Chevrolet Suburban Complaints (2005)

229 consumer complaints on file.

#11128213September 8, 2018
SERVICE BRAKES
THE 2005 CHEVROLET SUBURBAN 2500 WAS TRAVELING ON A CITY STREET AND THE BRAKES BECAME SOFT INSTANTLY, A COLLISION WAS AVOIDED BY STEERING AWAY FROM THE CARS AT THE INTERSECTION AND THE EMERGENCY BRAKE WAS USED. THERE WAS NO WARNING ON THE SUDDEN FAILURE, OTHER THAN A INDICATOR ON THE DASH. A SHORT DRIVE TO THE HOME DRIVEWAY, THE REMAINING BRAKE FLUID HAS ALL LEAKED OUT UNDER THE DRIVERS DOOR LOCATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11102991June 21, 2018
ENGINE, POWER TRAIN
IN MOTION ON CITY AND HIGHWAY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11084513April 11, 2018
ELECTRICAL SYSTEM, SEATS
DRIVER SIDE SEAT HEATER RANDOMLY COMES ON AND GOES OFF. MAJORITY OF THE TIME THE HEATER STAYS ON CONSTANTLY AND BECOMES UNCOMFORTABLE. THIS HAPPENS MORE ESPECIALLY IN WET CONDITIONS AND WHEN YOU ATTEMPT TO TURN THE HEATED SEAT OFF, THE CONTROLS WON'T WORK. THIS ISSUE HAPPENS WHEN THE SUV IS STARTED, CONTINUES WHILE IDLING AND WHILE DRIVING. SOME DAYS IT IS HOURS BEFORE IT WILL GO OFF. OTHER DAYS IT WILL NOT GO OFF. THE SCARY THING IS YOU CAN HEAR THE DASHBOARD CLICKING WHEN THE HEATER TURNS ON AND OFF, CONSTANTLY CYCLING THOUGH HIGH TO LOW, BACK OF SEAT TO BOTTOM OF THE SEAT. ADJUSTING THE SEAT IN ANY WAY DOES NOT HELP. I THINK THIS IS A CONCERN DUE TO THE FACT THAT IT TURNS OFF AND ON AND YOU CAN HEAR IT CYCLE THROUGH. IT'S ALSO A MAJOR CONCERN BECAUSE THE HEAT STAYS ON WITHOUT ANY WAY TO TURN IT OFF. THIS STARTED A WEEK AFTER I PURCHASED THIS VEHICLE AND HAS CONTINUED SINCE OCTOBER 2016.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11082438April 2, 2018
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, SUSPENSION
THE FUEL LINE THAT IS ON TOP OF THE GAS TANK ROTTED THROUGH. THE BRAKE AND TRANSMISSION LINES ROTTED AND LEAKED. THE CHASSIS IS ROTTING IN DIFFERENT PLACES I HAVE LESS THAN 77,000 MILES ON IT SINCE I BOUGHT NEW. I HAVE A 1969 MALIBU THAT I'VE HAD SINCE IT WAS NEW AND I KEEP IT OUTSIDE IN ALL KINDS OF WEATHER AND NOT ONE PART OF THE CHASSIS IS ROTTED. I DON'T KNOW WHAT KIND OF STEEL THEY USE NOW TO BUILD THESE CARS AND TRUCKS, BUT IT SHOULD BE UNACCEPTABLE. I DON'T KNOW THE EXACT DATES THESE THINGS HAPPENED, BUT I DO HAVE ALL THE REPAIR BILLS FOR THEM. WHEN THE BRAKE LINE ROTTED THROUGH I WAS GOING TO THE STORE AND WHEN I CAME TO A YIELD SIGN THE BRAKE PEDAL WHET TO THE FLOOR. IT'S A GOOD THING IT HAPPENED THEN, BECAUSE I LIVE ON A MOUNTAIN AND WE HAVE A ROAD CALLED BREAKNECK AND IT IS A 25% GRADE. IT WAS RAINING THE DAY THAT THIS HAPPENED AND ALL I HAD WAS A LITTLE BIT OF FOOT BRAKE AND THE EMERGENCY BRAKE. I SURELY WOULD HAVE HAD A BAD ACCIDENT IF I MADE IT TO THAT HILL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11001518June 26, 2017
SERVICE BRAKES
I HAD A RUSTED BRAKE LINE (DRIVER SIDE FRONT) FAIL JUNE 25TH, 2017. THIS TRUCK IS 12 YEARS OLD AND HAS LESS THAN 90,000 MILES. IMMEDIATELY ALL BRAKING WAS LOST AND THE PEDAL PUSHED TO THE FLOOR. REPEATED PRESSING THE BRAKE ONLY PUMPED OUT ALL THE BRAKE FLUID. THIS WAS A SUDDEN AND CATASTROPHIC LOSS OF BRAKING. THE WORST PART IS, BRAKING IS SUPPOSED TO BE SPLIT AND INDEPENDENT BETWEEN FRONT AND REAR BRAKES, SO IF YOU LOSE THE FRONT, THE REAR BRAKES STILL WORK, AND VICE VERSA. WELL I LOST ALL BRAKING, I HAD NO FRONT OR REAR BRAKING! THIS SHOULD BE A CLEAR SAFETY PROBLEM AND A MANDATORY RECALL! I CRASHED INTO THE CAR IN FRONT OF ME, BECAUSE OF COURSE MY EMERGENCY BRAKE DIDN'T WORK EITHER. DESPITE GM'S INSISTENCE THAT SOMEHOW THIS PREMATURE BRAKE LINE FAILURE IS NORMAL AND THE OWNER'S MAINTENANCE PROBLEM, IT SHOULD BE A VERY SIMPLE ISSUE FOR THE NHTSA TO SIMPLY OPEN A SINGLE BRAKE LINE AND TEST TO REALIZE THE AFFECTED VEHICLES DO IN FACT LOSE ALL BRAKING, NOT JUST FRONT OR REAR. I'VE ALREADY COMPLETELY LOST FAITH IN GM TO DO THE RIGHT THING, BUT I'D LIKE TO BELIEVE THE NHTSA WILL STILL DO THE RIGHT THING, AND NOT LET GM OFF WITH A CLEAR SAFETY PROBLEM WITH THEIR BRAKE DESIGN. THIS CRASH WAS PULLING UP TO THE STOPLIGHT IN PRESCOTT, WI, HEADING INTO TOWN ACROSS THE PRESCOTT BRIDGE. I WAS DRIVING MAYBE 30 MPH WHEN I REALIZED I HAD LOST ALL BRAKES.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10953672February 9, 2017
AIR BAGS
FOR APPROXIMATELY THE LAST 4 YEARS THE AIRBAG LIGHT HAS BEEN ON INDICATING AN ISSUE WITH THE AIRBAG SYSTEM. GIVEN ALL THE AIRBAG PROBLEMS IN RECENT YEARS AND THE FACT THIS SEEMS TO BE A COMMON PROBLEM WITH 2005 GM SUVS AND GIVEN AIRBAGS ARE VITAL SAFETY EQUIPMENT GM NEEDS TO PROVIDE OWNERS WITH THESE PROBLEMS A FREE FIX OR BE FORCED TO RECALL THESE VEHICLES IMMEDIATELY FOR REPAIRS BEFORE ALOT OF PEOPLE GET HURT OR KILLED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937319December 24, 2016
AIR BAGS
ONE MORNING CAME OUT TO START MY 2005 SUBURBAN AND THE SERVICE AIRBAG MESSAGE POPPED ON ALONG WITH THE AIRBAG LIGHT. TOOK IT TO MY SERVICE CENTER AND WAS TOLD IT WAS A FRONT IMPACT SENSOR. WAS ALSO TOLD THIS IS A COMMON PROBLEM ON THESE VEHICLES. AFTER DOING SOME RESEARCH ONLINE I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM RENDERING THE AIRBAG SYSTEM INOP. I BELIEVE GM NEEDS TO STEP UP AND FIX THE ISSUE WITH THE SENSORS AS NOT EVERYONE HAS $400 TO FIX A FAULTY SENSOR. THE ODOMETER ON MY SUBURBAN IS 127,000 MILES, SO BY NO MEANS DRIVEN HARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10893888August 8, 2016
AIR BAGS, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875030June 18, 2016
WHEELS
IT WOULDN'T LET ME PICK TIRES I HAVE A SET OF 4 BRIDGESTONE DEULER H/L AND THE TIRES HAVE 2 TIRES HAVE 6/32 OF TREAD AND THE OTHER 2 HAD 8/32 AND ON ALL 4 TIRES THE BELTS ARE SEPARATING !!! I USED TO HAVE A CDL LICENSE AND DRIVE TOW TRUCKS AND IF I GOT PULLED OVER BY THE STATE WHETHER IT BE BY D.O.T. OR STATE POLICE I WOULD RECEIVE TICKETS AND POSSIBLY BE STUCK AT WEIGH STATION WAITING FOR A TIRE REPAIR SERVICE TO SHOW UP !!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872881June 7, 2016
SERVICE BRAKES
REAR BRAKE LINE FAILED. MY WIFE AND KIDS WERE IN THE 2005 SUBURBAN 1500, SHE MANAGED TO PRESS THE EBRAKE THEN TURN THE SUBURBAN INTO SOMEONE'S FRONT YARD WHERE IT EVENTUALLY CAME TO REST ON A HILL. SHE WAS HEADED DOWNHILL ON A RESIDENTIAL STREET AT THE TIME OF FAILURE. TOOK TO HUNDRU CHEV IN MANHEIM PA I WAS TOLD THE REPAIR WILL BE SOMEWHERE AROUND $2300.00
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10865800May 19, 2016
STRUCTURE:BODY:HATCHBACK/LIFTGATE
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE ATTEMPTING TO USE THE REAR HATCH OF THE VEHICLE, THE REAR HATCH FAILED TO OPEN. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,210.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10863519May 5, 2016
AIR BAGS
I TURNED MY 2005 SUBURBAN ON AND THE AIR BAG LIGHT CAME ON. I TOOK IT IN TO THE CHEVY/GM DEALER WHO SAID, "THE RIGHT, FRONT, AIR BAG SENSOR WAS THE CAUSE." IT WOULD COST $375 TO FIX IT. I DID NOT GET IT FIXED AT THAT TIME. IT IS DANGEROUS BECAUSE THE AIR BAGS ARE INOPERABLE. THE PROBLEM OCCURRED AT ABOUT 150,000 MILES. FROM WHAT I HAVE SEEN THIS IS A HUGE PROBLEM THAT NEEDS TO BE ADDRESS BY THE COMPANY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10849566March 14, 2016
SEATS
WHILE DRIVING THE DRIVER SIDE HEATED SEATS INGAUGE BY THEMSELVES AND COME ON EVERY TIME WE USE THE VEHICLE. WE HAVE TRIED TURNING THEM BACK OFF, BUT THEY COME RIGHT BACK ON AND WILL CYCLE UP AND DOWN A FEW TIMES THEN STAY IN THE HIGH POSITION. I THOUGHT AT FIRST THAT MY HUSBAND WAS ACCIDENTALLY TURNING THEM ON BUT HE WASN'T. IT DOES IT ALL THE TIME. THERE IS NO RYHME OR REASON TO IT. ITS VERY DISTRACTING TRYING TO TURN THEM OFF OVER & OVER AGAIN. I COULD SEE WHERE IT COULD BE A SAFETY ISSUE. I RESEARCH END ON THE INTERNET AND HAVE SEEN HUNDREDS OF POST ON THE SAME ISSUE. NONE OF THEM HELPED WITH A SOULOUTIN TO THE PROBLEM. I PUT MY VIN # IN TO SEE IF THEIR WERE ANY RECALLS ON THIS ISSUE. AND COULDN'T FIND ONE. MY QUESTION IS WHY? WITH AS MANY COMPLAINTS AS THERE ARE ONLINE. NOT SURE IF THEY WERE NOT COMPLAINING HERE ABOUT IT BUT NOW AT LEAST I HAVE. IT DOESN'T MATTER WHOSE DRIVING IT, WHEATER ISN'T A FACTOR EITHER. IN TOWN OR HIGHWAY MAKES NO DIFFERENCE HELP PLEASE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10807658December 1, 2015
SERVICE BRAKES
AS I WAS ABOUT TO EXIT A PARKING LOT ONTO A FOUR LANE ROADWAY, THE BRAKES ON MY 2005 CHEVROLET SUBURBAN FAILED. I LIVED APPROXIMATELY 1/2 MILE FROM THIS LOCATION AND PROCEEDED TO DRIVE HOME. IT WAS A LITTLE SCAREY WITHOUT ANY STOPPING POWER, EVEN THE EMERGENCY BAKE WOULD NOT HOLD. WHEN I GOT HOME, I USED A FLASHLIGHT TO TRY TO FIND THE SOURCE OF THE PROBLEM. FOUND A PATTERN OF BRAKE FLUID LEAKING. REMOVED THE SPARE TIRE TO GET A BETTER LOOK AND FOUND A BRAKE LINE BETWEEN THE ABS AND REAR OF THE VEHICLE HAD RUSTED OUT. FROM THE LOOKS OF THE LINE CONDITION, THEY NEED TO BE ALL REPLACED. NEVER IN MY 70 YEARS HAVE I SEEN BRAKE LINES ON A TEN YEAR OLD VEHICLE LOOK LIKE THEY DID, REALLY IN BAD SHAPE. LOOKED AT OTHER LINES, FUEL, TRANSMISSION, THEY ALL LOOKED LIKE THEY SHOULD BE REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10766829September 21, 2015
SERVICE BRAKES
FIRST INCIDENT EASTERN PA: 05/19/2014 APROX 119000 MILES: AFTER HITTING THE BRAKES HARD TO AVOID A VEHICLE THAT PULLED IN FRONT OF ME, THE BRAKES FAILED (BRAKE PEDAL WOULD GO TO THE FLOOR WITH LITTLE BRAKING ACTION). MANAGED TO SAFELY STOP. FOUND BURST BRAKE LINE IN THE REAR END OF VEHICLE. TWO REAR CORRODED REAR BRAKE LINES REPLACED BY LOCAL REPAIR SHOP. SECOND INCIDENT MILFORD MA: 09/17/2015 127336 MILES: HIT BRAKES GOING DOWN DRIVEWAY. BRAKES WERE SOFT AND SANK TO FLOOR. BRAKE LINE GOING TO FRONT PASSENGER WHEEL WAS BURST. ALL THE BRAKE FLUID DRAINED QUICKLY OUT OF THE MASTER CYLINDER ONTO THE DRIVEWAY. ORDERED ACDELCO 22932592 GM ORIGINAL EQUIPMENT HYDRAULIC BRAKE PIPE KIT AND AM IN THE PROCESS OF REPLACING ALL BRAKE LINES AS ALL OF THEM OTHER THAN THE TWO REPLACED IN PA ARE VERY CORRODED. THE REPLACEMENT LINES ARE NOT REALLY OEM AS THEY HAVE A NYLON COATING FOR BETTER CORROSION PROTECTION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10760317August 31, 2015
UNKNOWN OR OTHER
THE REAR LIFTGATE WILL NOT UNLOCK. THERE IS NO MANUAL RELEASE OR "KEY BYPASS" FOR THE REAR LIFTGATE LOCK. THIS PRESENTS A SERIOUS SAFETY ISSUE IN CASE OF FIRE OR CRASH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10732867July 9, 2015
FUEL/PROPULSION SYSTEM
AFTER RUNNING VEHICLE, GAS RUNS DOWN SIDES FROM TOP OF FUEL TANK, AND DRIPS UNDER VEHICLE. CONTINUES TO DRIP IF CAR IDLES. STOPS IF CAR IS SHUT OFF. STRONG SMELL OF FUEL AFTER DRIVING VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10723112June 3, 2015
AIR BAGS
AIR BAG SENSOR FAILURE RENDERING THE AIRBAGS INOPERABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10721293May 25, 2015
POWER TRAIN
BEGAN HEARING A "WHINING" NOISE UNDER THE VEHICLE. NOISE WAS PROGRESSIVELY LOUDER AT ACCELERATED SPEEDS. LEFT VEHICLE AT LOCAL CHEVROLET DEALER (CA) WHO DID AN INSPECTION AND DIAGNOSED A MECHANICAL ISSUE POSSIBLY WITH THE DIFFERENTIAL [REF. CLAIM CHECK 175]. SERVICE WRITER STATED ESTIMATED REPAIR COST FOR AN OVERHAUL WAS $3,000 VS. HIGHER COSTS TO REPLACE WITH USED OR NEW DIFFERENTIAL. SERVICE WRITER FURTHER INDICATED CONTINUED DRIVING COULD CAUSE FURTHER DAMAGE AND ADDED COST IF AXLE WAS ALSO AFFECTED. DECIDED TO TAKE VEHICLE TO A RECOGNIZED POWERTRAIN REPAIR FACILITY WHO DETERMINED (ALSO WITH A DRIVE TEST) THAT THE DIFFERENTIAL WAS THE PROBLEM AND GAVE INITIAL $1,200 ESTIMATE. AUTHORIZED REPAIR. FINAL COST WAS $813 AND INCLUDES 1 YEAR FULL WARRANTY. NOW RUNS SMOOTH / QUIET WHEN DRIVING. TECHNICIAN INDICATED THAT ALTHOUGH FLUID LEVEL WAS GOOD (SEALED AT FACTORY), A RING INSIDE THE DIFFERENTIAL WAS BAD (HAD BECOME PITTED AND COULD HAVE CAUSED FURTHER ISSUES IF UNCHECKED. CHANGED OUT RING AND BEARINGS BUT ALL OTHER COMPONENTS INCLUDING CASING WERE FINE. TECHNICIAN STATED SUCH WEAR IS UNCOMMON FOR A VEHICLE WITH ONLY 126K MILES AND WITH NO TOWING ON FACTORY TOW PACKAGE. IS THIS AN ANNOMILY OR ARE THERE OTHER CASES OF BAD PARTS IN DIFFERENTIAL FOR THIS MAKE / MODEL? WOULD LIKE TO DISCUSS FURTHER WITH GM ZONE REP. BUT NO RESPONSE!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10715251May 7, 2015
SERVICE BRAKES
WHILE DRIVING AROUND TOWN I NOTICED MY BRAKES FEELING MUSHY AND THE PEDAL NEEDING TO BE PRESSED FURTHER INTO THE FLOORBOARD. MY "CHECK BRAKE SYSTEM" LIGHT CAME ON AND UPON INSPECTION NOTICED THAT I WAS LOW ON BRAKE FLUID. I FILLED THE BRAKE FLUID RESERVOIR TO THE MAX LINE. THE NEXT DAY THE SAME WARNING LIGHT CAME ON AND I FURTHER INSPECTED THE BRAKE LINES TO FIND THAT THE LINES FROM THE ABS BOX TO THE REAR HAD RUSTED OUT AND WERE LEAKING BADLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban