PROPULSION SYSTEM, VISIBILITY/WIPER
The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. All recall for 1.5L and I am sure the badlands have the same parks and is not included in the recall. less than 60,00o mile with a check engine light on. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere. Please add recall to cover Badland if they contain same parks as 1.5L!!!! Also the windshield wiper pump did not work. I can not clean the windshield wen needing to see out of it. i have to pull over and clean at local gas station.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639343January 29, 2025
ELECTRICAL SYSTEM
Battery failed exactly as described in Ford recall 25S02 NHTSA# 25V019. On 11/1/24 drove vehicle 125 miles home on a return trip and parked car in garage. Morning of 11/2/24, vehicle would not start, battery is dead. Tried to charge battery with external charger, would not take a charge. Called dealer, scheduled appointment for 11/4/24. Morning of 11/4/24, started vehicle with a jump box, took vehicle to dealer. Vehicle would not start when shut off at Dealer. Lucky have made it there, I had shut off the auto restart vie dash button, if I had not shut it off, I would have been stranded at my first traffic stop. Dealer determined it was a failed battery, replaced it at a cost of $510 as vehicle was 2 weeks out of warranty. I reluctantly paid the $510. I was lucky that the vehicle did not start running on that (11/1/25) 125 mile drive, the battery was almost dead at the end of the trip, and of course, it would have stalled when battery got too low. There were in-dash warning messages about low battery near the end of the trip. Ford and the dealership won't reimburse me for the $510. They state that they have to test the battery under the recall, even though that original battery was disposed of by the dealership. Dealership wants to test the 2 month old replacement battery under the recall before they can do anything about a refund. That makes no sense, the replacement almost certainly will test ok.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638334January 24, 2025
ELECTRICAL SYSTEM
In August of 2024, my vehicle shut down after sitting at a red light. The vehicle would not turn back on nor could I put it in neutral to move it out of the way of traffic. It was explained to me that the battery was bad and had to be replaced when I took it in for service the next day. A recall was placed on my vehicle yesterday related to battery issues and I suspect my prior battery had the same issue as referenced in the recall. My car at the time was under 40,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638226January 24, 2025
ELECTRICAL SYSTEM
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the Auto START/STOP technology failed to start the vehicle while depressing the accelerator. The contact had to connect a portable charger to be able to restart the vehicle and continue driving. The failure recurred and the engine failed to restart. The vehicle was towed to a certified mechanic who diagnosed and determined that the battery was drained and needed to be replaced. The vehicle was repaired. The dealer was not contacted. The manufacturer was made aware of the failure and informed the contact that the part for the recall repair would be available approximately in April 2025. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 59,340. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638084January 23, 2025
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
This has been an ongoing issue since I purchased the vehicle in July 2024. It has become so bad that the vehicle is nearly un-driveable. FORD states it is a non-issue, non safety related and there is no know fix at this time. FORD has been buying vehicles back due to this "secret recall" but after numerous calls and visits to both dealers and the Ford customer care line, nothing is being done. And while FORD might state it is an "inconvenience", when driving on the highway and a cylinder just randomly shuts down, the vehicle loses power and backfires and vibrates it is a safety concern. I have been EXTREMELY patience and professional in all my dealings with FORD on this matter, yet they refuse to offer me any help or come to a resolution in my case.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11637501January 21, 2025
POWER TRAIN
Complained numerous times about a clunk noise art parking lot speeds Finally on my Ford dealer 7/10/24 they diagnosed TSB 24-2185 and had me pay $433.53 to replace Vent Hose not covered under my powertrain warranty My mileage was 48986 on that date If part was labeled as RDU Vent hose why not covered under power train warranty? The day I was there, they has another Bronco in with this same issue they told me The service department told they wouldn't be surprised if thus became a recall. I don't see any recall to this day for this issue Ford knows about
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636940January 19, 2025
ELECTRICAL SYSTEM, SERVICE BRAKES, UNKNOWN OR OTHER
Rear brakes are noisy, they make a grinding noise. Ever since we got the vehicle . Screens turn black while driving , can control infotainment system Water gets into the vehicle when it rains or when getting car washed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636144January 15, 2025
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells like fuel is burning and fumes enter into the cabin. When you push start after fueling it struggles to turn car on to drive. There is full accessory power but no power to drive the car even when giving it gas. It requires multiple attempts at starting the vehicle and it will tremble and shake once it starts running and stutters as if about to shut off even when you start driving it. Today it powered down again while driving and we avoided and accident but it is becoming dangerous to drive the vehicle due to its unpredictable shutting down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634942January 8, 2025
ELECTRICAL SYSTEM
The contact owns a 2021 Ford Bronco Sport. The contact stated while his son was driving 55 MPH, several unknown warning lights illuminated. The steering wheel then seized. The vehicle was towed to the dealer and the battery was replaced. The technician inspected the alternator and stated that the alternator could not be replaced since it was fully charged. The contact stated that during the second failure, the emergency brake was applied independently. The vehicle was towed to a Walmart Service Center waiting to be towed by Ford's road side assistance. The manufacturer was not notified of the failure. The approximate failure mileage was 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634796January 8, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, ENGINE
The vehicle has been in the shop since day one with many many problems! The TURBO failed under warranty so they replaced it without doing proper procedures. A few months later the turbo failed again out of warranty but this time cracked the head causing damages I can not afford!! The vehicle is sitting at the dealership not fixed!! I want out of this lemon!!! I tried getting them to buy it back when I took it to the shop three different times due to break issues they could not fix but a Ford representative told me it "had too many miles" I work out of this vehicle and have not been able to work now for three months!! Note...after the first TURBO was replaced I told the dealership the vehicle was loosing antifreeze but all they did was pressure check the radiator. A few months later engine failure due to turbo failure!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634786January 8, 2025
POWER TRAIN
Tranmission failed at 137k miles. Inspection revealed the tranmission was beyond repair and would have to be replaced. Last maintenance was tranmission fluid change at 95k miles by Ford dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634503January 7, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The battery that came with the vehicle lasted less than 2 years. It was replaced after one day the car just wouldn’t hold any charge. I have the pep boys receipt and record to prove the battery would no longer hold any charge.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport